Interface-engineered Bi₂Te₃ powders via atomic layer deposited TiO₂-ZnO multilayer for improved thermoelectric performance

Abstract

Tailoring the interfacial properties at the nanoscale is essential for improving the performance of thermoelectric materials, where the simultaneous optimization of electronic and phononic transport remains a key challenge. We used atomic layer deposition (ALD) to conformally coat Bi₂Te₃Se_0.3 (BTS) powders with TiO₂-ZnO multilayer oxides. Two configurations were fabricated: ZnO/TiO₂ bilayers (2 nm thick) and ZnO/TiO₂/ZnO/TiO₂ multilayers (1 nm thick). The coated powders were consolidated by spark plasma sintering (SPS). The ALD-grown multilayers uniformly coated the powder and remained highly dense after sintering. Consequently, the multilayer-coated structure showed improved carrier concentration and mobility owing to interfacial electron donation and diffusion doping, enhancing electrical conductivity. Their high-density and continuous layers effectively reduce lattice thermal conductivity, resulting in a zT of 0.8 at 460 K, a 27% increase over uncoated BTS. The controlled interface design enabled effective tuning of both charge carrier and phonon transport. This study demonstrates that conformal interfacial engineering via ALD is a promising strategy for enhancing thermoelectric performance by simultaneously tuning the electronic and phononic transport properties through nanoscale interface design.

Keywords

Thermoelectrics / atomic layer deposition / interface engineering / multilayer

References

[1] D’angelo M.,Galassi C.,Lecis N.. Thermoelectric materials and applications: a review Energies 2023 16 6409

[2] Massetti M.,Jiao F.,Ferguson A. J..et al. Unconventional thermoelectric materials for energy harvesting and sensing applications Chem. Rev. 2021 121 12465 547

[3] Finn P. A.,Asker C.,Wan K.,Bilotti E.,Fenwick O.,Nielsen C. B.. Thermoelectric materials: current status and future challenges Front. Electron. Mater. 2021 1 677845

[4] Zafar M. H.,Khan N. M.,Mansoor M.,Khan U. A.. Towards green energy for sustainable development: machine learning based MPPT approach for thermoelectric generator J. Clean. Prod. 2022 351 131591

[5] Champier D.. Thermoelectric generators: a review of applications Energy Convers. Manag. 2017 140 167 81

[6] Bu Z.,Zhang X.,Hu Y..et al. A record thermoelectric efficiency in tellurium-free modules for low-grade waste heat recovery Nat. Commun. 2022 13 237 PMC8752736

[7] Zhu T.,Liu Y.,Fu C.,Heremans J. P.,Snyder J. G.,Zhao X.. Compromise and synergy in high-efficiency thermoelectric materials Adv. Mater. 2017 29 1605884

[8] Okirigiti M. A.,Kim C. M.,Choi H.,Alluri N. R.,Park K.. Recent advances in thermoelectric materials and devices: improving power generation performance J. Powder Mater. 2025 32 1 15

[9] Bae J.,Jo S.,Kim K. T.. Enhancing electrical properties of N-type bismuth telluride alloys through graphene oxide incorporation in extrusion 3D printing J. Powder Mater. 2023 30 318 23

[10] Lee S.,Park T. J.,Kim S. K.. Recent progress on performance improvements of thermoelectric materials using atomic layer deposition J. Powder. Mater. 2022 29 56 62

[11] Lee S.,Jung S.,Park G. M..et al. Grain boundary engineering strategy for simultaneously reducing the electron concentration and lattice thermal conductivity in n-type Bi₂Te_2.7Se_0.3-based thermoelectric materials J. Eur. Ceram. Soc. 2023 43 3376 82

[12] Lim S.,Kim K.,Lee S..et al. Carrier Modulation in Bi₂Te₃-based alloys via interfacial doping with atomic layer deposition Coatings 2020 10 572

[13] Lee S.,Park G. M.,Kim Y..et al. Unlocking the potential of porous Bi₂Te₃-based thermoelectrics using precise interface engineering through atomic layer deposition ACS Appl. Mater. Interfaces 2024 16 17683 91

[14] Park K. H.,Mohamed M.,Aksamija Z.,Ravaioli U.. Phonon scattering due to van der Waals forces in the lattice thermal conductivity of Bi₂Te₃ thin films J. Appl. Phys. 2015 117 015103

[15] Fang T.,Li X.,Hu C..et al. Complex band structures and lattice dynamics of Bi₂Te₃-based compounds and solid solutions Adv. Funct. Mater. 2019 29 1900677

[16] Li C.,Zhou Z.,Lou Y.,Fu L.. Lattice softening in thermoelectric materials Microstructures 2025 5 2025075

[17] Dharmaiah P.,Jung S.,Kim J.,Kim S. K.,Baek S.. Why is it challenging to improve the thermoelectric properties of n-type Bi₂Te₃ alloys? Appl. Phys. Rev. 2024 11 031312

[18] Irfan S.,Yan Z.,Khan S. B.. Advancements in thermoelectric materials: a comprehensive review Mater. Sci. Energy Technol. 2024 7 349 73

[19] Theja V. C. S.,Karthikeyan V.,Assi D. S.,Roy V. A. L.. Insights into the classification of nanoinclusions of composites for thermoelectric applications ACS Appl. Electron. Mater. 2022 4 4781 96

[20] Lu X.,Pan G.,Shi Z.,Xu B.,Lou Y.. Recent advances in interface engineering of thermoelectric nanomaterials Mater. Chem. Front. 2023 7 4707 22

[21] Li S.,Wang L.,Ma D.,Jiang Y.,Guo K.,Luo J.. Recent advances in atomic layer deposition-based interface modification engineering in thermoelectric materials Mater. Today Phys. 2023 39 101287

[22] Kim K. C.,Lim S. S.,Lee S. H..et al. Precision interface engineering of an atomic layer in bulk Bi₂Te₃ alloys for high thermoelectric performance ACS Nano 2019 13 7146 54

[23] He S.,Bahrami A.,Zhang X.,Martínez I. G.,Lehmann S.,Nielsch K.. Effect of powder ALD interface modification on the thermoelectric performance of bismuth Adv. Mater. Technol. 2021 7 2100953

[24] Park G. M.,Lee S.,Park T. J.,Baek S. H.,Kim J. S.,Kim S. K.. Controlled engineering of defects and interfaces in thermoelectric materials with atomic layer deposition Adv. Mater. Interfaces 2024 12 2400581

[25] George S. M.. Atomic layer deposition: an overview Chem. Rev. 2010 110 111 31

[26] Liu W.,Hu J.,Zhang S.,Deng M.,Han C.,Liu Y.. New trends, strategies and opportunities in thermoelectric materials: a perspective Mater. Today Phys. 2017 1 50 60

[27] Jung C.,Jeon S.,Lee S..et al. Reduced lattice thermal conductivity through tailoring of the crystallization behavior of NbCoSn by V addition J. Alloys Compd. 2023 962 171191

[28] Bueno Villoro R.,Zavanelli D.,Jung C..et al. Grain boundary phases in NbFeSb half‐heusler alloys: a new avenue to tune transport properties of thermoelectric materials Adv. Energy Mater. 2023 13 2204321

[29] Pei Y.,Wang H.,Snyder G. J.. Band engineering of thermoelectric materials Adv. Mater. 2012 24 6125 35

[30] Venkatasubramanian R.,Siivola E.,Colpitts T.,O’Quinn B.. Thin-film thermoelectric devices with high room-temperature figures of merit Nature 2001 413 597 602

[31] Bueno Villoro R.,Hatami Naderloo R.,Mattlat D. A..et al. Composite design of half-Heusler thermoelectrics: selective doping of grain boundary phases in NbFeSb by InSb Mater. Today Phys. 2023 38 101240

[32] Zheng Y, ; Slade TJ, ; Hu L, ; et al. Defect engineering in thermoelectric materials: what have we learned? Chem. Soc. Rev. 2021 50 9022 54

[33] Jung C.,Dutta B.,Dey P..et al. Tailoring nanostructured NbCoSn-based thermoelectric materials via crystallization of an amorphous precursor Nano Energy 2021 80 105518

[34] Zhang Y.,Peng G.,Li S..et al. Phase interface engineering enables state-of-the-art half-Heusler thermoelectrics Nat. Commun. 2024 15 5978 PMC11252142

[35] Luo Y.,Zhu J.,Rao X..et al. Optimized interface engineering enhances carrier and phonon scattering for superior thermoelectric performance in Yb-filled skutterudites ACS Appl. Mater. Interfaces 2025 17 8047 54

[36] Santhosh R.,Kamalakannan S.,Harish S.,Archana J.,Ponnusamy S.,Navaneethan M.. Interface-driven energy filtering effect and enhanced thermoelectric performance of Ag₂Se/SnS composites: an experimental and theoretical insights J. Colloid Interface Sci. 2025 691 137375

[37] He S.,Bahrami A.,Jung C..et al. Precision interface engineering of CuNi alloys by powder ALD toward better thermoelectric performance Adv. Funct. Mater. 2024 34 2314457

[38] Jung M. J.,Ji M.,Han J. H..et al. Atomic layer deposition of ZnO layers on Bi₂Te₃ powders: comparison of gas fluidization and rotary reactors Ceram. Int. 2022 48 36773 80

[39] Jung M. J.,Park J. Y.,Eun S. M.,Choi B. J.. Thermoelectric performance enhancement of sintered Bi-Te Pellets by rotary-type atomic layer deposition J. Powder Mater. 2023 30 130 9

[40] Yang J.,Daqiqshirazi M.,Ritschel T..et al. Interfacial distortion of Sb₂Te₃-Sb₂Se₃ multilayers via atomic layer deposition for enhanced thermoelectric properties ACS Nano 2024 18 17500 8

[41] Rawther A. N.,Rout U.,S P. K. D.,Ramanathan R.,Mallik R. C.. Thermoelectric properties of sputter deposited Bi₂Te₃-PbTe multilayer thin films Phys. B Condens. Matter 2024 673 415467

[42] Wang G.,Meng F.,Chen Y.,Lotnyk A.,Shen X.. Boosting thermoelectric performance of Bi₂Te₃ material by microstructure engineering Adv. Sci. 2024 11 e2308056 PMC10853752

[43] Kong F.,Bai J.,Zhao Y..et al. Ultralow thermal conductivity and high thermoelectric performance of Cu₂Se/TiO₂ nanocomposite Appl. Phys. Lett. 2019 115 203901

[44] Liu C.,Miao L.,Zhou J.,Huang R.,Fisher C. A. J.,Tanemura S.. Chemical tuning of TiO₂ nanoparticles and sintered compacts for enhanced thermoelectric properties J. Phys. Chem. C 2013 117 11487 97

[45] Liu H.,Ma H.,Su T..et al. High-thermoelectric performance of TiO_2-x fabricated under high pressure at high temperatures J. Materiomics 2017 3 286 92

[46] Liu X.,Kepaptsoglou D.,Gao Z..et al. Controlling the thermoelectric properties of Nb-doped TiO₂ ceramics through engineering defect structures ACS Appl. Mater. Interfaces 2021 13 57326 40

[47] Tsubota T.,Ohtaki M.,Eguchi K.,Arai H.. Thermoelectric properties of Al-doped ZnO as a promising oxide material for high-temperature thermoelectric conversion J. Mater. Chem. 1997 7 85 90

[48] Jayaseelan V.,Mani N.,Eswaran S. K.. Large electrical conductivity and thermoelectric power factor of pulsed laser-deposited Zn_xGa_xO thin films ACS Appl. Energy Mater. 2024 7 1693 9

[49] Bakos L. P.,Justh N.. Moura da Silva Bezerra da Costa, U. C.; et al. Photocatalytic and gas sensitive multiwalled carbon nanotube/TiO₂-ZnO and ZnO-TiO₂ composites prepared by atomic layer deposition Nanomaterials 2020 10 252

[50] Wang H.,Gurunathan R.,Fu C.,Cui R.,Zhu T.,Snyder G. J.. Thermoelectric transport effects beyond single parabolic band and acoustic phonon scattering Mater. Adv. 2022 3 734 55

[51] Li S, ; Chu M, ; Zhu W, ; et al. Atomic-scale tuning of oxygen-doped Bi₂Te_2.7Se_0.3 to simultaneously enhance the Seebeck coefficient and electrical conductivity Nanoscale 2020 12 1580 8

[52] Li D.,Li J. M.,Li J. C..et al. High thermoelectric performance of n-type Bi₂Te_2.7Se_0.3 via nanostructure engineering J. Mater. Chem. A. 2018 6 9642 9

[53] Liu Y.,Zhang Y.,Lim K. H..et al. High thermoelectric performance in crystallographically textured n-type Bi₂Te_3-xSe_x produced from asymmetric colloidal nanocrystals ACS Nano 2018 12 7174 84

[54] Kim G.,Lee K.,Shin H..et al. Strong enhancement of room-temperature thermoelectric properties of Cu-doped Bi₂Te_2.7Se_0.3 Appl. Phys. Lett. 2022 120 043903

[55] Li Q.,Wei Z.,Ma Q.,Li Z.,Luo J.. Optimizing room-temperature thermoelectric performance of n-type Bi₂Te_2.7Se_0.3 ACS Omega 2021 6 33883 8 PMC8675032

[56] Chen T.,Li S.,Chen K..et al. Enhancing thermoelectric performance of n-type Bi₂Te_2.7Se_0.3 through Incorporation of amorphous Si₃N₄ nanoparticles ACS Appl. Mater. Interfaces 2024 16 22016 24