Wellbore temperature distribution during drilling of natural gas hydrate formation in South China sea

Abstract

The natural gas hydrate resources in the South China Sea alone are about 85 trillion cubic meters. In the drilling process of marine gas hydrate, the natural gas hydrate will decompose and produce gas, as the rising of temperature and dropping of the pressure in the annulus. This process will have a significant impact on drilling safety. Therefore, it is necessary to study the wellbore temperature distribution during the drilling of marine hydrate layer. In this paper, the wellbore temperature distribution of safe drilling in hydrated formation is taken as the research goal, and the research status of relevant domestic and international wellbore temperatures was investigated. According to the characteristics of the marine environment and reservoir-forming characteristics of hydrate reservoirs in the South China Sea, the wellbore temperature distribution model of offshore drilling wellbore under the condition of hydrate decomposition was established. The temperature distribution curve of drilling straight wellbore in hydrate layer of South China Sea was obtained. When drilling the hydrate reservoir, the distribution regularity of the wellbore temperature is similar to that of the conventional offshore drilling wellbore. However, the temperature of the wellbore annulus near the hydrate decomposition site is lower than the ambient temperature, mainly due to the hydrate decomposition endothermic. In this paper, the sensitivity analysis of several main parameters of the wellbore temperature distribution of drilling straight wellbore in hydrate layer of South China Sea was carried out. Through the conduction of experiment and numerical simulation, we have get some new findings: (1) The hydrate saturation has little effect on the wellbore temperature; (2) As the drilling fluid displacement increases, the annulus temperature of the wellbore above the mudline increases, and the temperature of the wellbore below the mudline decreases continuously; (3) As the density of the drilling fluid increases, the temperature at the wellhead decreases, and the temperature at the bottom of the well increases slightly; (4) The greater the rate of penetration of the well, the temperature at the upper part of the wellbore decreases, and the temperature at the bottom of the wellbore increases; Among them, the penetration rate has the most obvious effect on the annular temperature. The results are expected to be helpful to guide the drilling process of marine gas hydrate and offer some references.

Keywords

Wellbore temperature / Natural gas hydrate / South China Sea / Numerical simulation / Sensitivity analysis

Declaration of competing interest

All the authors of this work declare that we have no known competing financial interests or personal relationships that could have appeared to influence the work reported in this paper.

Acknowledgments

The work described in this paper is supported by the prospective research project of petroleum and gas development foundation of science and technology department of Sinopec (P20040-3), Postdoctoral program of Shengli Oilfield, Sinopec (YKB2107), National Key Research and Development Program of China (2019YFC0312302 and 2019YFC0312303), National Natural Science Foundation of China (U20B6005 and 51874252), and 111 Project (D21025).

References

[1] The new beloved energy after shale gasdnatural gas hydrate[J], Nat. Gas. Ind. 36 (5) (2016) 24.

[2] R. Boswell, T.S. Collett, Current perspective on gas hydrate resources[J], Energy Environ. Sci. 4 (4) (2011) 1206-1215.

[3] W.F. Prassl, J.M. Peden, K.W. Wong, Mitigating Gas Hydrate Related Drilling Risks: A Process-Knowledge Management Approach[C]. SPE/IADC Asia Pacific Oil and Gas Conference, 2004. Perth, Australia.

[4] Jicheng Zhang, Kaoping Song, Bo Dong, et al., Pervention and Control of Gas Hydrate for Foam Combination flooding[C]. SPE/IADC Asia Pacific Oil and Gas Conference Melboume, 2002. Australia.

[5] M. Schlunberger, H.G. Doll, Perebionssoff, A temperature measurements in oil wells[J], J. Inst. Pet.Technotogists, Jan 23 (1937) 159.

[6] M.J. Edwardson, H.M. Gimer, Calculation of formation temperature disturbance caused by mud circulation[J], J. Petrol. Technol. 14 (4) (1961) 416-426.

[7] H.J. Ramey, Wellbore heat transmission[J], J. Petrol. Technol. 14 (4) (1962) 427-435.

[8] A. Sater, Heat losses of steam down a wellbore[J], J. Petrol. Technol. 17 (4) (1965) 845-851.

[9] G.P. Willhite, Over-all heat transfer coefficients in stream and hot water injection wells[J], J. Petrol. Technol. 19 (5) (1967) 607-615.

[10] C.S. Holmes, S.C. Swift, Calculation of circulating mud temperatures[J], J. Petrol. Technol. 22 (6) (1970) 670-674.

[11] G.R. Wooley, Computing downhole temperatures in circulation, injection, and production wells[J], J. Petrol. Technol. 32 (9) (1980) 1509-1522.

[12] F.C. Arnold, Temperature variation in a circulating wellbore fluid[J], J. Energy Resour. Technol. 112 (2) (1990) 79-83.

[13] O.O. Harris, O.S. Osisanya, Evaluation of Equivalent Circulating Density of Drilling Fluids under High Pressure High Temperature Conditions[J], 10, SPE Annual Technical Conference and Exhibition, Dallas, Texas, 2005, pp. 9-12.

[14] Gilberto Espinosa-Paredes, Alfonso Garcia-Gutierrez, Thermal behaviour of geothermal wells using mud and airewater mixtures as drilling fluids[J], Energy Convers. Manag. 45 (9-10) (2004) 1513-1527.

[15] Gilberto Espinosa-Paredes G. Erick, Espinosa-Martínez, A feedback-based inverse heat transfer method to estimate unperturbed temperatures in wellbores[J], Energy Convers. Manag. 50 (1) (2009) 140-148.

[16] S. Levitus, T. Boyer, World Ocean Atlas 1994, 4: Temperature[R]. Wash., D. C. NOAA Atlas NESDIS 4, U. S. Gov. Printing Office, 1994, p. 117.

[17] Weiping Zeng, Di Zhou, Gis-aided estimation of gas hydrate resources in southern South China sea[J], Journal of Tropical Oceanography 22 (6) (2003) 35-44.

[18] Xueyong Zhou, Xin Zhou, Calculation of Standard Adsorption Equilibrium Constant from Langmuir Equation[J], 28, University Chemistry, 2013, pp. 50-53, 6.

[19] K. Ostergaard, R. Anderson, M. Llamedo, B. Tohidi, Hydrate phase equilibria in porous media: effect of pore size and salinity[J], Terra. Nova 14 (5) (2002) 307-312.

[20] A. Vysniauskas, P.R. Bishnoi, A kinetic study of methane hydrate formation[J], Chem. Eng. Sci. 38 (7) (1983) 1061-1072.

[21] A.A. Khokhar, Storage Properties of Natural Gas Hydrates[D], Nonvegian University of Science and Technology, Trondheim, 1998.

[22] Shiming He, The Research of Prediction and Distribution Law for Fluid's Temperature in the Wellbore[D], Doctoral thesis of Southwest University of Petroleum, 1998.

[23] Maoyan Hu, Wenbin Yin, Xiuhua Zheng, Bai-ru Xia, Analyses on calculation methods of rheological parameters of drilling fluid and optimization of rheological model[J], Ore Prospecting Engineering (Geotechnical Drilling Engineering) 31 (7) (2004) 41-45.

[24] S. Levitus, T. Boyer, World Ocean Atlas 1994, 4: Temperature[R]. Wash., D. C. NOAA Atlas NESDIS 4, U. S. Gov. Printing Office, 1994, p. 117.