Most common surfactants employed in chemical enhanced oil recovery

Abstract

Chemical enhanced oil recovery (EOR) and particularly surfactant injection has recently received a great deal of attention. The suggested recovery mechanisms after injecting surfactants include wettability alteration and IFT reduction. If a surfactant is properly selected according to the environmental variables-such as pressure, temperature, salinity, it can lead to more efficient enhanced recovery from an oil reservoir. On the other hand, poor selection of the surfactant can result in a low recovery and can even become detrimental to the reservoir due to undesirable wettability alteration and possible rock dissolution resulting in a chemical reaction with displacing fluid and blockage of the pore space. Also, choosing the wrong surfactant without considering the rock mineralogy may result in high adsorption on the pore surface of the rock and unnecessary waste of resources. It is also worthy to note that surfactants are some of the most expensive chemicals used during EOR. Extensive literature review suggests that anionic surfactant are the preferred surfactant category for EOR especially when it comes to sandstone reservoirs. Occasionally, in specific situations a better performance have been reported after injecting cationic, non-ionic or mixtures of both surfactants, particularly when dealing with carbonate reservoirs. This paper presents in detail a review of the most commonly applied surfactants in EOR studies and the optimum application criteria for of each type. To the best of the Authors' knowledge, such detailed and comprehensive review is not available in the literature, presently.

Keywords

Surfactants / Enhanced oil recovery / Wettability / Interfacial tension

References

[1] G. Hirasaki, C.A. Miller, M. Puerto, Recent Advances in Surfactant EOR, 2011.

[2] J.J. Sheng, Status of surfactant EOR technology, Petroleum 1 (2) (2015) 97-105.

[3] W. Karnanda, M.S. Benzagouta, A. AlQuraishi, M.M. Amro, Effect of temperature, pressure, salinity, and surfactant concentration on IFT for surfactant flooding optimization, Arab. J. Geosci. 6 (9) (2013) 3535-3544.

[4] Z. Ye, F. Zhang, L. Han, P. Luo, J. Yang, H. Chen, The effect of temperature on the interfacial tension between crude oil and gemini surfactant solution, Colloids Surfaces A Physicochem. Eng. Aspects 322 (1) (2008) 138-141.

[5] P.C. Hiemenz, R. Rajagopalan, Principles of Colloid and Surface Chemistry, third ed., Taylor & Francis, New York, 1997. Revised and Expanded.

[6] S.G. Udeagbara, Effect of Temperature and Impurities on Surface Tension of Crude Oil, reprint), Universal Publishers, USA, 2010.

[7] D.B. Troy, J.P. Remington, P. Beringer, Remington: the Science and Practice of Pharmacy, illustrated, Lippincott Williams & Wilkins, USA, 2006.

[8] G. Hirasaki, C.A. Miller, M. Puerto, Recent advances in surfactant EOR, SPE J. 16 (04) (2011).

[9] A. Bera, K. Ojha, T. Kumar, A. Mandal, Water solubilization capacity, interfacial compositions and thermodynamic parameters of anionic and cationic microemulsions, Colloids Surfaces A Physicochem. Eng. Aspects 404 (2012) 70-77.

[10] A. Bera, T. Kumar, K. Ojha, A. Mandal, Screening of microemulsion properties for application in enhanced oil recovery, Fuel 121 (2014) 198-207.

[11] A. Bera, K. Ojha, A. Mandal, T. Kumar, Interfacial tension and phase behavior of surfactant-brineeoil system, Colloids Surfaces A Physicochem. Eng. Aspects 383 (1-3) (2011) 114-119.

[12] S.I. Chou, D.O. Shah, The optimal salinity concept for oil displacement by oil-external microemulsions and graded salinity slugs, J. Can. Petr. Technol. 20 (03) (1981).

[13] O.G. Apaydin, A.R. Kovscek, O.G. Apaydin, A.R. Kovscek, Surfactant concentration and end effects on foam flow in porous media, Transp. Porous Media 43 (3) (2001) 511-536.

[14] S.J. Salter,The influence of type and amount of alcohol on surfactant-oilbrine phase behavior and properties, in:SPE Annual Fall Technical Conference and Exhibition., Colorado Society of Petroleum Engineers, Denver, 1977. SP--6843-MS.

[15] R.L. Reed, R.N. Healy, Some physicochemical aspects of microemulsion flooding: a review, Improv. Oil Recovery by Surfactant Polym. Flooding (1977) 383-437.

[16] M. Abe, D. Schechter, R.S. Schechter, W.H. Wade, U. Weerasooriya, S. Yiv, Microemulsion formation with branched tail polyoxyethylene sulfonate surfactants, J. Colloid Interface Sci. 114 (2) (1986) 342-356.

[17] K.R. Wormuth, S. Zushma, Phase behavior of branched surfactants in oil and water, Langmuir 7 (10) (1991) 2048-2053.

[18] EPA, Ethylene Oxide. Ethylene Oxide, United States Environmental Agency, USA, 2013.

[19] J. Wu, Y. Xu, T. Dabros, H. Hamza, Effect of EO and PO positions in nonionic surfactants on surfactant properties and demulsification performance, Colloids Surfaces A Physicochem. Eng. Aspects 252 (1) (2005) 79-85.

[20] D. Levitt, S. Dufour, G.A. Pope, D.C. Morel, P.R. Gauer, Design of an ASP flood in a high-temperature, high-salinity, low-permeability carbonate,in: International Petroleum Technology Bangkok, Thailand: International Petroleum Technology Conference, 2012.

[21] P. Kathel, K.K. Mohanty, EOR in Tight Oil Reservoirs through Wettability Alteration. SPE Annual Technical Conference and Exhibition, Society of Petroleum Engineers, New Orleans, Louisiana, USA, 2013.

[22] L. Co, Z. Zhang, Q. Ma, G. Watts, L. Zhao, P.J. Shuler, et al., Evaluation of functionalized polymeric surfactants for EOR applications in the Illinois Basin, J. Petroleum Sci. Eng. 134 (2015) 167-175.

[23] E.J. Behrens, Investigation of Loss of Surfactants during Enhanced Oil Recovery Applications -Adsorption of Surfactants onto Clay Materials [Department of Chemical Engineering], Norwegian University of Technology and Science: Norwegian University of Technology and Science, 2013.

[24] K.-O. Choi, N.P. Aditya, S. Ko, Effect of aqueous pH and electrolyte concentration on structure, stability and flow behavior of non-ionic surfactant based solid lipid nanoparticles, Food Chem. 147 (2014) 239-244.

[25] R.C. Nelson, Further Studies on Phase Relations in Chemical Flooding, 1981, pp. 73-104.

[26] S.P. Gupta, Dispersive mixing effects on the Sloss field micellar system, Soc. Petroleum Eng. J. 22 (04) (1982) 481-492.

[27] C. Glover, M. Puerto, J. Maerker, E. Sandvik, Surfactant phase behavior and retention in porous media, Soc. Petroleum Eng. J. 19 (03) (1979) 183-193.

[28] J. Zhang, Q.P. Nguyen, A. Flaaten, G.A. Pope, Mechanisms of enhanced natural imbibition with novel chemicals, SPE Reserv. Eval. Eng. 12 (06) (2009) 912-920.

[29] Flaaten A, Nguyen QP, Pope GA, Zhang J.A systematic laboratory approach to low-cost, high-performance chemical flooding. Conference a Systematic Laboratory Approach to Low-cost, High-performance Chemical Flooding. Society of Petroleum Engineers.

[30] K. Hara, H. Kuwabara, O. Kajimoto, K. Bhattacharyya, Effect of pressure on the critical micelle concentration of neutral surfactant using fluorescence probe method, J. Photochem. Photobiol. A Chem. 124 (3) (1999) 159-162.

[31] Shupe RD.Surfactant oil recovery process usable in high temperature formations containing high salinity water. Google Patents; 1978.

[32] Sharma MM, Gao B. Salt-tolerant anionic surfactant compositions for enhanced oil recovery (eor) applications. USA: Google Patents; 2014.

[33] J. Lu, Development of Novel Surfactants and Surfactant Methods for Chemical Enhanced Oil Recovery, Doctor of Philosophy, The University of Texas at Austin, Austin, Texas, USA, 2014.

[34] M. Showell (Ed.), Powdered Detergents. Illustrated, Taylor & Francis, New York, USA, 1997.

[35] OilChemTechnologies,ANIONIC SURFACTANTS. Oil Chem Technology, 2010. Texas, USA.

[36] M. Oya, Y. Takemoto, Y. Ishikawa, Large decrease in acute aquatic toxicity of linear alkylbenzene sulfonate in hard water and seawater by adding adsorbent, J. Oleo Sci. 57 (1) (2008) 15-21.

[37] A.L.M.L. Pena, Experimental Evaluation of Linear Alkylbenzene Sulphonates for Enhanced Oil Recovery, Instituto Superior Técnico, 2015.

[38] Procter&Gamble. PG, Linear Alkybenzene Sulfonate (LAS), Glossary of Procter & Gamble. USA: P&G, 2014.

[39] SigmaAldrich,Alkyl Sulfates, 2015 ed., Sigma-Aldrich Co. LLC, USA, 2015.

[40] Procter&Gamble PG. Alkyl(or Alcohol) Ethoxy Sulphate (AES), Glossory of P&G. USA: Procter & Gamble, 2014.

[41] Andjelic S, Erneta M, Fevola MJ, Sun FC. Polyglyceryl compounds and compositions. USA: Google Patents; 2012.

[42] G. Sharma, K. Mohanty, Wettability Alteration in High-temperature and High-salinity Carbonate Reservoirs, 2013.

[43] P. Esmaeilzadeh, N. Hosseinpour, A. Bahramian, Z. Fakhroueian, S. Arya, Effect of ZrO2 nanoparticles on the interfacial behavior of surfactant solutions at airewater and n-heptaneewater interfaces, Fluid Phase Equilibria 361 (0) (2014) 289-295.

[44] gbiosciences. Sodium Dodecyl Sulfate. G-Biosciences Research Product. USA2014.

[45] P.S. CIEC, Surfactants. The Essential Chemical Industry, UK: University of York, 2013.

[46] Szlendak SM, Nguyen NM, Nguyen QP., Szlendak SM, Nguyen NM, Nguyen QP. Laboratory investigation of low-tension-gas flooding for improved oil recovery in tight formations. SPE vol. 159841; 2013.

[47] D. Levitt, A. Jackson, C. Heinson, L.N. Britton, T. Malik, V. Dwarakanath, et al., Identification and evaluation of high-performance EOR surfactants,in:SPE/DOE Symposium on Improved Oil Recovey, Society of Petroleum Engineers, Tulsa, Oklahoma, USA, 2006.

[48] M. Srivastava, J. Zhang, Q.P. Nguyen, G.A. Pope, A systematic study of alkali surfactant gas injection as an enhanced oil recovery technique, in: SPE Annual Technical Conference and Exhibition, USA Society of Petroleum Engineers, New Orleans, Louisiana, 2009.

[49] D. Levitt, A. Jackson, C. Heinson, L.N. Britton, T. Malik, V. Dwarakanath, et al., Identification and evaluation of high-performance EOR surfactants, SPE Reserv. Eval. Eng. 12 (02) (2009).

[50] S. Adkins, P.J. Liyanage, G.W.P. Pinnawala Arachchilage, T. Mudiyanselage, U. Weerasooriya, G.A. Pope, A New Process for Manufacturing and Stabilizing High-performance EOR Surfactants at Low Cost for Hightemperature, High-salinity Oil Reservoirs. SPE Improved Oil Recovery, Society of Petroleum Engineers, Tulsa, Oklahoma, USA, 2010.

[51] ArokorHolding, Sodium Alpha-olefin Sulfonate. Chemicalland21 Arokor Holding Inc., Seoul, South Korea, 2013.

[52] M. Rieger, L.D. Rhein, Surfactants in Cosmetics, second ed., Taylor & Francis, New York, USA, 1997, 2, illustrated, revised.

[53] Wei Z, Navarrete RC. High temperature gellant for viscosity modification of low and high density brines. Google Patents; 2007.

[54] Kott KL, Scheibel JJ, Severson RG, Cripe TA, Burckett-St LJCT. Laundry detergents comprising modified alkylbenzene sulfonates. USA: Google Patents; 2006.

[55] C.T.Q. Dang, N.T.B. Nguyen, Z. Chen, H.X. Nguyen, W. Bae, T.H. Phung, A Comprehensive Evaluation of the Performances of Alkaline/Surfactant/Polymer Flooding in Conventional and Unconventional Reservoirs. SPE Asia Pacific Oil and Gas, Australia Society of Petroleum Engineers, Perth, 2012.

[56] Masaki M, Furukawa Y, Takenaka K.Process for preparation of glycidyl sulfonate derivative. USA: Google Patents; 1999.

[57] Weerasooriya UP, Pope GA, Nguyen QP. Method of manufacture and use of large hydrophobe ether sulfate surfactants in enhanced oil recovery (eor) applications. Google Patents; 2011.

[58] Mahanthappa MK, Sorenson GP, Coppage KLN. Dicarboxylate gemini surfactant that forms a lyotropic liquid crystal. USA: Google Patents; 2014.

[59] Shell, Enordet Surfactants for Enhanced oil Recovery, Shell Chemicals: Shell Company, 2015.

[60] C. Shi, G. Liao, W. Liu, Synthesis of internal olefin sulfonate and its application in oil recovery, Arab. J. Sci. Eng. 39 (1) (2014) 37-41.

[61] Loza R, Cooper AJ, Coffey GP.Enhanced oil recovery, anionic surfactants. USA: Google Patents; 1990.

[62] Y. Wu, S. Lglauer, Y. Tang, W.A. Goddard, Branched alkyl alcohol propoxylated sulfate surfactants for improved oil recovery, Tenside Surf. Det. 47 (3) (2010) 152-161.

[63] F. Friedli, Detergency of Specialty Surfactants, illustrated, Taylor & Francis, New York, 2001.

[64] Cripe TA.Process for making alkyl ethoxy carboxylates. Google Patents; 1993.

[65] M. Santa, G. Alvarez-Jürgenson, S. Busch, P. Birnbrich, C. Spindler, G. Brodt, Sustainable Surfactants in Enhanced Oil Recovery, in: SPE Enhanched Oil Recovery Conference, Malaysia Society of Petroleum Engineers, Kuala Lumpur, 2011.

[66] C. Leray, Glycosides of Fatty Alcohols, Cyberlipid Center, USA, 2014.

[67] Shell, NEODOL. Product Data, Shell Oil Company, 2015.

[68] B. Barzegar Alamdari, M. Kiani, H. Kazemi, Experimental and numerical simulation of surfactant-assisted oil recovery, in: Tight Fractured Carbonate Reservoir Cores. Eighteenth Oil Recovery Symposium, Society of Petroleum Engineers, Tulsa, Oklahoma, USA, 2012.

[69] A. Flaaten, Q.P. Nguyen, G.A. Pope, J. Zhang, A systematic laboratory approach to low-cost, high-performance chemical flooding, SPE Reserv. Eval. Eng. 12 (05) (2009).

[70] Company TDC, DOW™ Nonylphenol Ethoxylate Surfactants, The Dow Chemical Company, Midland MI, United States of America, 2010.

[71] Bathe DP, Montgomery FJ. Compositions, methods and articles concerning pharmaceutical nitric oxide and controlled patient delivery systems thereof. USA: Google Patents; 2012.

[72] Cristobal G, Tan WE, Metivier P, Lu R, Lambert F. Combination of polymer and surfactant for improved laundry. USA: Google Patents; 2012.

[73] De GM, Bernhard K.Flooding process for recovering oil from subterranean oil-bearing strata. USA: Google Patents; 1941.

[74] S.A. Lewis, Propylene Glycol Ethers. OECD SIDS, American Chemistry Council, Italy, 2003.

[75] K. Mohan, Alkaline surfactant flooding for tight carbonate reservoirs, in: SPE Annual Technical Conference and Exhibition, Louisiana Society of Petroleum Engineers, New Orleans, 2009.

[76] S.K.C. Evetts, M. Levin, M. Stafford, High-temperature stability of alcohol ethoxylates, J. Am. Oil Chemists' Soc. 72 (no 7) (1995) 811-816, 106 p.

[77] Souter PF, Meek M, Tarbit DJ, Boutique JP. Enzyme stabilized liquid detergent composition. USA: Google Patents; 2013.

[78] Berrill SA, Davies RJ, Lewis DA, Meakin BJ. Solubilisation of drugs in HFA propellant by means of emulsions. USA: Google Patents; 2003.

[79] AroKorHoldings I,Tridecyl Alcohol Ethoxylate Chemicalland2013. http://www.chemicalland21.com/specialtychem/perchem/SODIUM%20ALPHA% 20OLEFIN%20SULFONATE.htm.

[80] L. Siggel, M. Santa, M. Hansch, M. Nowak, M. Ranft, H. Weiss, et al., A new class of viscoelastic surfactants for enhanced oil recovery,in:SPE Imroved Oil Recovery Symposium, Society of Petroleum Engineers, Tulsa, Oklahoma, USA, 2012.

[81] A.C. Bhasikuttan, J. Mohanty, Targeting G-quadruplex structures with extrinsic fluorogenic dyes: promising fluorescence sensors, Chem. Commun. 51 (36) (2015) 7581-7597.

[82] A. Mandal, A. Bera, K. Ojha, T. Kumar, Characterization of Surfactant Stabilized Nanoemulsion and its Use in Enhanced Oil Recovery, Society of Petroleum Engineers, 2012.

[83] H. Vatanparast, A.H. Alizadeh, A. Bahramian, H. Bazdar, Wettability alteration of low-permeable carbonate reservoir rocks in presence of mixed ionic surfactants, Petroleum Sci. Technol. 29 (18) (2011) 1873-1884.

[84] G.W.A. Milne, Gardner's Commercially Important Chemicals: Synonyms, Trade Names, and Properties, Wiley, 2005.

[85] Kuper C, Kuzma M. Compositions of suspended carbon nanotubes, methods of making the same, and uses thereof. USA: Google Patents; 2003.

[86] M. Ash, I. Ash, Handbook of Green Chemicals: Synapse Information Resources, 2004.

[87] ChemNet. Dodecyl trimethyl ammonium bromide DTAB, Global Chemical Market China, NetSun Co., Ltd., Zhejiang, 2013.

[88] Y. Chen, A.S. Elhag, B.M. Poon, L. Cui, K. Ma, S.Y. Liao, et al., Ethoxylated cationic surfactants for CO 2 EOR,in:High Temperature, High Salinity Reservoirs. Eighteenth SPE Improved Oil Recovery Symposium Tulsa, Society of Petroleum Engineers, Oklahoma, USA, 2012.

[89] Welton T, Todd B, McMechan D. Methods for effecting controlled break in pH dependent foamed fracturing fluid. USA: Google Patents; 2007.

[90] Q.-Q. Zhang, B.-X. Cai, W.-J. Xu, H.-Z. Gang, J.-F. Liu, S.-Z. Yang, et al., Novel zwitterionic surfactant derived from castor oil and its performance evaluation for oil recovery, Colloids Surfaces A Physicochem. Eng. Aspects 483 (2015) 87-95.

[91] R. Sen, Biotechnology in petroleum recovery: the microbial EOR, Prog. Energy Combust. Sci. 34 (6) (2008) 714-724.

[92] L. Torres, A. Moctezuma, J.R. Avenda-no, A. Mu-noz, J. Gracida, Comparison of bio-and synthetic surfactants for EOR, J. Petroleum Sci. Eng. 76 (1-2) (2011) 6-11.

[93] L. Daoshan, L. Shouliang, L. Yi, W. Demin, The effect of biosurfactant on the interfacial tension and adsorption loss of surfactant in ASP flooding, Colloids Surfaces A Physicochem. Eng. Aspects 244 (1-3) (2004) 53-60.