Experimental study on sand production and coupling response of silty hydrate reservoir with different contents of fine clay during depressurization

Abstract

To further understand the characteristics of clay and sand production (hereafter collectively referred to as sand production) and to provide optimization designs of sand control schemes are critical for gas production from clayey silt natural gas hydrate reservoirs in the South China Sea. Thus, gas-water-sand production behavoirs and coupling reservoir subsidence characteristics before, during, and after hydrate dissociation of the clayey silt hydrate reservoirs with different clay contents (5%, 10%, 15%, 20%, 25%, and 30%) have been studied through a self-developed experimental system. The results show that with the increase of clay content, the total mass of sand production first increases and then decreases, and it reaches maximum when the clayey content is 20%. The sand production is the lowest before hydrate dissociation and increases significantly during hydrate dissociation, which mainly occurs in the high-speed gas and water production stage at the beginning of hydrate dissociation. After hydrate dissociation, the sand production decreases significantly. During the whole depressurization process, the clay and free sand particles generally move to the sand outlet due to the fluid driving force and overlying stress extrusion. However, for conditions of high clay contents, those particles fail to pass through the sand control screen and gradually accumulate and block the screen by forming a mud cake, which greatly reduce the permeability of the screen and limite sand production as well as gas and water production. Our research lays a foundation for sand production prediction and sand control scheme selection during gas recovery from clayey silty hydrate reservoirs that greatly need to consider a balance between sand control and gas productivity.

Keywords

Natural gas hydrate / Clayey silt reservoir / Clay content / Depressurization / Sand production / Sand control

Declaration of competing interest

The manuscript is approved by all authors for publication. We authors confirm that no conflict of interest exits in the submission of this manuscript. The original work has not been published previously and is not under consideration for publication elsewhere, in whole or in part.

Acknowledgement

This work was supported by the National Key Research and Development Program of China (2018YFE0126400), the China Geological Survey Project (DD20190232), the Qingdao National Laboratory for Marine Science and Technology Open Fund (QNLM2016ORP0203), the Department of Natural Resources of Guangdong Province Project (GDNRC[2020]-047).

References

[1] Y.F. Makogon, S.A. Holditch, T.Y. Makogon, Natural gas-hydrates d a potential energy source for the 21st Century[J], J. Petrol. Sci. Eng. 56 (1-3) (2007) 14-31.

[2] R. Boswell, Is gas hydrate energy within reach[J], Science 325 (5943) (2009) 957-958.

[3] A.K. Sum, C.A. Koh, E.D. Sloan, Clathrate hydrates: from laboratory science to engineering practice[J], Ind. Eng. Chem. Res. 48 (16) (2009) 7457-7465.

[4] B. Tohidi, R. Anderson, A. Chapoy, et al., Do we have new solutions to the old problem of gas hydrates[J], Energy Fuel. 26 (7) (2012) 4053-4058.

[5] Y. Liu, I.K. Gamwo, Comparison between equilibrium and kinetic models for methane hydrate dissociation[J], Chem. Eng. Sci. 69 (1) (2012) 193-200.

[6] Wei Wei, Jinhua Zhang, Rongze Yu, et al., Review on natural gas hydrate in 2017[J], Sci. Technol. Rev. 36 (2018) 83-90, 001.

[7] S.R. Dallimore, T.S. Collett, T. Uchida, et al., Overview of the Science Activities for the 2002 Mallik Gas Hydrate Production Research Well Program, Mackenzie Delta,N.W.T. Canada[C]// Egs-Agu-Eug Joint Assembly, 2003.

[8] R.M. Haberer, M. Kai, H. Wilkes, et al., Occurrence and palaeoenvironmental significance of aromatic hydrocarbon biomarkers in oligocene sediments from the mallik 5L-38 gas hydrate production research well (Canada)[J], Org. Geochem. 37 (5) (2006) 519-538.

[9] T. Graver, G. Moridis, S.A. Holditch, Analysis of reservoir performance of messoyakha gas hydrate field[D], in:Proceedings of the International Offshore and Polar Engineering Conference, 2008.

[10] K. Yamamoto, S.R. Dallimore,Overview of the 2006-2008 JOGMEC/NRCan/Aurora Mallik Gas Hydrate Production Test Program[C]//, 2008.

[11] Y. Zhang, J. Sunarso, S. Liu, et al., Current status and development of membranes for CO2/CH4 separation: a review[J], International Journal of Greenhouse Gas Control 12 (1) (2013) 84-107.

[12] S. Abendroth, J. Thaler, J. Klump, et al., Numerical modeling of the simulated gas hydrate production test at Mallik 2L-38 in the pilot scale pressure reservoir LARS -applying the[J], Egu General Assembly 16 (2014) 38-43.

[13] S. Chee, T. Leokprasirtkul, T. Kanno, et al., A Deepwater Sandface Monitoring System for Offshore Gas hydrate[R]. OTC-25328-MS, Offshore Technology Conference, Houston, Texas, 2014.

[14] K. Yamamoto, Y. Terao, T. Fujji, et al., Operational Overview of the First Offshore Production Test of Methane Hydrates in the Eastern Nankai Trough[R]. OTC-25243-MS, Offshore Technology Conference, Houston, Texas, 2014.

[15] B. Kvamme, Feasibility of simultaneous CO₂ storage and CH4 production from natural gas hydrate using mixtures of CO₂ and N2[J], Can. J. Chem. 10 (2015) 21-30.

[16] Y. Konno, J. Yoneda, K. Egawa, et al., Permeability of sediment cores from methane hydrate deposit in the Eastern Nankai Trough[J], Mar. Petrol. Geol. 66 (2015) 487-495.

[17] Wei Zhang, Mingjuan Shao, Qianning Tian, Technical progress of a pilot project to produce natural gas hydrate in Japanese waters[J], Petroleum Drilling Techniques (2017) 98-102, 045(005).

[18] J.F. Li, J.L. Ye, X.W. Qin, et al., The first offshore natural gas hydrate production test in South China Sea[J], China Geology 2096-5192 (1) (2018) 5-16.

[19] Shiguo Wu, Jiliang Wang, On the China's successful gas production test from marine gas hydrate reservoirs[J], Chin. Sci. Bull. 63 (2018) 2-8, 01.

[20] Jianliang Ye, Xuwen Qin, Wenwei Xie, et al., Main progress of the second gas hydrate trial production in the South China Sea[J], Chin. Geol. 47 (3) (2020) 557-568.

[21] T. Grover, Natural Gas Hydrates -Issues for Gas Production and Geomechanical stability[D], 2008.

[22] P. Bhade, J. Phirani, Gas production from layered methane hydrate reservoirs[J], Energy 82 (2015) 686-696.

[23] T. Collett, J.J. Bahk, R. Baker, et al., Methane hydrates in naturedcurrent knowledge and challenges[J], J. Chem. Eng. Data 60 (2) (2015) 319-329.

[24] Fulong Ning, Xiangyu Fang, Yanlong Li, et al., Research status and perspective on wellbore sand production from hydrate reservoirss[J], Bulletin of Geological Science and Technology 39 (1) (2020) 137-148.

[25] F.L. Ning, J.X. Sun, Z.C. Liu, et al., Prediction of Sand Production in Gas Recovery by depressurization[C]// Proceedings of the 9th International Conference on Gas Hydrate, ICGH9, Denver, Colorado, USA, 2017.

[26] G. Han, T.H. Kwon, J.Y. Lee, et al., Depressurization-induced fines migration in sediments containing methane hydrate: X-ray computed tomography imaging experiments[J], J. Geophys. Res.: Solid Earth 123 (2018) 2539-2558.

[27] J. Lu, Y. Xiong, D. Li, et al., Experimental investigation of characteristics of sand production in wellbore during hydrate exploitation by the depressurization method[J], Energies 11 (7) (2018) 1673.

[28] J. Lu, D. Li, Y. He, et al., Experimental study of sand production during depressurization exploitation in hydrate silty-clay sediments[J], Energies 12 (22) (2019) 4268.

[29] H. Oyama, J. Nagao, K. Suzukii, et al., Experimental analysis of sand production from methane hydrate bearing sediments applying depressurization method[J], Journal of MMIJ 126 ( 8/9) (2010) 497-502.

[30] J.W. Jung, J. Jang, J.C. Santamarina, et al., Gas production from hydrate-bearing sediments: the role of fine particles[J], Energy Fuel. 26 (1) (2012) 480-487.

[31] S. Suzuki, R. Kuwano, Evaluation on stability of sand control in mining methane hydrate[J], Production research 68 (4) (2016) 311-314.

[32] S. Uchida, A. Klar, K. Yamamoto, Sand production model in gas hydratebearing sediments[J], Int. J. Rock Mech. Min. Sci. 86 (2016) 303-316.

[33] A. Murphy, K. Soga, K. Yamamoto, A Laboratory Investigation of Sand Production Simulating the 2013 Daini-Atsumi Knoll Gas Hydrate Production Trial Using a High Pressure Plane Strain Testing apparatus[C]// Proceedings of the 9th International Conferences on Gas Hydrate, IGGH9, Denver, Colorado, USA, 2017.

[34] C.L. Yan, Y. Li, Y.F. Cheng, et al., Sand production evaluation during gas production from natural gas hydrates[J], J. Nat. Gas Sci. Eng. 57 (2018) 77-88.

[35] J.P. Ding, Y.F. Cheng, C.L. Yan, et al., Experimental study of sand control in a natural gas hydrate reservoir in the South China Sea[J], Int. J. Hydrogen Energy (44) (2019) 23639-23648.

[36] J. Lee, T. Ahn, J.Y. Lee, et al., Laboratory Test to Evaluate the Performance of Sand Control Screens during Hydrate Dissociation Process by depressurization[R]. ISOPE-M-13-035, International Society of Offshore and Polar Engineers, Szczecin, Poland, 2013.

[37] Changyin Dong, Yixin Zhong, Yanxin Wu, et al., Experimental study on sand retention mechanisms and feasibility evaluation of sand control for gas hydrate reservoirs with highly clayey fine sands[J], Journal of China University of Petroleum(Edition of Natural Science) 42 (6) (2018) 84-92.

[38] Yu Lu, Liang Zhang, Rui Zhang, et al., Assessment of Natural Gas Production from Hydrate-Bearing Sediments with Unconsolidated Argillaceous Siltstones via a Controlled Sandout method[J], Energy, 2018, pp. 654-667.

[39] Jingsheng Lu, Dongliang Li, Yong He, et al., Research status of sand production during the gas hydrate exploitation process[J], Advances in New and Renewable Energy 5 (5) (2017) 394-402.

[40] Fulong Ning, Xiaofeng Dou, Jiaxin Sun, et al., Progress in numerical simulation of sand production from hydrate reservoirs[J], Petroleum Science Bulletin 5 ( 2) (2020) 182-203.

[41] Xiangyu Fang, Fulong Ning, Linjie Wang, Liu, et al., Dynamic coupling responses and sand production behavior of gas hydrate-bearing sediments during depressurization: an experimental study[J], J. Petrol. Sci. Eng. (2021) 201.

[42] H. Ghiassian, J.L.H. Grozic, Strength behavior of methane hydrate bearing sand in undrained triaxial testing[J], Mar. Petrol. Geol. 43 (2013) 310-319.

[43] Rongtao Yan, Changfu Wei, Xinhui Fu, et al., Influence of occurrence mode of hydrate on mechanical behaviour of hydrate-bearing soils[J], Chin. J. Rock Mech. Eng. 32 (2013) 4115-4122.

[44] Han H, Wang Y, Li X, et al. EXperimental study on sediment deformation during methane hydrate decomposition in sandy and silty clay sediments with a novel experimental apparatus[J]. Fuel, 182: 446-453.

[45] W.J. Winters, W.F. Waite, D.H. Mason, et al., Methane gas hydrate effect on sediment acoustic and strength properties[J], J. Petrol. Sci. Eng. 56 (1-3) (2007) 127-135.

[46] Jiawang Cheng, Su Zheng, Nengyou Wu, A geomechanical stability model analysis of hydrate reservoir for gas hydrate production by depressurization[J], Advances in New and Renewable Energy 4 (2016) 35-43, 01.

[47] Jingsheng Lu, Youming Xiong, Dongliang Li, et al., Experimental study on sand production and seabottom subsidence of non-diagenetic hydrate reservoirs in depressurization production[J], Mar. Geol. Quat. Geol. 39 (4) (2019) 183-195.

[48] M. Hyodo, Y. Nakata, N. Yoshimoto, et al., Shear behaviour of methane hydrate-bearing sand[J], Proceedings of the Seventeenth (2007) 1326(. -+).

[49] Z. Liu, S. Dai, F. Ning, et al., Strength estimation for hydrate-bearing sediments from direct shear tests of hydrate-bearing sand and silt[J], Geophys. Res. Lett. 45 (2) (2018) 715-723.

[50] Changyin Dong, Qinghua Zhang, Kaige Gao, et al., Screen sand retaining precision optimization experiment and a new empirical design model[J], Petrol. Explor. Dev. 43 (6) (2016) 1082-1088.

[51] C. Dong, K. Gao, S. Dong, et al., A new integrated method for comprehensive performance of mechanical sand control screens testing and evaluation[J], J. Petrol. Sci. Eng. 158 (2017) 775-783.