Deciphering the intermolecular interactions for separating bicyclic and tricyclic aromatics via different naphthalene-based solvents

  • Pengzhi Bei 1 ,
  • Antony Rajendran 2 ,
  • Jie Feng 1 ,
  • Wen-Ying Li , 1
Expand
  • 1. State Key Laboratory of Clean and Efficient Coal Utilization, Taiyuan University of Technology, Taiyuan 030024, China
  • 2. Department of Chemistry, Mepco Schlenk Engineering College, Sivakasi 626005, India
ying@tyut.edu.cn

Received date: 05 Feb 2024

Accepted date: 03 Apr 2024

Copyright

2024 Higher Education Press

Abstract

The traditional separation of bicyclic and tricyclic aromatics from coal tar involves complicated multi-steps and consumes significantly more energy. Previous work accomplished the separation between anthracene-phenanthrene isomers using electrostatic interaction, but for the separation between bicyclic and tricyclic aromatics, electrostatic interactions are difficult to produce a recognizable effect. Naphthalene-based solvents, named as naphthaleneacetamide, naphthaleneethanol, naphthalenemethanol, naphthol, naphthylacetic acid, naphthylacetonitrile, and naphthylamine, respectively, were used for the efficient separation of naphthalene and phenanthrene via dispersion interaction. Results showed that the pre-studied structural parameters are the key factors in selecting an efficient solvent. And the substituents on the intermolecular interactions involved in the separation processes had an important impact, which were evaluated. Naphthalenemethanol exhibited a superior performance with a purity of 96.3 wt % naphthalene products because its electron-donating substituent enables the selective recognition of naphthalene via the dispersion interaction. The used naphthalene-based solvents can be regenerated and recycled via back extraction with a purity of over 90 wt % naphthalene products, suggesting solvent structural stability during the regeneration processes. Notably, the naphthalene-based solvents also demonstrated better separation performance for polycyclic aromatics from coal tar with a purity of over 80 wt % for bicyclic aromatics. This study would enhance the utilization of coal tar as a valuable source of polycyclic aromatics besides broadening the knowledge for applying non-bonded interaction in the separation of polycyclic aromatics technologies.

Cite this article

Pengzhi Bei , Antony Rajendran , Jie Feng , Wen-Ying Li . Deciphering the intermolecular interactions for separating bicyclic and tricyclic aromatics via different naphthalene-based solvents[J]. Frontiers of Chemical Science and Engineering, 2024 , 18(10) : 111 . DOI: 10.1007/s11705-024-2462-9

Competing interests

The authors declare that they have no competing interests.

Acknowledgements

The authors gratefully acknowledge financial support provided by the National Natural Science Foundation of China (Grant No. 22038008) and the China Shenhua Coal-to-Liquids Chemical Co., Ltd. Science and Technology Innovation Project (Grant No. MZYHG-2021-01).

Electronic Supplementary Material

Supplementary material is available in the online version of this article at https://doi.org/10.1007/s11705-024-2462-9 and is accessible for authorized users.
1
Wang Z , Liu W , Xu C , Ji B , Zheng C , Zhang X . Excellent deep-blue emitting materials based on anthracene derivatives for non-doped organic light-emitting diodes. Optical Materials, 2016, 58: 260–267

DOI

2
Yi Q , He J , Fu X , Ying J , Gong L , Shen J , He X . Carbazole-based chemosensor for highly sensitive and selective bioimaging identification of hydrazine in multiple model systems via ratiometric and colorimetric. Dyes and Pigments, 2021, 196: 109816

DOI

3
Brito L , Pirngruber G , Guillon E , Albrieux F , Martens J A . Hydroconversion of perhydrophenanthrene over bifunctional Pt/H-USY zeolite catalyst. ChemCatChem, 2020, 12(13): 3477–3488

DOI

4
Wang L , Chen Y , Jin S , Chen X , Liang C . Selective ring-shift isomerization in hydroconversion of fluorene over supported platinum catalysts. Energy & Fuels, 2016, 30(4): 3403–3412

DOI

5
Isa K M , Abdullah T A T , Ali U F M . Hydrogen donor solvents in liquefaction of biomass: a review. Renewable & Sustainable Energy Reviews, 2018, 81: 1259–1268

DOI

6
Chang H Z , Li J Q , Du S , Shen K Y , Yang Q , Yi H , Zhang J W . Transformation characteristics of hydrogen-donor solvent tetralin in the process of direct coal liquefaction. Frontiers in Chemistry, 2019, 7: 737

DOI

7
Kidd P S , Álvarez A , Álvarez López V , Cerdeira Pérez A , Rodríguez Garrido B , Prieto Fernández Á , Chalot M . Beneficial traits of root endophytes and rhizobacteria associated with plants growing in phytomanaged soils with mixed trace metal-polycyclic aromatic hydrocarbon contamination. Chemosphere, 2021, 277: 130272

DOI

8
Xie X , Zhao Y , Qiu P , Lin D , Qian J , Hou H , Pei J . Investigation of the relationship between infrared structure and pyrolysis reactivity of coals with different ranks. Fuel, 2018, 216: 521–530

DOI

9
Fan X , Fei Y , Chen L , Li W . Distribution and structural analysis of polycyclic aromatic hydrocarbons abundant in coal tar pitch. Energy & Fuels, 2017, 31(5): 4694–4704

DOI

10
Yu L Z , Wei Y , Shi M . Synthesis of polysubstituted polycyclic aromatic hydrocarbons by gold-catalyzed cyclization-oxidation of alkylidenecyclopropane-containing 1,5-enynes. ACS Catalysis, 2017, 7(7): 4242–4247

DOI

11
Li W Y , Wang W , Mu H , Li W , Ye C P , Feng J . Analysis of light weight fractions of coal-based crude oil by gas chromatography combined with mass spectroscopy and flame ionization detection. Fuel, 2019, 241: 392–401

DOI

12
Sun M , Ma X X , Lv B , Dai X M , Yao Y , Liu Y Y , He M , Zhao X L . Gradient separation of ≥ 300 °C distillate from low-temperature coal tar based on formaldehyde reactions. Fuel, 2015, 160: 16–23

DOI

13
Ban H , Cheng Y , Wang L , Li X , Zhou X , Zhang X . Preparation of high-purity 2,6-naphthalenedicarboxylic acid from coal tar distillate. Chemical Engineering & Technology, 2019, 42(6): 1188–1198

DOI

14
Yu J , Jiang C , Guan Q , Gu J , Ning P , Miao R , Chen Q , Zhang J . Conversion of low-grade coals in sub-and supercritical water: a review. Fuel, 2018, 217: 275–284

DOI

15
Lisicki Z , Majewski W , Kwiatkowski J , Dunalewicz A , Polaczek J . Coal tar purification, distribution and characterization by supercritical extraction. Fuel Processing Technology, 1988, 20: 103–121

DOI

16
MarciniakBDziwinskiE. Study on the purity and zone refining of some coal-tar aromatic hydrocarbons. International Conference on Solid State Crystals 2000: Epilayers and Heterostructures in Optoelectronics and Semicobductor Technology. 17 April 2001: 413–418

17
Banerjee A , Ray S K . Synthesis of novel composite membranes by in-situ intercalative emulsion polymerization for separation of aromatic-aliphatic mixtures by pervaporation. Journal of Membrane Science, 2020, 597: 117729

DOI

18
Shimada Y , Bi D , Habaki H , Egashira R . Mass transfer rate in separation of coal tar absorption oil by emulsion liquid membranes. Journal of Chemical Engineering of Japan, 2013, 46(6): 376–382

DOI

19
Sun M , Chen J , Dai X M , Zhao X L , Liu K , Ma X X . Controlled separation of low temperature coal tar based on solvent extraction-column chromatography. Fuel Processing Technology, 2015, 136: 41–49

DOI

20
LongHShiQPanNZhangYCuiDChungK HZhaoSXuC. Characterization of middle-temperature gasification coal tar. Part 2: neutral fraction by extrography followed by gas chromatography-mass spectrometry and electrospray ionization coupled with Fourier transform ion cyclotron resonance mass spectrometry. Energy & Fuels, 2012, 26(6): 3424–3431

21
Gai H , Qiao L , Zhong C , Zhang X , Xiao M , Song H . A solvent based separation method for phenolic compounds from low-temperature coal tar. Journal of Cleaner Production, 2019, 223: 1–11

DOI

22
Liu Z W , Zong Z M , Li J N , Chen C F , Jiang H , Peng Y L , Xue J Q , Yang X L , Zheng Y X , Zhou X . . Isolation and identification of two bis(2-ethylheptyl) benzenedicarboxylates from Lingwu coal. Energy & Fuels, 2009, 23(1): 588–590

DOI

23
Jiao T , Li C , Zhuang X , Cao S , Chen H , Zhang S . The new liquid-liquid extraction method for separation of phenolic compounds from coal tar. Chemical Engineering Journal, 2015, 266: 148–155

DOI

24
Yi L , Feng J , Li W , Luo Z . High-performance separation of phenolic compounds from coal-based liquid oil by deep eutectic solvents. ACS Sustainable Chemistry & Engineering, 2019, 7(8): 7777–7783

DOI

25
Kong X F , Yang B , Xiong H , Kong L X , Liu D C , Xu B Q . Thermodynamics of removing impurities from crude lead by vacuum distillation refining. Transactions of Nonferrous Metals Society of China, 2014, 24(6): 1946–1950

DOI

26
Wang K , Jordan J H , Hu X Y , Wang L . Supramolecular strategies for controlling reactivity within confined nanospaces. Angewandte Chemie International Edition, 2020, 59(33): 13712–13721

DOI

27
De Castro I A , Datta R S , Ou J Z , Castellanos-Gomez A , Sriram S , Daeneke T , Kalantar-zadeh K . Molybdenum oxides-from fundamentals to functionality. Advanced Materials, 2017, 29(40): 1701619

DOI

28
Stark R , Grzelak M , Hadfield J . RNA sequencing: the teenage years. Nature Reviews. Genetics, 2019, 20(11): 631–656

DOI

29
Zimmerman J B , Anastas P T , Erythropel H C , Leitner W . Designing for a green chemistry future. Science, 2020, 367(6476): 397–400

DOI

30
Yan W W , Zong Z M , Li Z X , Li J , Liu G H , Ma Z H , Zhang Y Y , Xu M L , Liu F J , Wei X Y . Effective separation and purification of nitrogen-containing aromatics from the light portion of a high-temperature coal tar using choline chloride and malonic acid: experimental and molecular dynamics simulation. ACS Sustainable Chemistry & Engineering, 2020, 8(25): 9464–9471

DOI

31
Li C , Li D , Zou S , Li Z , Yin J , Wang A , Cui Y , Yao Z , Zhao Q . Extraction desulfurization process of fuels with ammonium-based deep eutectic solvents. Green Chemistry, 2013, 15(10): 2793–2799

DOI

32
Ma Z H , Wei X Y , Gui J , Liu G H , Yan W W , Li J , Liu F J , Liu Z Q , Zong Z M . Selective enrichment of carbazole from an anthracene slag by extraction: experiment and simulation. Journal of Molecular Liquids, 2021, 341: 117382

DOI

33
Zhao D , Liu C , Wang Y , Zhang H . Ionic liquids design for efficient separation of anthracene and carbazole. Separation and Purification Technology, 2022, 281: 119892

DOI

34
Vigier K D O , Chatel G , Jérôme F . Contribution of deep eutectic solvents for biomass processing: opportunities, challenges, and limitations. ChemCatChem, 2015, 7(8): 1250–1260

DOI

35
Bei P , Rajendran A , Feng J , Li W Y . Anthracene separation from analogous polycyclic aromatic hydrocarbons using the naphthalene-based solvents. Fuel, 2023, 335: 127029

DOI

36
Bassil G , Saab J , Goutaudier C , Negadi L , Jose J , Mokbel I . Experimental measurements for the liquid-liquid equilibrium of ternary systems [(water+methyl oleate+model mixtures of tar (naphthalene, phenanthrene and anthracene)] issued from the biomass gasification process. Journal of Chemical Thermodynamics, 2022, 164: 106613

DOI

37
Li J H , Wei X Y , Zhao H F , Yan W W , Teng D G , Ma Z H , Gao H S , Zong Z M . Effective separation of condensed arenes from high-temperature coal tar and insight into related intermolecular interactions. Energy & Fuels, 2021, 35(5): 4267–4272

DOI

Outlines

/