^{Upcycling coal gangue in alkali-activated pervious concrete: a sustainable pathway to sponge city infrastructure}

Abstract

This study explores the use of coal gangue powder (CGP) to enhance the workability of ground granulated blast-furnace slag (GGBS)-based geopolymer pervious concrete (GPCC) and promote the reuse of industrial waste. CGP was introduced as a partial replacement for GGBS at rates ranging from 0 to 50%. The impact of CGP on the multiscale properties of GPCC was evaluated, including rheology, mechanical strength, permeability, frost resistance, and pore structure. Incorporating CGP improved paste flowability by reducing yield stress, plastic viscosity, and thixotropy. However, mechanical strength declined with increasing CGP content. At 40% replacement, the 28-day compressive strength dropped to 17.9 MPa, falling below the C20 strength class defined in relevant specifications. Although CGP increased total porosity, permeability decreased. This was likely due to bottom pore blockage caused by changes in flow behavior. Frost resistance also diminished at higher CGP rates, with over 7% mass loss and 20% strength loss after 25 freeze–thaw cycles. Pore structure analysis revealed a shift toward larger pores, reducing compactness and long-term durability. When CGP content was limited to 30% or less, GPCC maintained a balanced performance across strength, permeability, durability, and workability. These results highlight the potential of CGP-based geopolymers in sustainable infrastructure applications, especially in sponge cities and pervious pavement systems.

Keywords

Coal gangue powder / Geopolymer pervious concrete / Water permeability / Frost resistance / Pore structure analysis

References

[1] Ikhine IV, Rosti F, Hosseinpour F, Gopu V, Cooper SIII. Experimental study on the strength behavior of concrete reinforced with cornhusk fiber. Steps For Civil. Constructions and Environmental Engineering. 2025, 3(1): 1-16.

[2] Jahami A, Zeaiter N, Cheaib M. Reviewing the potential: A comprehensive review of natural fibers (NFs) in structural concrete and their multifaceted influences. Innovative Infrastructure Solutions. 2024, 9(4. 102

[3] Jahami A, Younes H, Khatib J. Enhancing reinforced concrete beams: Investigating steel dust as a cement substitute. Infrastructures. 2023, 811. 157

[4] Sukkari A, Al-Khateeb G, Wajeeh M, Ezzat H, Zeiada W. Impact of Sasobit on asphalt binder’s performance under UAE local conditions. Steps For Civil. Constructions and Environmental Engineering. 2024, 23): 1-8.

[5] Nasan Agha W. A framework for assessing sustainability in post-disaster reconstruction projects on the example of Syria. Steps For Civil. Constructions and Environmental Engineering. 2024, 2(2): 17-34.

[6] Zhang D, Zhu T, Yang Q, Vandeginste V, Li J. Influence of ground granulated blast furnace slag on recycled concrete powder-based geopolymer cured at ambient temperature: Rheology, mechanical properties, reaction kinetics and air-void characteristics. Construction and Building Materials. 2024, 438. 137190

[7] Qin Y, Pu Y. Characteristics of environmentally friendly permeable concrete with non-clinker blast furnace slag cement. Concrete. 2009, 3: 52-55

[8] Chang J, Yeih W, Chung T, Huang R. Properties of pervious concrete made with electric arc furnace slag and alkali-activated slag cement. Construction and Building Materials. 2016, 109: 34-40.

[9] Sun Z, Lin X, Vollpracht A. Pervious concrete made of alkali activated slag and geopolymers. Construction and Building Materials. 2018, 189: 797-803.

[10] Huang W, Wang H. Multi-aspect engineering properties and sustainability impacts of geopolymer pervious concrete. Composites Part B: Engineering. 2022, 242. 110035

[11] Liu M, Wang C, Wu H, Yang D, Ma Z. Reusing recycled powder as eco-friendly binder for sustainable GGBS-based geopolymer considering the effects of recycled powder type and replacement rate. Journal of Cleaner Production. 2022, 364. 132656

[12] El-Hassan H, Kianmehr P. Pervious concrete pavement incorporating GGBS to alleviate pavement runoff and improve urban sustainability. Road Materials and Pavement Design. 2018, 19(1): 167-181.

[13] Pu B, Liu B, Li L, Jiang L, Zhou J, Ding P. Using rice husk ash in alkali-activated ultra-high-performance concrete: Flowability, early age strength and elasticity modulus. Construction and Building Materials. 2024, 443. 137771

[14] Yuan S, Duan D, Sun J, Yu Y, Wang Y, Huang B, Peng J, Mohamed S, Wang X. Mechanical, alkali excitation, hydrothermal enhancement of 3D printed concrete incorporated with antimony tailings. Construction and Building Materials. 2024, 443. 137610

[15] Marathe S, Sadowski Ł, Shree N. Geopolymer and alkali-activated permeable concrete pavements: Bibliometrics and systematic current state of the art review, applications, and perspectives. Construction and Building Materials. 2024, 421. 135586

[16] Xu F, Li X, Xiong Q, Li Y, Zhu J, Yang F, Sun T, Peng C, Lin J. Influence of aggregate reinforcement treatment on the performance of geopolymer recycled aggregate permeable concrete: From experimental studies to PFC 3D simulations. Construction and Building Materials. 2022, 354. 129222

[17] Merino-Lechuga AM, Lamaa G, Silva RV, de Brito J, Jiménez JR, Fernández-Rodríguez JM, González-Caro Á. Accelerated carbonation of alkali-activated vibro-compacted pervious concrete paving blocks. Construction and Building Materials. 2024, 449. 138458

[18] Wu H, Chen C, Song W, Hou W. High-capacity utilization of coal gangue as supplementary cementitious material, geopolymer, and aggregate: A review. Construction and Building Materials. 2024, 435. 136857

[19] Zhu H, Yang S, Li W, Li Z, Fan J, Shen Z. Study of mechanical properties and durability of alkali-activated coal gangue-slag concrete. Materials. 2020, 13(23. 5576

[20] Zhang D, Zhu T, Ai Q, Mao M, Li J, Yang Q. Performance of coal gangue concrete with fly ash and ground-granulated blast slag: Rheology, mechanical properties and microstructure. Construction and Building Materials. 2024, 427. 136250

[21] Liu R, Wang S. Research progress on the comprehensive utilization of coal gangue. International Journal of Coal Preparation and Utilization. 2025.

[22] Sun Y, Bai B, Yang X, Zhu S, Tian J, Wang Z, Xu L, Xu L, Shen B. Coal gangue utilization: Applications, challenges, and sustainable development strategies. Energies. 2025, 182. 444

[23] Zhong M, Meng J, Ning B, Na F, Cui T, Shi X, Cui T. Preparation and alkali excitation mechanism of coal gangue-iron ore tailings non-sintering ceramsite. Construction and Building Materials. 2024, 426. 136209

[24] Mischinenko V, Vasilchenko A, Lazorenko G. Effect of waste concrete powder content and microwave heating parameters on the properties of porous alkali-activated materials from coal. Gangue. Materials. 2024, 1722. 5670

[25] Qi R, Xu Z, Jiang Y, Liu X, Pan T. Effects of superplasticizer dosage on cement slurry rheological characteristics, pore structure and properties of pervious concrete. Construction and Building Materials. 2025, 479. 141457

[26] Chen S, Ruan S, Zeng Q, Liu Y, Zhang M, Tian Y, Yan D. Pore structure of geopolymer materials and its correlations to engineering properties: A review. Construction and Building Materials. 2022, 328. 127064

[27] Wei Y, Chen X, Chai J, Qin Y. Correlation between mechanical properties and pore structure deterioration of recycled concrete under sulfate freeze-thaw cycles: An experimental study. Construction and Building Materials. 2024, 412. 134794

[28] Wu C, Jiang W, Zhang C, Li J, Wu S, Wang X, Xu Y, Wang W, Feng M. Preparation of solid-waste-based pervious concrete for pavement: A two-stage utilization approach of coal gangue. Construction and Building Materials. 2022, 319. 125962

[29] Zhang J, Jin C, Wang B, Han J, Guo L, Tang N. Study on the micro-rheological properties of fly ash-based cement mortar. Construction and Building Materials. 2024, 442. 137664

[30] Han X, Ding N, Chen A, Wang Z, Xu Y, Feng L, Ji Y, Li K, Jing J, Sun S, Zhang Q. Experimental study on freeze-thaw failure of concrete incorporating waste tire crumb rubber and analytical evaluation of frost resistance. Construction and Building Materials. 2024, 439. 137356

[31] Xiao J, Lv Z, Duan Z. Pore structure characteristics, modulation and its effect on concrete properties: A review. Construction and Building Materials. 2023, 397. 132430

[32] Yin W, Yan L, Wu H, Lu Y, Zhang C, Zhong H. Effects of nanoscale CSH seeds dispersed in PCE on rheological and early mechanical properties of mortar. Case Studies in Construction Materials. 2024, 21. e04035

[33] Carvalho IC, Melo ARS, Melo CDR, Brito MS, Chaves AR, Babadopulos LFAL, Bastos JBS. Evaluation of the effect of rubber waste particles on the rheological and mechanical properties of cementitious materials for 3D printing. Construction and Building Materials. 2024, 411. 134377

[34] Li L, Wei Y, Li Z, Farooqi M. Rheological and viscoelastic characterizations of fly ash/slag/silica fume-based geopolymer. Journal of Cleaner Production. 2023, 354. 131629

[35] Alexander AE, Shashikala AP. Studies on the microstructure and durability characteristics of ambient cured FA-GGBS based geopolymer mortar. Construction and Building Materials. 2022, 347. 128538

[36] Mandal R, Panda SK, Nayak S. Rheology of concrete: Critical review, recent advancements, and future prospectives. Construction and Building Materials. 2023, 392. 132007

[37] Hu Y, Han X, Sun Z, Jin P, Li K, Wang F, Gong J. Study on the reactivity activation of coal gangue for efficient utilization. Materials (Basel). 2023, 1618): 6321.

[38] Zhang Y, Liu W, Liu M. Setting time and mechanical properties of chemical admixtures modified FA/GGBS-based engineered geopolymer composites. Construction and Building Materials. 2024, 431. 136473

[39] Zhang C, Wang M, Liu R, Li X, Liu Y, Jiang P, Yan J, Zhu Z, Chen M. Rheological properties of cement-based slurry and evaluation of rheological model: Influence of particle size and shape. Construction and Building Materials. 2023, 406. 133498

[40] Wang X, Zhou M, Bai J, Liao Y, Li D, Zhang B. Research on the rheological properties and diffusion law of coal-based solid waste geopolymer grouting material. Materials. 2024, 1722. 5433

[41] Lei T, Qiu J, Li L, Huo Y, Zhang T. Study on properties of basalt fiber coal gangue concrete modified by supplementary cementitious materials: Mechanics, durability, microstructure. Journal of Building Engineering. 2025, 104. 112271

[42] Zhao B, Wen J, Zhai D, Tang R, Chen S, Xin J. Effect of calcium chloride on the properties of gangue cemented paste backfill: Experimental results of setting time, rheological properties, mechanical strength and microscopic properties. Case Studies in Construction Materials. 2025, 22. e04331

[43] Chen Y, Wang KJ, Wang XH, Zhou WF. Strength, fracture and fatigue of pervious concrete. Construction and Building Materials. 2013, 42: 97-104.

[44] Yu L, Xia J, Xia Z, Chen M, Wang J, Zhang Y. Study on the mechanical behavior and micro-mechanism of concrete with coal gangue fine and coarse aggregate. Construction and Building Materials. 2022, 338. 127626

[45] Zhang WQ, Dong CW, Huang P, Sun Q, Li M, Chai J. Experimental study on the characteristics of activated coal gangue and coal gangue-based geopolymer. Energies. 2020, 1310. 2504

[46] Wu CL, Jiang W, Zhang C, Li JW, Wu S, Wang XJ, Xu YM, Wang WL, Feng MJ. Preparation of solid-waste-based pervious concrete for pavement: A two-stage utilization approach of coal gangue. Construction and Building Materials. 2022, 319. 125962

[47] Qin ZH, Yuan Y, Chen ZS, Li Y, Xia YQ. Combined preparation and application of geopolymer pavement materials from coal slurry-slag powder-fly ash mining solid waste: A case study. Construction and Building Materials. 2024, 441. 137510

[48] Sata V, Wongsa A, Chindaprasirt P. Properties of pervious geopolymer concrete using recycled aggregates. Construction and Building Materials. 2013, 42: 33-39.

[49] Huang W, Wang H. Geopolymer pervious concrete modified with granulated blast furnace slag: Microscale characterization and mechanical strength. Journal of Cleaner Production. 2021, 328. 129469

[50] Zhao R, Yuan Y, Cheng Z, Wen T, Li J, Li F, Ma Z. Freeze-thaw resistance of class F fly ash-based geopolymer concrete. Construction and Building Materials. 2019, 222: 474-483.

[51] Zhu Y, Fu H, Wang P, Xu P, Ling Z, Wei D. Pore structure characteristics, mechanical properties, and freeze-thaw resistance of vegetation-pervious concrete with unsintered sludge pellets. Construction and Building Materials. 2023, 382. 131342

[52] Shen D, Yu Y, Jin Z, Li N. Effects of crumb rubber particles on the evolution of pore structure in steam-cured concrete under freeze-thaw cycles. Journal of Building Engineering. 2025, 103. 112138

[53] Shan JS, Zhang Y, Wu SY, Lin ZS, Li L, Wu QL. Pore characteristics of pervious concrete and their influence on permeability attributes. Construction and Building Materials. 2022, 327. 126874

[54] Wang J, Zhao C, Li Q, Song G, Hu Y. The synergistic effect of recycled steel fibers and rubber aggregates from waste tires on the basic properties, drying shrinkage, and pore structures of cement concrete. Construction and Building Materials. 2025, 470. 140574

[55] Xu F, Gu G, Zhang W, Wang H, Huang X, Zhu J. Pore structure analysis and properties evaluations of fly ash-based geopolymer foams by chemical foaming method. Ceramics International. 2018, 441619989-19997.

[56] Chen S, Ruan S, Zeng Q, Liu Y, Zhang M, Tian Y, Yam D. Pore structure of geopolymer materials and its correlations to engineering properties: A review. Construction and Building Materials. 2022, 328. 127064

[57] Negahban E, Bagheri A, Sanjayan J. Pore gradation effect on Portland cement and geopolymer concretes. Cement and Concrete Composites. 2021, 122. 104141

Funding

National Natural Science Foundation of China(52468068)

Natural Science Foundation of Ningxia Province(2024AAC02014)

RIGHTS & PERMISSIONS

The Author(s)