Study on static characteristics of a novel prestress-reinforced railway subgrade

Abstract

Understanding the reinforcement effect of the newly developed prestressed reinforcement components (PRCs) (a system composed of prestressed steel bars (PSBs), protective sleeves, lateral pressure plates (LPPs), and anchoring elements) is technically significant for the rational design of prestressed subgrade. A three-dimensional finite element model was established and verified based on a novel static model test and utilized to systematically analyze the influence of prestress levels and reinforcement modes on the reinforcement effect of the subgrade. The results show that the PRCs provide additional confining pressure to the subgrade through the diffusion effect of the prestress, which can therefore effectively improve the service performance of the subgrade. Compared to the unreinforced conventional subgrades, the settlements of prestress-reinforced subgrades are reduced. The settlement attenuation rate (R _s) near the LPPs is larger than that at the subgrade center, and increasing the prestress positively contributes to the stability of the subgrade structure. In the multi-row reinforcement mode, the reinforcement effect of PRCs can extend from the reinforced area to the unreinforced area. In addition, as the horizontal distance from the LPPs increases, the additional confining pressure converted by the PSBs and LPPs gradually diminishes when spreading to the core load bearing area of the subgrade, resulting in a decrease in the R _s. Under the single-row reinforcement mode, PRCs can be strategically arranged according to the local areas where subgrade defects readily occurred or observed, to obtain the desired reinforcement effect. Moreover, excessive prestress should not be applied near the subgrade shoulder line to avoid the shear failure of the subgrade shoulder. PRCs can be flexibly used for preventing and treating various subgrade defects of newly constructed or existing railway lines, achieving targeted and classified prevention, and effectively improving the bearing performance and deformation resistance of the subgrade. The research results are instructive for further elucidating the prestress reinforcement effect of PRCs on railway subgrades.

References

[1] Zhou SH, Wang BL, Shan Y. Review of research on high-speed railway subgrade settlement in soft soil area. Railw Eng Sci 2020, 28 2 129-145

[2] Sysyn M, Nabochenko O, Kovalchuk V. Experimental investigation of the dynamic behavior of railway track with sleeper voids. Railw Eng Sci 2020, 28 3 290-304

[3] Roshan MJ, Rashid ASA, Wahab NA . Improved methods to prevent railway embankment failure and subgrade degradation: a review. Transp Geotech 2022, 37

[4] Khan MR, Dasaka SM. Quantification of ground-vibrations generated by high-speed trains in ballasted railway tracks. Transp Geotech 2019, 20

[5] Shan Y, Zhou SH, Wang BL. Differential settlement prediction of ballasted tracks in bridge-embankment transitionzones. J Geotech Geoenviron Eng 2020, 146 9

[6] Zhou SH, Jiang HB, Fu LL . Experimental study on deformation and strength characteristics of granular soilstructure interface under coupled monotonic shear and vibration using a modified direct shear apparatus. Acta Geotech 18 2023, 18 6 2899-2913

[7] Esmaeili M, Khajehei H. Mechanical behavior of embankments overlying on loose subgrade stabilized by deep mixed columns. J Rock Mech Geotech Eng 2016, 8 5 651-659

[8] Indraratna B, Singh M, Nguyen TT. The mechanism and effects of subgrade fluidization under ballasted railway tracks. Railw Eng Sci 2020, 28 2 113-128

[9] Smethurst JA, Powrie W. Monitoring and analysis of the bending behaviour of discrete piles used to stabilise a railway embankment. Géotechnique 2007, 57 8 663-677

[10] Dong J, Wu ZH, Li X . Dynamic response and pile-soil interaction of a heavy-haul railway embankment slope reinforced by micro-piles. Comput Geotech 2018, 100 144-157

[11] Esmaeili M, Naderi B, Neyestanaki HK . Investigating the effect of geogrid on stabilization of high railway embankments. Soils Found 2018, 58 2 319-332

[12] Leshchinsky B, Ling HI. Effects of geocell confinement on strength and deformation behavior of gravel. J Geotech Geoenviron Eng 2013, 139 2 340-352

[13] Leshchinsky B, Ling HI. Numerical modeling of behavior of railway ballasted structure with geocell confinement. Geotext Geomembr 2013, 36 33-43

[14] Francisco A, Paixão A, Varandas JN . Short soil-binder columns in railway track reinforcement: three-dimensional numerical studies considering the train-track interaction. Comput Geotech 2018, 98 8-16

[15] Fortunato E, Paixão A, Morais P . Subgrade reinforcement of old railway tracks using short soil-binder columns - laboratory studies and field tests. Transp Geotech 2021, 29

[16] Luo Q, Xie HW, Xiao CQ . Analysis of replacement thickness of soft rock cutting subgrade of high-speed railway with ballast track. J Railway Eng Soc 2018, 236 5 7-12

[17] Alamshahi S, Hataf N. Bearing capacity of strip footings on sand slopes reinforced with geogrid and grid anchors. Geotext Geomembr 2009, 27 3 217-226

[18] Choudhary AK, Jha JN, Gill KS. Laboratory investigation of bearing capacity behavior of strip footing on reinforced flyash slope. Geotext Geomembr 2010, 28 4 393-402

[19] Bian XC, Li SH, Wan ZB . Influence of injection remediation on dynamic behaviors of a high-speed railway track-subgrade system. J Vib Shock 2022, 41 4 294-302(in Chinese)

[20] Yang X, Han J, Leshchinsky D . A three-dimensional mechanistic-empirical model for geocell-reinforced unpaved roads. Acta Geotech 2013, 8 2 201-213

[21] Chawla S, Shahu JT. Reinforcement and mud-pumping benefits of geosynthetics in railway tracks: model tests. Geotext Geomembr 2016, 44 3 366-380

[22] Ding Y, Jia Y, Ang X . The influence of geotextile on the characteristics of railway subgrade mud pumping under cyclic loading. Transp Geotech 2022, 37

[23] Leng WM, Nie RS, Yang Q . A new type of prestressed embankment structure and its properties. J China Railw Soc 2016, 38 11 111-119(in Chinese)

[24] Zhang QS, Leng WM, Xu F . Additional stress in soil embankments subjected to a new prestressed reinforcement device. J Civ Eng Manag 2019, 25 7 700-714

[25] Zhang QS, Leng WM, Xu F . (2022) Stability analysis method for a prestressed railway embankment considering the additional stress propagation effect. Lithosphere 2021, 7 6928614

[26] Xu F, Leng WM, Nie RS . New structure for strengthening soil embankments. Adv Civ Eng 2018, 2018 4809034

[27] Leng WM, Dong JL, Ai X . Study on design spacing of lateral pressure plate of a new prestressed embankment. J Central South Univ (Sci Technol) 2023, 54 4 1379-1392(in Chinese)

[28] Leng WM, Deng ZL, Xu F . A prestress loss model for subgrade considering creep effect of subgrade soil. Rock Soil Mech 2022, 43 6 1671-1682(in Chinese)

[29] Li Y, Su L, Ling XZ . Model studies on load-settlement characteristics of coarse-grained soil treated with geofiber and cement. Polymers 2018, 10 6 621

[30] Lee SH, Eum KY, Le THM . Evaluation on mechanical behavior of asphalt concrete trackbed with slab panel using full-scale static and dynamic load test. Constr Build Mater 2021, 276

[31] Huang ZC, Su Q, Huang JJ . Field assessment of a subgrade-culvert transition zone constructed with foamed concrete in the ballasted railway. Int J Rail Transp 2024, 12 3 391-413

[32] Huang J, Wang X, Fan R et al (2023) Full-scale model testing of a graded crushed stone sandwich structure within the ballastless track subgrade. Int J Rail Transp 1–23

[33] Lü XL, Ma Q, Mu LL . Model test of the long-term behavior of a pile-net structure subgrade for highspeed railways. J Test Eval 2019, 46 6 2311-2318

[34] Zhang QS, Leng WM, Xu F . Static reinforcement performance and mechanism of new prestressed embankment. J Railway Sci Eng 2023, 20 7 2488-2499(in Chinese)

[35] National Railway Administration of People’s Republic of China (2017) Code for design of heavy haul railway (TB 10625–2017), China Railway Pres, Beijing

[36] Brand L. The Pi theorem of dimensional analysis. Arch Ratio Mech Anal 1957, 1 1 35-45

[37] Curtis WD, Logan JD, Parker WA. Dimensional analysis and the Pi theorem. Linear Algebra Appl 1982, 47 117-126

[38] Ministry of Construction of the People’s Republic of China. Code for design of concrete structures (GB 50010–2010) 2010 Beijing China Architecture and Building Press

[39] Chen M, Sun Y, Guo Y . Study on effect of wheel polygonal wear on high-speed vehicle-track-subgrade vertical interactions. Wear 2019, 432

[40] Shan Y, Wang BL, Zhang JW . The influence of dynamic loading and thermal conditions on tram track slab damage resulting from subgrade differential settlement. Eng Fail Anal 2021, 128

[41] Yao HL, Hu Z, Lu Z . Analytical model to predict dynamic responses of railway subgrade due to high-speed trains considering wheel-track interaction. Int J Geomech 2016, 16 2 04015061

[42] Zhou SH, Guo PJ, Stolle DFE. Interaction Model for “Shelled Particles” and Small-Strain Modulus of Granular Materials. J Appl Mech 2018, 85 10

[43] Yang CW, Sun HL, Zhang JJ . Dynamic responses of bridge-approach embankment transition section of high-speed rail. J Cent South Univ 2013, 20 10 2830-2839

[44] Mei HH, Leng WM, Nie RS . Random distribution characteristics of peak dynamic stress on the subgrade surface of heavy-haul railways considering track irregularities. Soil Dyn Earthq Eng 2019, 116 205-214

[45] Zhang QS, Dong JL, Leng WM . Dynamic stress response in a novel prestressed subgrade under heavy-haul train loading: a numerical analysis. Constr Build Mater 2024, 412

[46] Tang YQ, Xiao SQ, Yang Q. Numerical study of dynamic stress developed in the high speed rail foundation under train loads. Soil Dyn Earthq Eng 2019, 123 36-47

[47] Wu Y, Shi CG, Yu YH . Dynamic behavior of precast epoxy asphalt track bed for transition zone in high-speed railway: a numerical approach. Transp Geotech 2023, 40

[48] Brenkus NR, Tatar J, Hamilton HR . Simplifed fnite element modeling of post-tensioned concrete members with mixed bonded and unbonded tendons. Eng Struct 2019, 179 387-397

[49] Shi YP, Zhou YR. Example analysis of ABAUQS finite element analysis 2006 Beijing China Machine Press

[50] Xu F, Leng WM, Ai X . An analytical model of the additional confning stress in a prestress-reinforcement embankment. Smart Struct Syst 2023, 31 5 517-529

[51] Dong JL, Xu F, Zhang QS . Study on vibration characteristics of fine breccia soil subgrade reinforced with a new prestressed structure under train cyclic loading. Constr Build Mater 2023, 397

[52] Leng WM, Zhang QS, Xu F . Diffusion behavior of additional stress perpendicular to the slope surface in a new prestressed subgrade. Rock Soil Mech 2019, 40 10 3987-4000(in Chinese)

Funding

National Natural Science Foundation of China(51978672)

Natural Science Funding of Hunan Province(2023JJ41054)

Natural Science Research Project of Anhui Educational Committee(2023AH051170)