Impact of roxarsone on the UASB reactor performance and its degradation

Abstract

Impact of continuous ROX addition on performance of UASB reactor was investigated

With continuous ROX addition, severe inhibition to methanogenic activity occurred

ROX addition caused the changes in the morphology and bacterial diversity of AGS

A possible biotransformation pathway of ROX in the UASB reactor was proposed

60%–70% of the arsenic was discharged to the effluent, and 30%–40% was precipitated

Roxarsone (3-nitro-4-hydroxyphenylarsonic acid, ROX) has been widely used for decades as an organoarsenic feed additive to control intestinal parasites and improve feed efficiency in animal production. However, most of the ROX is excreted into the manure, causing arsenic contamination in wastewater. The arsenic compounds are toxic to microorganisms, but the influence of continuous ROX loading on upflow anaerobic sludge blanket (UASB) reactor is still unknown. In this study, the impact of ROX and its degradation products on the performance of the UASB reactor and the degradation and speciation of ROX in the reactor were investigated. The UASB reactor (hydraulic retention time: 1.75 d) was operated using synthetic wastewater supplemented with ROX for a period of 260 days. With continuous ROX addition at 25.0 mg·L^–1, severe inhibition to methanogenic activity occurred after 87 days operation accompanied with an accumulation of volatile fatty acids (VFAs) and a decline in pH. The decrease of added ROX concentration to 13.2 mg·L^–1 did not mediate the inhibition. As(III), As(V), MMA(V), DMA(V), HAPA and an unknown arsenic compound were detected in the reactor, and a possible biotransformation pathway of ROX was proposed. Mass balance analysis of arsenic indicated that 60%–70% of the arsenic was discharged into the effluent, and 30%–40% was precipitated in the reactor. The results from this study suggest that we need to pay attention to the stability in the UASB reactors treating organoarsenic-contaminated manure and wastewater, and the effluent and sludge from the reactor to avoid diffusion of arsenic contamination.

Graphical abstract

Keywords

Anaerobic digestion / Anaerobic granular sludge (AGS) / Arsenic species / Impact / Roxarsone (ROX) / UASB reactor

References

[1] P Mangalgiri K, Adak A, Blaney L. Organoarsenicals in poultry litter: detection, fate, and toxicity. Environment International, 2015, 75: 68–80

[2] Nachman K E, Raber G, Francesconi K A, Navas-Acien A, Love D C. Arsenic species in poultry feather meal. Science of the Total Environment, 2012, 417-418(417–418): 183–188

[3] US Food and Drug Administration. FDA response to citizen petition on arsenic-based animal drugs. Animal & Veterinary. 2013. Available online at: lt;Date>accessed October 10, 2013</Date>)

[4] Yao L, Huang L, He Z, Zhou C, Li G, Deng X. Phosphate enhances uptake of As species in garland chrysanthemum (C. coronarium) applied with chicken manure bearing roxarsone and its metabolites. Environmental Science and Pollution Research International, 2015, 22(6): 4654–4659

[5] Wang H L, Hu Z H, Tong Z L, Xu Q, Wang W, Yuan S J. Effect of arsanilic acid on anaerobic methanogenic process: Kinetics, inhibition and biotransformation analysis. Biochemical Engineering Journal, 2014, 91(91): 179–185

[6] Yang Z, Peng H, Lu X, Liu Q, Huang R, Hu B, Kachanoski G, Zuidhof M J, Le X C. Arsenic metabolites, including N-acetyl-4-hydroxy-m-arsanilic acid, in chicken litter from a roxarsone-feeding study involving 1600 chickens. Environmental Science & Technology, 2016, 50(13): 6737–6743

[7] Bednar A J, Garbarino J R, Ferrer I, Rutherford D W, Wershaw R L, Ranville J F, Wildeman T R. Photodegradation of roxarsone in poultry litter leachates. Science of the Total Environment, 2003, 302(1-3): 237–245

[8] Guo Q, Liu L, Hu Z, Chen G. Biological phosphorus removal inhibition by roxarsone in batch culture systems. Chemosphere, 2013, 92(1): 138–142

[9] Fisher D J, Yonkos L T, Staver K W. Environmental concerns of roxarsone in broiler poultry feed and litter in Maryland, USA. Environmental Science & Technology, 2015, 49(4): 1999–2012

[10] Zhang W, Xu F, Han J, Sun Q, Yang K. Comparative cytotoxicity and accumulation of Roxarsone and its photodegradates in freshwater Protozoan Tetrahymenathermophila. Journal of Hazardous Materials, 2015, 286: 171–178

[11] Kim K W, Bang S, Zhu Y, Meharg A A, Bhattacharya P. Arsenic geochemistry, transport mechanism in the soil-plant system, human and animal health issues. Environment International, 2009, 35(3): 453–454

[12] Sharma V K, Sohn M. Aquatic arsenic: toxicity, speciation, transformations, and remediation. Environment International, 2009, 35(4): 743–759

[13] Adak A, Mangalgiri K P, Lee J, Blaney L. UV irradiation and UV-H₂O₂ advanced oxidation of the roxarsone and nitarsone organoarsenicals. Water Research, 2015, 70(3): 74–85

[14] Zhang F F, Wang W, Yuan S J, Hu Z H. Biodegradation and speciation of roxarsone in an anaerobic granular sludge system and its impacts. Journal of Hazardous Materials, 2014, 279(5): 562–568

[15] Chong S, Sen T K, Kayaalp A, Ang H M. The performance enhancements of upflow anaerobic sludge blanket (UASB) reactors for domestic sludge treatment—a state-of-the-art review. Water Research, 2012, 46(11): 3434–3470

[16] Liu C, Li J, Wang S, Nies L. A syntrophic propionate-oxidizing microflora and its bioaugmentation on anaerobic wastewater treatment for enhancing methane production and COD removal. Frontiers of Environmental Science & Engineering, 2016, 10(4): 1–9

[17] Chávez P C, Castillo L R, Dendooven L, Escamilla-Silva E M. Poultry slaughter wastewater treatment with an up-flow anaerobic sludge blanket (UASB) reactor. Bioresource Technology, 2005, 96(15): 1730–1736

[18] Liu L, You Q Y, Gibson V, Huang X, Chen S H, Ye Z L, Liu C X. Treatment of swine wastewater in aerobic granular reactors: comparison of different seed granules as factors. Frontiers of Environmental Science & Engineering, 2015, 9(6): 1139–1148

[19] Cortinas I, Field J A, Kopplin M, Garbarino J R, Gandolfi A J, Sierra-Alvarez R. Anaerobic biotransformation of roxarsone and related N-substituted phenylarsonic acids. Environmental Science & Technology, 2006, 40(9): 2951–2957

[20] Shi L, Wang W, Yuan S J, Hu Z H. Electrochemical stimulation of microbial roxarsone degradation under anaerobic conditions. Environmental Science & Technology, 2014, 48(14): 7951–7958

[21] Stolz J F, Perera E, Kilonzo B, Kail B, Crable B, Fisher E, Ranganathan M, Wormer L, Basu P. Biotransformation of 3-nitro-4-hydroxybenzene arsonic acid (roxarsone) and release of inorganic arsenic by Clostridium species. Environmental Science & Technology, 2007, 41(3): 818–823

[22] Lu D, Ji F, Wang F, Yuan S, Hu Z H, Chen T. Adsorption and photocatalytic decomposition of roxarsone by TiO₂ and its mechanism. Environmental Science and Pollution Research International, 2014, 21(13): 8025–8035

[23] Sierra-Alvarez R, Cortinas I, Field J A. Methanogenic inhibition by roxarsone (4-hydroxy-3-nitrophenylarsonic acid) and related aromatic arsenic compounds. Journal of Hazardous Materials, 2010, 175(1-3): 352–358

[24] Inskeep W P, Mcdermott T R, Fendorf S, Frankenberger W T. Arsenic (V)/(III) cycling in soils and natural waters: chemical and microbiological processes. In: Environmental chemistry of arsenic. W T Frankenberger, Ed, New York, America: Marcel Dekker. 2002. 183–215.

[25] Sierra-Alvarez R, Cortinas I, Yenal U, Field J A. Methanogenic inhibition by arsenic compounds. Applied and Environmental Microbiology, 2004, 70(9): 5688–5691

[26] MacLeod F A, Guiot S R, Costerton J W. Layered structure of bacterial aggregates produced in an upflow anaerobic sludge bed and filter reactor. Applied and Environmental Microbiology, 1990, 56(6): 1598–1607

[27] Yang S C, He Y L, Liu Y H, Chou C, Zhang P X, Wang D Q. Effect of wastewater composition on the calcium carbonate precipitation in upflow anaerobic sludge blanket reactors. Frontiers of Environmental Science & Engineering in China, 2010, 4(2): 142–149

[28] Yin X X, Chen J, Qin J, Sun G X, Rosen B P, Zhu Y G. Biotransformation and volatilization of arsenic by three photosynthetic cyanobacteria. Plant Physiology, 2011, 156(3): 1631–1638

[29] Qin J, Rosen B P, Zhang Y, Wang G, Franke S, Rensing C. Arsenic detoxification and evolution of trimethylarsine gas by a microbial arsenite S-adenosylmethionine methyltransferase. Proceedings of the National Academy of Sciences of the United States of America, 2006, 103(7): 2075–2080

[30] Garbarino J R, Rutherford D W, Wershaw R L. Degradation of roxarsone in poultry litter. In: Arsenic in the environment, Proceedings of the US Geological Survey Workshop. Denver, CO.,2001

[31] Pinel-Raffaitin P, Le Hecho I, Amouroux D, Potin-Gautier M. Distribution and fate of inorganic and organic arsenic species in landfill leachates and biogases. Environmental Science & Technology, 2007, 41(13): 4536–4541

[32] Lin P F, Zhang X J, Yang H W, Li Y, Chen C. Applying chemical sedimentation process in drinking water treatment plant to address the emergent arsenic spills in water sources. Frontiers of Environmental Science & Engineering, 2015, 9(1): 50–57

[33] Wang H J, Gong W X, Liu R P, Liu H J, Qu J H. Treatment of high arsenic content wastewater by a combined physical–chemical process. Colloids and Surfaces. A, Physicochemical and Engineering Aspects, 2011, 379(1–3): 116–120

[34] Marvin-Sikkema F D, de Bont J A M. Degradation of nitroaromatic compounds by microorganisms. Applied Microbiology and Biotechnology, 1994, 42(4): 499–507

[35] Spain J C. Biodegradation of nitroaromatic compounds. Annual Review of Microbiology, 1995, 49(2): 523–555

[36] Karim K, Gupta S K. Biotransformation of nitrophenols in upflow anaerobic sludge blanket reactors. Bioresource Technology, 2001, 80(3): 179–186

[37] Mestrot A, Xie W Y, Xue X M, Zhu Y G. Arsenic volatilization in model anaerobic biogas digesters. Applied Geochemistry, 2013, 33: 294–297

[38] Rosen B P, Liu Z. Transport pathways for arsenic and selenium: a minireview. Environment International, 2009, 35(3): 512–515

RIGHTS & PERMISSIONS

Higher Education Press and Springer-Verlag Berlin Heidelberg