Control of sludge settleability and nitrogen removal under low dissolved oxygen condition

Abstract

Low dissolved oxygen (DO) is an energy-saving condition in activated sludge process. To investigate the possible application of limited filamentous bulking (LFB) in sequencing batch reactor (SBR), two lab-scale SBRs were used to treat synthetic domestic wastewater and real municipal wastewater, respectively. The results showed that prolonging low DO aeration duration and setting pre-anoxic (anaerobic) phase were effective strategies to induce and inhibit filamentous sludge bulking, respectively. According to the sludge settleability, LFB could be maintained steadily by adjusting operation patterns. Filamentous bacteria content and sludge volume index (SVI) were likely correlated. SVI fluctuated dramatically within a few cycles when around 200 mL·g^-1, where altering operation pattern could change sludge settleability in spite of the unstable status of activated sludge system. Energy consumption by aeration reduced under low DO LFB condition, whereas the nitrification performance deteriorated. However, short-cut nitrification and simultaneous nitrification denitrification (SND) were prone to take place under such conditions. When the cycle time kept constant, the anoxic (anaerobic) to aerobic time ratio was determining factor to the SND efficiency. Similarity keeping aerobic time as constant, the variation trends of SND efficiency and specific SND rate were uniform. SBR is a promising reactor to apply the LFB process in practice.

Keywords

limited filamentous bulking / sequencing batch reactor / sludge settleability / sludge volume index / simultaneous nitrification denitrification

References

[1] Martins A M P, Pagilla K, Heijnen J J, van Loosdrecht M C M. Filamentous bulking sludge—a critical review. Water Research, 2004, 38(4): 793-817

[2] Wang J B, Chai L H, Zhang Y, Chen L M. Microbial ecological model of filamentous bulking and mechanisms. World Journal of Microbiology & Biotechnology, 2006, 22(12): 1313-1320

[3] Guo J H, Peng Y Z, Peng C Y, Wang S Y, Chen Y, Huang H J, Sun Z R. Energy saving achieved by limited filamentous bulking sludge under low dissolved oxygen. Bioresource Technology, 2010, 101(4): 1120-1126

[4] Smolders G J F, Meij J van der, Loosdrecht M C M van, HeijnenJ J. Stoichiometric model of the aerobic metabolism of the biological phosphorus removal process. Biotechnology and Bioengineering, 1994, 44(7): 837-848

[5] APHA. Standard Methods for the Examination of Water and Wastewater. 20th ed. Washington D C: American Public Health Association, 1998

[6] Eikelboom D H. Process Control of Activated Sludge Plants by Microscopic Investigation. London: IWA Publishing, 2000

[7] Vaiopoulou E, Melidis P, Aivasidis A. Growth of filamentous bacteria in an enhanced biological phosphorus removal system. Desalination, 2007, 213(1-3): 288-296

[8] Eikelboom D H, Andreadakis A, Andreasen K. Survey of filamentous populations in nutrient removal plants in four European countries. Water Science and Technology, 1998, 37(4-5): 281-289

[9] Grau P, Da-Rin B P. Management of toxicity effects in a large wastewater treatment plant. Water Science and Technology, 1997, 36(2-3): 1-8

[10] Peng Y Z, Guo J H, Wang S Y, Chen Y. Energy saving achieved by limited filamentous bulking under low dissolved oxygen: derivation, originality and theoretical basis. Environmental Sciences, 2008, 29(12): 3342-3347 (in Chinese)

[11] Tsang Y F, Chua H, Sin S N, Tam C Y. A novel technology for bulking control in biological wastewater treatment plant for pulp and paper making industry. Biochemical Engineering Journal, 2006, 32(3): 127-134

[12] Huang L, Ju L K. Sludge settling and online NAD(P)H fluorescence profiles in wastewater treatment bioreactors operated at low dissolved oxygen concentrations. Water Research, 2007, 41(9): 1877-1884

[13] Caravelli A, Giannuzzi L, Zaritzky N. Effect of chlorine on filamentous microorganisms present in activated sludge as evaluated by respirometry and INT-dehydrogenase activity. Water Research, 2004, 38(9): 2395-2404

[14] Agridiotis V, Forster C F, Carliell-Marquet C. Addition of Al and Fe salts during treatment of paper mill effluents to improve activated sludge settlement characteristics. Bioresource Technology, 2007, 98(15): 2926-2934

[15] Ni B J, Yu H Q. Kinetic modeling microbial storage process in activated sludge under anoxic conditions. Chemical Engineering Science, 2008, 63(10): 2785-2792

[16] Jolis D, Mitch A A, Marneri M, Ho C F. Effects of anaerobic selector hydraulic retention time on biological foam control and enhanced biological phosphorus removal in a pure-oxygen activated sludge system. Water Environment Research, 2007, 79(5): 472-478

[17] Martins A M P, Heijnen J J, van Loosdrecht M C M. Effect of feeding pattern and storage on the sludge settleability under aerobic conditions. Water Research, 2003, 37(11): 2555-2570

[18] Schuler A J, Jassby D. Filament content threshold for activated sludge bulking: artifact or reality? Water Research, 2007, 41(19): 4349-4356

[19] Schuler A I, Jang H. Causes of variable biomass density and its effects on settleability in full-scale biological wastewater treatment systems. Environmental Science & Technology, 2007, 41(5): 1675-1681

[20] Hu L L, Wang J L, Wen X H, Qian Y. Study on performance characteristics of SBR under limited dissolved oxygen. Process Biochemistry, 2005, 40(1): 293-296

[21] Bernet N, Dangcong P, Delgenes J P, Moletta R. Nitrification at low oxygen concentration in biofilm reactor. Journal of Environmental Engineering, 2001, 127(3): 266-271

[22] Guo J H, Peng Y Z, Wang S Y, Zheng Y N, Huang H J, Wang Z W. Long-term effect of dissolved oxygen on partial nitrification performance and microbial community structure. Bioresource Technology, 2009, 100(11): 2796-2802

[23] Dosta J, Galí A, Benabdallah El-Hadj T, Macé S, Mata-Alvarez J. Operation and model description of a sequencing batch reactor treating reject water for biological nitrogen removal via nitrite. Bioresource Technology, 2007, 98(11): 2065-2075

[24] Ma Y, Peng Y Z, Wang S Y, Yuan Z G, Wang X L. Achieving nitrogen removal via nitrite in a pilot-scale continuous pre-denitrification plant. Water Research, 2009, 43(3): 563-572

[25] Third K A, Burnett N, Cord-Ruwisch R. Simultaneous nitrification and denitrification using stored substrate (PHB) as the electron donor in an SBR. Biotechnology and Bioengineering, 2003, 83(6): 706-720

[26] Agridiotis V, Forster C F, Carliell-Marquet C. Addition of Al and Fe salts during treatment of paper mill effluents to improve activated sludge settlement characteristics. Bioresource Technology, 2007, 98(15): 2926-2934

RIGHTS & PERMISSIONS

Higher Education Press and Springer-Verlag Berlin Heidelberg