Modeling of single coal particle combustion in O₂/N₂ and O₂/CO₂ atmospheres under fluidized bed condition

Abstract

A one-dimensional transient single coal particle combustion model was proposed to investigate the characteristics of single coal particle combustion in both O₂/N₂ and O₂/CO₂ atmospheres under the fluidized bed combustion condition. The model accounted for the fuel devolatilization, moisture evaporation, heterogeneous reaction as well as homogeneous reactions integrated with the heat and mass transfer from the fluidized bed environment to the coal particle. This model was validated by comparing the model prediction with the experimental results in the literature, and a satisfactory agreement between modeling and experiments proved the reliability of the model. The modeling results demonstrated that the carbon conversion rate of a single coal particle (diameter 6 to 8 mm) under fluidized bed conditions (bed temperature 1088 K) in an O₂/CO₂ (30:70) atmosphere was promoted by the gasification reaction, which was considerably greater than that in the O₂/N₂ (30:70) atmosphere. In addition, the surface and center temperatures of the particle evolved similarly, no matter it is under the O₂/N₂ condition or the O₂/CO₂ condition. A further analysis indicated that similar trends of the temperature evolution under different atmospheres were caused by the fact that the strong heat transfer under the fluidized bed condition overwhelmingly dominated the temperature evolution rather than the heat release of the chemical reaction.

Key words： coal; oxy-fuel; fluidized bed; combustion; simulation

Acknowledgment

This work was supported by the National Key R&D Program of China (No. 2018YFF0216002) and the Seed Fund of Shanxi Research Institute for Clean Energy, Tsinghua University.

References

1 Wang H, He J. China’s pre-2020 CO₂ emission reduction potential and its influence. Frontiers in Energy, 2019, 13(3): 571–578

2 Wang W, Li Z, Lyu J, Zhang H, Yue G, Ni W. An overview of the development history and technical progress of China’s coal-fired power industry. Frontiers in Energy, 2019, 13(3): 417–426

3 Kanniche M, Gros-Bonnivard R, Jaud P, Valle-Marcos J, Amann J M, Bouallou C. Pre-combustion, post-combustion and oxy-combustion in thermal power plant for CO₂ capture. Applied Thermal Engineering, 2010, 30(1): 53–62

4 Kunze C, Spliethoff H. Assessment of oxy-fuel, pre- and post-combustion-based carbon capture for future IGCC plants. Applied Energy, 2012, 94: 109–116

5 Leung D Y C, Caramanna G, Maroto-Valer M M. An overview of current status of carbon dioxide capture and storage technologies. Renewable & Sustainable Energy Reviews, 2014, 39: 426–443

6 Kazanc F, Khatami R, Manoel Crnkovic P, Levendis Y A. Emissions of NO_x and SO₂ from coals of various ranks, bagasse, and coal-bagasse blends burning in O₂/N₂ and O₂/CO₂ environments. Energy & Fuels, 2011, 25(7): 2850–2861

7 Khatami R, Stivers C, Joshi K, Levendis Y A, Sarofim A F. Combustion behavior of single particles from three different coal ranks and from sugar cane bagasse in O₂/N₂ and O₂/CO₂ atmospheres. Combustion and Flame, 2012, 159(3): 1253–1271

8 Khatami R, Stivers C, Levendis Y A. Ignition characteristics of single coal particles from three different ranks in O₂/N₂ and O₂/CO₂ atmospheres. Combustion and Flame, 2012, 159(12): 3554–3568

9 Riaza J, Khatami R, Levendis Y A, Álvarez L, Gil M V, Pevida C, Rubiera F, Pis J J. Single particle ignition and combustion of anthracite, semi-anthracite and bituminous coals in air and simulated oxy-fuel conditions. Combustion and Flame, 2014, 161(4): 1096–1108

10 Piotrowska P, Zevenhoven M, Davidsson K, Hupa M, Åmand L E, Barišić V, Coda Zabetta E. Fate of alkali metals and phosphorus of rapeseed cake in circulating fluidized bed boiler. Part 2: cocombustion with coal. Energy & Fuels, 2010, 24(8): 4193–4205

11 Piotrowska P, Zevenhoven M, Davidsson K, Hupa M, Åmand L E, Barišić V, Coda Zabetta E. Fate of alkali metals and phosphorus of rapeseed cake in circulating fluidized bed boiler. Part 1: cocombustion with wood. Energy & Fuels, 2010, 24(1): 333–345

12 Leckner B, Gómez-Barea A. Oxy-fuel combustion in circulating fluidized bed boilers. Applied Energy, 2014, 125: 308–318

13 Seddighi K S, Pallarès D, Normann F, Johnsson F. Progress of combustion in an oxy-fuel circulating fluidized-bed furnace: measurements and modeling in a 4 MW_th boiler. Energy & Fuels, 2013, 27(10): 6222–6230

14 Tan Y, Jia L, Wu Y, Anthony E J. Experiences and results on a 0.8 MW_th oxy-fuel operation pilot-scale circulating fluidized bed. Applied Energy, 2012, 92: 343–347

15 Duan L, Sun H, Zhao C, Zhou W, Chen X. Coal combustion characteristics on an oxy-fuel circulating fluidized bed combustor with warm flue gas recycle. Fuel, 2014, 127: 47–51

16 Varol M, Symonds R, Anthony E J, Lu D, Jia L, Tan Y. Emissions from co-firing lignite and biomass in an oxy-fired CFBC. Fuel Processing Technology, 2018, 173: 126–133

17 Hernberg R, Stenberg J, Zethraus B. Simultaneous in situ measurement of temperature and size of burning char particles in a fluidized bed furnace by means of fiberoptic pyrometry. Combustion and Flame, 1993, 95(1-2): 191–205

18 Joutsenoja T, Heino P, Hernberg R, Bonn B. Pyrometric temperature and size measurements of burning coal particles in a fluidized bed combustion reactor. Combustion and Flame, 1999, 118(4): 707–717

19 Bu C, Leckner B, Chen X, Pallarès D, Liu D, Gómez-Barea A. Devolatilization of a single fuel particle in a fluidized bed under oxy-combustion conditions. Part A: experimental results. Combustion and Flame, 2015, 162(3): 797–808

20 Lupion M, Alvarez I, Otero P, Kuivalainen R, Lantto J, Hotta A, Hack H. 30 MW_th CIUDEN oxy-cfb boiler–first experiences. Energy Procedia, 2013, 37: 6179–6188

21 Lyu J, Yang H, Ling W, Nie L, Yue G, Li R, Chen Y, Wang S. Development of a supercritical and an ultra-supercritical circulating fluidized bed boiler. Frontiers in Energy, 2019, 13(1): 114–119

22 Garcia-Gutierrez L, Hernández-Jiménez F, Cano-Pleite E, Soria-Verdugo A. Improvement of the simulation of fuel particles motion in a fluidized bed by considering wall friction. Chemical Enginee-ring Journal, 2017, 321: 175–183

23 Zhu S, Zhang M, Huang Y, Wu Y, Yang H, Lyu J, Gao X, Wang F, Yue G. Thermodynamic analysis of a 660 MW ultra-supercritical CFB boiler unit. Energy, 2019, 173: 352–363

24 Saxena S C. Devolatilization and combustion characteristics of coal particles. Progress in Energy and Combustion Science, 1990, 16(1): 55–94

25 Solomon P R, Serio M A, Suuberg E M. Coal pyrolysis: experiments, kinetic rates and mechanisms. Progress in Energy and Combustion Science, 1992, 18(2): 133–220

26 Chern J S, Hayhurst A N. Does a large coal particle in a hot fluidised bed lose its volatile content according to the shrinking core model? Combustion and Flame, 2004, 139(3): 208–221

27 Scala F, Chirone R. Fluidized bed combustion of single coal char particles at high CO₂ concentration. Chemical Engineering Journal, 2010, 165(3): 902–906

28 Scala F, Chirone R. Combustion of single coal char particles under fluidized bed oxyfiring conditions. Industrial & Engineering Chemistry Research, 2010, 49(21): 11029–11036

29 Guedea I, Pallarès D, Díez L I, Johnsson F. Conversion of large coal particles under O₂/N₂ and O₂/CO₂ atmospheres—experiments and modeling. Fuel Processing Technology, 2013, 112: 118–128

30 Bu C, Leckner B, Chen X, Gómez-Barea A, Liu D, Pallarès D. Devolatilization of a single fuel particle in a fluidized bed under oxy-combustion conditions. Part B: modeling and comparison with measurements. Combustion and Flame, 2015, 162(3): 809–818

31 Salinero J, Gómez-Barea A, Fuentes-Cano D, Leckner B. Measurement and theoretical prediction of char temperature oscillation during fluidized bed combustion. Combustion and Flame, 2018, 192: 190–204

32 Nikrityuk P, Meyer B. Gasification Processes: Modeling and Simulation. Weinheim: Wiley-VCH Verlag GmbH & Co. KGaA, 2014

33 Bhatia S, Perlmutter D. A random pore model for fluid-solid reactions: I. Isothermal, kinetic control. AIChE Journal, 1980, 26(3): 379–386

34 Chern J S, Hayhurst A N. A model for the devolatilization of a coal particle sufficiently large to be controlled by heat transfer. Combustion and Flame, 2006, 146(3): 553–571

35 Loison R, Chauvin F. Rapid coal pyrolysis. Chemical Industry (Paris), 1964, 91 (in French)

36 Rowe P N, Clayton K T, Lewis J B. Heat mass transfer from single sphere in an extensive flowing fluid. Transactions of the Institution of Chemical Engineers, 1965, 43: 14–31

37 Herrin J M, Deming D. Thermal conductivity of US coals. Journal of Geophysical Research–Solid Earth, 1996, 101(B11): 25381–25386

38 Maloney D J, Monazam E R, Woodruff S D, Lawson L O. Measurements and analysis of temperature histories and size changes for single carbon and coal particles during the early stages of heating and devolatilization. Combustion and Flame, 1991, 84(1–2): 210–220

39 Duan L, Li L, Liu D, Zhao C. Fundamental study on fuel-staged oxy-fuel fluidized bed combustion. Combustion and Flame, 2019, 206: 227–238