An approach for IC engine coolant energy recovery based on low-temperature organic Rankine cycle

Abstract

To promote the fuel utilization efficiency of IC engine, an approach was proposed for IC engine coolant energy recovery based on low-temperature organic Rankine cycle (ORC). The ORC system uses IC engine coolant as heat source, and it is coupled to the IC engine cooling system. After various kinds of organic working media were compared, R124 was selected as the ORC working medium. According to IC engine operating conditions and coolant energy characteristics, the major parameters of ORC system were preliminary designed. Then, the effects of various parameters on cycle performance and recovery potential of coolant energy were analyzed via cycle process calculation. The results indicate that cycle efficiency is mainly influenced by the working pressure of ORC, while the maximum working pressure is limited by IC engine coolant temperature. At the same working pressure, cycle efficiency is hardly affected by both the mass flow rate and temperature of working medium. When the bottom cycle working pressure arrives at the maximum allowable value of 1.6 MPa, the fuel utilization efficiency of IC engine could be improved by 12.1%. All these demonstrate that this low-temperature ORC is a useful energy-saving technology for IC engine.

Keywords

IC engine / waste heat recovery / organic Rankine cycle / cycle efficiency / coolant energy

References

[1] FengR-h, YangJ, ZhangD-m, DengB-l, FuJ-q, LiuJ-p, LiuX-qiang. Experimental study on SI engine fuelled with butanol-gasoline blend and H₂O addition [J]. Energy Conversion and Management, 2013, 74(10): 192-200

[2] LiuJ-p, FuJ-q, RenC-q, ZhuG-h, DengB-l, KeshavV. Experimental comparison of heat and exergy balance in a turbocharged direct-injected gasoline engine [J]. Transactions of CSICE, 2013, 31(1): 65-71

[3] FuJ-q, LiuJ-p, FengR-h, YangY-p, WangL-j, WangYong. Energy and exergy analysis on gasoline engine based on mapping characteristics experiment [J]. Applied Energy, 2013, 102(2): 622-630

[4] SrinivasanK K, MagoP J, KrishnanS R. Analysis of exhaust waste heat recovery from a dual fuel low temperature combustion engine using an organic Rankine cycle [J]. Energy, 2010, 35(6): 2387-2399

[5] FuJ-q, LiuJ-p, RenC-q, WangL-j, DengB-l, XuZ-xin. An open steam power cycle used for IC engine exhaust gas energy recovery [J]. Energy, 2012, 44(1): 544-554

[6] LiuJ-p, FuJ-q, RenC-q, WangL-j, XuZ-x, DengB-lin. Comparison and analysis of engine exhaust gas energy recovery potential through various bottom cycles [J]. Applied Thermal Engineering, 2013, 50(1): 1219-1234

[7] ConklinJ C, SzybistJ P. A highly efficient six-stroke internal combustion engine cycle with water injection for in-cylinder exhaust heat recovery [J]. Energy, 2010, 35(4): 1658-1664

[8] WangT-y, ZhangY-j, PengZ-j, ShuG-qun. A review of researches on thermal exhaust heat recovery with Rankine cycle [J]. Renewable and Sustainable Energy Reviews, 2011, 15(6): 2862-2871

[9] SrinivasanK K, MagoP J, KrishnanS R. Analysis of exhaust waste heat recovery from a dual fuel low temperature combustion engine using an organic Rankine cycle [J]. Energy, 2010, 35(6): 2387-2399

[10] RoyJ P, MishraM K, MisraA. Parametric optimization and performance analysis of a waste heat recovery system using organic Rankine cycle [J]. Energy, 2010, 35(12): 5049-5062

[11] BorettiA. Stoichiometric H₂ICE with water injection and exhaust and coolant heat recovery through organic Rankine cycles [J]. International Journal of Hydrogen Energy, 2011, 36(19): 12591-12600

[12] BorettiA. Recovery of exhaust and coolant heat with R245fa organic Rankine cycles in a hybrid passenger car with a naturally aspirated gasoline engine [J]. Applied Thermal Engineering, 2012, 36(4): 73-77

[13] DrescherU, BruggemannD. Fluid selection for the organic Rankine cycle (ORC) in biomass power and heat plants [J]. Applied Thermal Engineering, 2007, 27(1): 223-228

[14] LiuB-t, ChienK-h, WangC-chuan. Effect of working fluids on organic Rankine cycle for waste heat recovery [J]. Energy, 2004, 29(8): 1207-1217

[15] HungT C. Waste heat recovery of organic Rankine cycle using dry fluids [J]. Energy Conversion and Management, 2001, 42(5): 539-553

[16] KosmadakisG, ManolakosD, KyritsisS, PapadakisG. Comparative thermodynamic study of refrigerants to select the best for use in the high-temperature stage of a two-stage organic Rankine cycle for RO desalination [J]. Desalination, 2009, 243(1/2/3): 74-94

[17] LiuJ, ChenJ-p, QiZ-gang. Thermodynamic analysis of low temperature organic Rankine cycle [J]. CIESC Journal, 2010, 61(S2): 9-14

[18] LiuJ-p, FuJ-q, FengR-h, ZhuG-hui. Effects of working parameters on gasoline engine exergy balance [J]. Journal of Central South University, 2013, 20(7): 1938-1946