Highly efficient and selective removal of phosphate from wastewater of sea cucumber aquaculture for microalgae culture using a new adsorption-membrane separation-coordinated strategy

Abstract

● A new adsorption-membrane separation strategy is used for phosphate removal.

● PVC/Zr-BT shows a selective adsorption ability to low-concentration phosphate.

● Low concentration of P below 0.05 mg/L was achieved in actual wastewater treatment.

● Algal biomass production served as a demonstration of phosphorus recycling.

Enhanced phosphorus treatment and recovery has been continuously pursued due to the stringent wastewater discharge regulations and a phosphate supply shortage. Here, a new adsorption-membrane separation strategy was developed for rational reutilization of phosphate from sea cucumber aquaculture wastewater using a Zr-modified-bentonite filled polyvinyl chloride membrane. The as-obtained polyvinyl chloride/Zr-modified-bentonite membrane was highly permeability (940 L/(m²·h)), 1–2 times higher than those reported in other studies, and its adsorption capacity was high (20.6 mg/g) when the phosphate concentration in water was low (5 mg/L). It remained stable under various conditions, such as different pH, initial phosphate concentrations, and the presence of different ions after 24 h of adsorption in a cross-flow filtration system. The total phosphorus and phosphate removal rate reached 91.5% and 95.9%, respectively, after the membrane was used to treat sea cucumber aquaculture wastewater for 24 h and no other water quality parameters had been changed. After the purification process, the utilization of the membrane as a new source of phosphorus in the phosphorus-free f/2 medium experiments indicated the high cultivability of economic microalgae Phaeodactylum tricornutum FACHB-863 and 1.2 times more chlorophyll a was present than in f/2 medium. The biomass and lipid content of the microalgae in the two different media were similar. The innovative polyvinyl chloride/Zr-modified-bentonite membrane used for phosphorus removal and recovery is an important instrument to establish the groundwork for both the treatment of low concentration phosphate from wastewater as well as the reuse of enriched phosphorus in required fields.

Graphical abstract

Keywords

Adsorption-membrane / Low-concentration phosphate / Zr-modified-bentonite / Recycle / Microalgal culture

References

[1] Acelas N Y, Martin B D, López D, Jefferson B. (2015). Selective removal of phosphate from wastewater using hydrated metal oxides dispersed within anionic exchange media. Chemosphere, 119: 1353–1360

[2] Ahmad T, Liu X, Guria C. (2023). Preparation of polyvinyl chloride (PVC) membrane blended with acrylamide grafted bentonite for oily water treatment. Chemosphere, 310: 136840

[3] Aketo T, Waga K, Yabu Y, Maeda Y, Yoshino T, Hanada A, Sano K, Kamiya T, Takano H, Tanaka T. (2021). Algal biomass production by phosphorus recovery and recycling from wastewater using amorphous calcium silicate hydrates. Bioresource Technology, 340: 125678

[4] Batstone D J, Hulsen T, Mehta C M, Keller J. (2015). Platforms for energy and nutrient recovery from domestic wastewater: a review. Chemosphere, 140: 2–11

[5] Cakmak E K, Hartl M, Kisser J, Cetecioglu Z. (2022). Phosphorus mining from eutrophic marine environment towards a blue economy: the role of bio-based applications. Water Research, 219: 118505

[6] Chen L, Liu F, Wu Y, Zhao L, Li Y, Zhang X, Qian J. (2018). In situ formation of La(OH)₃-poly(vinylidene fluoride) composite filtration membrane with superior phosphate removal properties. Chemical Engineering Journal, 347: 695–702

[7] Davies I P, Carranza V, Froehlich H E, Gentry R R, Kareiva P, Halpern B S. (2019). Governance of marine aquaculture: pitfalls, potential, and pathways forward. Marine Policy, 104: 29–36

[8] Delavar M, Bakeri G, Hosseini M. (2017). Fabrication of polycarbonate mixed matrix membranes containing hydrous manganese oxide and alumina nanoparticles for heavy metal decontamination: Characterization and comparative study. Chemical Engineering Research & Design, 120: 240–253

[9] Fu C, Tran H N, Chen X, Juang R S (2020). Preparation of polyaminated Fe₃O₄@chitosan core-shell magnetic nanoparticles for efficient adsorption of phosphate in aqueous solutions. Journal of Industrial and Engineering Chemistry, 83: 235–246

[10] Gan Y, Wang X, Zhang L, Wu B, Zhang G, Zhang S. (2019). Coagulation removal of fluoride by zirconium tetrachloride: performance evaluation and mechanism analysis. Chemosphere, 218: 860–868

[11] Gao Q, Wang C, Liu S, Hanigan D, Liu S, Zhao H. (2019). Ultrafiltration membrane microreactor (MMR) for simultaneous removal of nitrate and phosphate from water. Chemical Engineering Journal, 355: 238–246

[12] Gu Y, Xie D, Ma Y, Qin W, Zhang H, Wang G, Zhang Y, Zhao H. (2017). Size modulation of zirconium-based metal organic frameworks for highly efficient phosphate remediation. ACS Applied Materials & Interfaces, 9(37): 32151–32160

[13] Huang Q, Luo K, Pi Z, He L, Yao F, Chen S, Hou K, Liu Y, Li X, Yang Q. (2022). Zirconium-modified biochar as the efficient adsorbent for low-concentration phosphate: performance and mechanism. Environmental Science and Pollution Research International, 29(41): 62347–62360

[14] Jamshidi Gohari R, Lau W J, Matsuura T, Ismail A F. (2013). Fabrication and characterization of novel PES/Fe-Mn binary oxide UF mixed matrix membrane for adsorptive removal of As(III) from contaminated water solution. Separation and Purification Technology, 118: 64–72

[15] Kumar P S, Korving L, van Loosdrecht M C M, Witkamp G J. (2019). Adsorption as a technology to achieve ultra-low concentrations of phosphate: research gaps and economic analysis. Water Research X, 4: 100029

[16] Liu S, Chen H, Xu X, Liu S, Sun K, Zhao J, Ying G. (2015a). Steroids in marine aquaculture farms surrounding Hailing Island, South China: occurrence, bioconcentration, and human dietary exposure. Science of the Total Environment, 502: 400–407

[17] Liu X, Lan S, Ni J. (2015b). Electrically assisted friction stir welding for joining Al 6061 to TRIP 780 steel. Journal of Materials Processing Technology, 219: 112–123

[18] Liu X, Zhang L. (2015). Removal of phosphate anions using the modified chitosan beads: adsorption kinetic, isotherm and mechanism studies. Powder Technology, 277: 112–119

[19] Luo H, Xiang Y, He D, Li Y, Zhao Y, Wang S, Pan X. (2019). Leaching behavior of fluorescent additives from microplastics and the toxicity of leachate to Chlorella vulgaris. Science of the Total Environment, 678: 1–9

[20] Nguyen T, Ngo H, Guo W, Nguyen T, Zhang J, Liang S, Chen S, Nguyen N. (2014). A comparative study on different metal loaded soybean milk by-product ‘Okara’ for biosorption of phosphorus from aqueous solution. Bioresource Technology, 169: 291–298

[21] Pawar R R, Gupta P, Lalhmunsiama H C, Bajaj S M. (2016). Al-intercalated acid activated bentonite beads for the removal of aqueous phosphate. Science of the Total Environment, 572: 1222–1230

[22] RazmjouA, Mansouri J, ChenV (2011). The effects of mechanical and chemical modification of TiO₂ nanoparticles on the surface chemistry, structure and fouling performance of PES ultrafiltration membranes. Journal of Membrane Science, 378(1–2): 73–84

[23] Song M, Li M, Liu J. (2017). Uptake characteristics and kinetics of inorganic and organic phosphorus by Ceratophyllum demersum. Water, Air, and Soil Pollution, 228(11): 407

[24] Su Y, Cui H, Li Q, Gao S, Shang J. (2013). Strong adsorption of phosphate by amorphous zirconium oxide nanoparticles. Water Research, 47(14): 5018–5026

[25] Ventrella A, Catucci L, Piletska E, Piletsky S, Agostiano A. (2009). Interactions between heavy metals and photosynthetic materials studied by optical techniques. Bioelectrochemistry (Amsterdam, Netherlands), 77(1): 19–25

[26] Wan J, Zhu C, Hu J, Zhang T, Richter-Egger D, Feng X, Zhou A, Tao T. (2017). Zirconium-loaded magnetic interpenetrating network chitosan/poly(vinyl alcohol) hydrogels for phosphorus recovery from the aquatic environment. Applied Surface Science, 423: 484–491

[27] Wang J, Liu Y, Hu P, Huang R. (2018). Adsorption of phosphate from aqueous Solution by Zr(IV)-crosslinked quaternized chitosan/bentonite composite. Environmental Progress & Sustainable Energy, 37(1): 267–275

[28] Wu Y, Li X, Yang Q, Wang D, Xu Q, Yao F, Chen F, Tao Z, Huang X. (2019). Hydrated lanthanum oxide-modified diatomite as highly efficient adsorbent for low-concentration phosphate removal from secondary effluents. Journal of Environmental Management, 231: 370–379

[29] Xu K, Lin F, Dou X, Zheng M, Tan W, Wang C. (2018). Recovery of ammonium and phosphate from urine as value-added fertilizer using wood waste biochar loaded with magnesium oxides. Journal of Cleaner Production, 187: 205–214

[30] Ye Y, Ngo H, Guo W, Liu Y, Zhang X, Guo J, Ni B, Chang S, Nguyen D. (2016). Insight into biological phosphate recovery from sewage. Bioresource Technology, 218: 874–881

[31] Young E, Beardall J. (2003). Photosynthetic function in Dunaliella tertiolecta (Chlorophyta) during a nitrogen starvation and recovery cycle. Journal of Phycology, 39(5): 897–905

[32] Zhao S, Yan W, Shi M, Wang Z, Wang J, Wang S. (2015). Improving permeability and antifouling performance of polyethersulfone ultrafiltration membrane by incorporation of ZnO-DMF dispersion containing nano-ZnO and polyvinylpyrrolidone. Journal of Membrane Science, 478: 105–116

RIGHTS & PERMISSIONS

Higher Education Press