Selective reduction of NO by photo-SCR with ammonia in an annular fixed-film photoreactor

Abstract

Gaseous NO was photocatalytically reduced at room temperature by photo-assisted selective catalytic reduction (photo-SCR) with ammonia over TiO₂ in this study. NO reduction efficiency and N₂ selectivity were determined from gases composition at the outlet stream of photoreactor. Effect of operating conditions, e.g. light intensity and inlet concentrations of ammonia and oxygen, on the NO reduction efficiency and N₂ selectivity were discussed to determine the feasible operating condition for photocatalytic reduction of NO. Experimental results showed that selective catalytic reduction of NO with ammonia over TiO₂ in the presence of oxygen was a spontaneous reaction in dark. The photoirradiation on the TiO₂ surface caused remarkable photocatalytic reduction of NO to form N₂, NO₂, and N₂O under 254 nm UV illuminations, while almost 90% of N₂ selectivity was achieved in this study. The ammonia and oxygen molecules played the roles of reductant and oxidant for NO reduction and active sites regeneration, respectively. The reduction of NO was found to be increased with the increase of inlet ammonia and oxygen concentrations until specific concentrations because of the limited active sites on the surface of TiO₂. The kinetic model proposed in this study can be used to reasonably describe the reaction mechanism of photo-SCR.

Keywords

photo-SCR / photocatalysis / NO reduction / Eley-Rideal model

References

[1] Pârvulescu V, Grange P, Delmon B. Catalytic removal of NO. Catalysis Today, 1998, 46(4): 233-316

[2] Bosch H, Janssen F. Formation and control of nitrogen oxides. Catalysis Today, 1988, 2(4): 369-379

[3] Cho S M. Properly apply selective catalytic reduction for NO_x removal. Chemical Engineering Progress, 1994, 90: 39-45

[4] He W, Zhu T, Li J. NO conversion by positive streamer discharge-Effects of gas compositions and reaction conditions. Frontiers of Environmental Science & Engineering in China, 2009, 3(2): 186-193

[5] Huang B, Huang R, Jin D, Ye D. Low temperature SCR of NO with NH₃ over carbon nanotubes supported vanadium oxides. Catalysis Today, 2007, 126(3-4): 279-283

[6] Tanaka T, Teramura K, Funabiki T. Photoassisted selective catalytic reduction of NO with ammonia in the presence of oxygen at low temperature. Physical Chemistry Chemical Physics, 2000, 2(12): 2681-2682

[7] Tanaka T, Teramura K, Arakaki K, Funabiki T. Photoassisted NO reduction with NH₃ over TiO₂ photocatalyst. Chemical Communications, 2002, (22): 2742-2743

[8] Chou Y C, Ku Y. NO reduction and N₂ selectivity by photo-SCR under various operating conditions. Chemical Engineering Journal, 2010, 162(2): 696-701

[9] Teramura K, Tanaka T, Funabiki T. Photoassisted selective catalytic reduction of NO with ammonia in the presence of Oxygen over TiO₂. Langmuir, 2003, 19(4): 1209-1214

[10] Teramura K, Tanaka T, Yamazoe S, Arakaki K, Funabiki T. Kinetic study of photo-SCR with NH₃ over TiO₂. Applied Catalysis B: Environmental, 2004, 53(1): 29-36

[11] Yamazoe S, Okumura T, Teramura K, Tanaka T. Development of the efficient TiO₂ photocatalyst in photoassisted selective catalytic reduction of NO with NH₃. Catalysis Today, 2006, 111(3-4): 266-270

[12] Ku Y, Ma C M, Shen Y S. Decomposition of gaseous trichloroethylene in a photoreactor with TiO₂-coated nonwoven fiber textile. Applied Catalysis B: Environmental, 2001, 34(3): 181-190

[13] Ma C M, Ku Y, Chou Y C, Jeng F T. Performance of tubular-type optical fiber reactor for decomposition of VOCs in gaseous phase. Journal of Environmental Economics and Management, 2008, 18: 363-369

[14] Mohseni M, David A. Gas phase vinyl chloride (VC) oxidation using TiO₂-based photocatalysis. Applied Catalysis B: Environmental, 2003, 46(2): 219-228

[15] Ma C M, Ku Y, Kuo Y L, Chou Y C, Jeng F T. Effects of silver on the photocatalytic degradation of gaseous isopropanol. Water, Air, and Soil Pollution, 2009, 197(1-4): 313-321

[16] Kim S B, Hong S C. Kinetic study for photocatalytic degradation of volatile organic compounds in air using thin film TiO₂ photocatalyst. Applied Catalysis B: Environmental, 2002, 35(4): 305-315

RIGHTS & PERMISSIONS

Higher Education Press and Springer-Verlag Berlin Heidelberg