Sustainable off-grid gasification: co-production of electricity, heat, and activated carbon

Abstract

The process of gasification is well-known; however, to this day, the applications of such facilities, especially off-grid small-scale units for direct electricity and char production, are scarce. In this study, an off-grid fixed bed downdraft gasification unit is studied from the gaseous/solid product character perspective. This unit represents a possible solution for the emerging call for sustainable decentralised energy sources. Softwood chips were utilised in this study, and their conversion into synthetic gas (direct electricity supply) and solid biochar was observed and analysed. The results show promising values of synthetic gas for potential utilisation in different applications outside the direct combustion process, such as microbial syngas fermentation, with a lower heating value equal to 6.31 MJ·m^-3. It appears that during the steam activation process of biochar, both high-quality off-gas of more than 70%_vol. H₂ (excluding N₂) and activated carbon of a specific surface area of 565.87 m²·g^-1 can be collected. Further investigations have revealed specific degradation of chemical bonds and material morphology changes during steam gasification. The microporous structure and high specific surface area of the material make it an attractive material for further development as an adsorbent in sorption cooling devices. Therefore, the waste generated within the gasification process is minimised, and the potential of the obtained products will be valued in favour of the sustainability of the remote locations.

Keywords

Waste management / sustainability / gasification / biochar / circular economy / off-grid

References

[1] Eurostat. EU’s circular material use rate increased in 2020; 2021. Available from: https://ec.europa.eu/eurostat/web/products-eurostat-news/-/ddn-20211125-1 [Last accessed on 15 Nov 2024]

[2] Horák J,Hopan F.Influence of co-combustion of unsuitable fuels with standardized fuels in households on CO, OGC, PM, and PAH emissions.Environ Sci Pollut Res Int2022;29:44297-307

[3] Ryšavý J,Kuboňová L. Beech leaves briquettes as fuel for a home combustion unit. 2020; pp. 75-85. Available from: https://www.researchgate.net/profile/Jiri-Rysavy/publication/343427834_BEECH_LEAVES_BRIQUETTES_AS_FUEL_FOR_A_HOME_COMBUSTION_UNIT/links/5f7344b5a6fdcc00864672d1/BEECH-LEAVES-BRIQUETTES-AS-FUEL-FOR-A-HOME-COMBUSTION-UNIT.pdf?origin=scientificContributions [Last accessed on 15 Nov 2024]

[4] Pedrazzi S,Mustone M.Techno-economic study of a small scale gasifier applied to an indoor hemp farm: from energy savings to biochar effects on productivity.Energy Convers Manag2021;228:113645

[5] Prakash M,Sarkar J,Mondal SS.Performance assessment of novel biomass gasification based CCHP systems integrated with syngas production.Energy2019;167:379-90

[6] Prakash M,Sarkar J,Chakraborty JP.Proposal and design of a new biomass based syngas production system integrated with combined heat and power generation.Energy2017;133:986-97

[7] Pedrazzi S,Minarelli A.Energy and biochar co-production from municipal green waste gasification: A model applied to a landfill in the north of Italy.Energy Convers Manag2019;187:274-82

[8] Morselli N,Tartarini P.Gasification as possible technological solution for driftwood management in bodies of waters.IOP Conf Ser Earth Environ Sci2022;1106:012014

[9] Merzic A,Ikanovic N,Kazagic A.Towards just transition of coal regions - cultivation of short rotation copies and dedicated energy crops for biomass co-firing vs photo voltaic power plants.Energy Convers Manag X2022;15:100267

[10] Čespiva J,Výtisk J,Tadeáš O.Softwood and solid recovered fuel gasification residual chars as sorbents for flue gas mercury capture.Environ Technol Innov2023;29:102970

[11] Čespiva J,Wnukowski M.Torrefaction and gasification of biomass for polygeneration: production of biochar and producer gas at low load conditions.Energy Rep2022;8:134-44

[12] Ryšavý J,Kuboňová L.Co-gasification of pistachio shells with wood pellets in a semi-industrial hybrid cross/updraft reactor for producer gas and biochar production.Fire2024;7:87

[13] Fajimi LI,Adams TA.Simulation studies on the co-production of syngas and activated carbon from waste tyre gasification using different reactor configurations.Energy Convers Manag X2021;11:100105

[14] Wystalska K,Barczak M.Poultry manure derived biochars - the impact of pyrolysis temperature on selected properties and potentials for further modifications.J Sustain Dev Energy Water Environ Syst2021;9:1080337

[15] Castiglioni M,Ingrando I.Biochars intended for water filtration: a comparative study with activated carbons of their physicochemical properties and removal efficiency towards neutral and anionic organic pollutants.Chemosphere2022;288:132538

[16] Sieradzka M,Kalemba-Rec I.Evaluation of physical and chemical properties of residue from gasification of biomass wastes.Energies2022;15:3539

[17] Mlonka-Mędrala A,Kalawa W.Possibilities of using zeolites synthesized from fly ash in adsorption chillers.Energies2022;15:7444

[18] Hansen V,Ahrenfeldt J,Henriksen UB.Gasification biochar as a valuable by-product for carbon sequestration and soil amendment.Biomass Bioenergy2015;72:300-8

[19] Santunionea G,Paris R,Montanari M. Production and use of co-composted biochar as soil amendment for cannabis sativa sp. growth. 2020. pp. 113-7. Available from: https://iris.unimore.it/handle/11380/1239367 [Last accessed on 15 Nov 2024]

[20] Phuphuakrat T,Yoshikawa K.Tar removal from biomass pyrolysis gas in two-step function of decomposition and adsorption.Appl Energy2010;87:2203-11

[21] Shen Y.Chars as carbonaceous adsorbents/catalysts for tar elimination during biomass pyrolysis or gasification.Renew Sustain Energy Rev2015;43:281-95

[22] Sur A.Experimental investigation on waste heat driven activated carbon-methanol adsorption cooling system.J Braz Soc Mech Sci Eng2017;39:2735-46

[23] Tchoffor PA,Thunman H.Production of activated carbon within the dual fluidized bed gasification process.Ind Eng Chem Res2015;54:3761-6

[24] Gañán J,Calama G,Al-Kassir A.Plant for the production of activated carbon and electric power from the gases originated in gasification processes.Fuel Process Technol2006;87:117-22

[25] Puglia M,Pedrazzi S,Allesina G.Specific and cumulative exhaust gas emissions in micro-scale generators fueled by syngas from biomass gasification.Sustainability2021;13:3312

[26] Mlonka-Mędrala A,Magdziarz A.Thermal upgrading of hydrochar from anaerobic digestion of municipal solid waste organic fraction.Fuel2022;324:124435

[27] Vonk G,Felipe Dos Santos P,Vaïtilingom G.Comparative analysis of wood and solid recovered fuels gasification in a downdraft fixed bed reactor.Waste Manag2019;85:106-20

[28] Susastriawan AA.Effect of air supply location and equivalence ratio on thermal performance of downdraft gasifier fed by wood sawdust.J Sustain Dev Energy Water Environ Syst2023;11:1100435

[29] Čespiva J,Vereš J.Evaluation of the performance of the cross/updraft type gasification technology with the sliding bed over a circular grate.Biomass Bioenergy2022;167:106639

[30] Kupka D.Design and experimental investigation of a micro-scale bladeless-type steam turbine.Appl Therm Eng2024;239:122119

[31] Rückel A,Leuter P,Fendt S.Conversion of syngas from entrained flow gasification of biogenic residues with Clostridium carboxidivorans and Clostridium autoethanogenum.Fermentation2022;8:465

[32] Pacheco M,Ortigueira J,Gírio F.Lignin syngas bioconversion by Butyribacterium methylotrophicum: advancing towards an integrated biorefinery.Energies2021;14:7124

[33] Piatek P,Nygård Y.Adaptation during propagation improves Clostridium autoethanogenum tolerance towards benzene, toluene and xylenes during gas fermentation.Bioresour Technol Rep2020;12:100564

[34] Rückel A,Maierhofer C,Weuster-Botz D.Studies on syngas fermentation with Clostridium carboxidivorans in stirred-tank reactors with defined gas impurities.Front Microbiol2021;12:655390 PMCID:PMC8081853

[35] Rahman MM,Ahrenfeldt J.Design, construction and operation of a low-tar biomass (LTB) gasifier for power applications.Energy2020;204:117944

[36] Liakakou ET,Cerone N.Gasification of lignin-rich residues for the production of biofuels via syngas fermentation: comparison of gasification technologies.Fuel2019;251:580-92

[37] Čespiva J,Niedzwiecki L.Characterization of tars from a novel, pilot scale, biomass gasifier working under low equivalence ratio regime.Renew Energy2020;159:775-85

[38] Marchelli F,Patuzzi F.Experimental study on H₂S adsorption on gasification char under different operative conditions.Biomass Bioenergy2019;126:106-16

[39] Kilpimaa S,Kangas T,Kuokkanen T.Physical activation of carbon residue from biomass gasification: novel sorbent for the removal of phosphates and nitrates from aqueous solution.J Ind Eng Chem2015;21:1354-64

[40] Výtisk J,Jadlovec M,Honus S.Life cycle assessment applied on alternative production of carbon-based sorbents - a comparative study.Sustain Mater Technol2023;35:e00563

[41] Kumdhitiahutsawakul L,Kantha U.Removal of hydrogen sulfide from swine-waste biogas on a pilot scale using immobilized Paracoccus versutus CM1.Microorganisms2022;10:2148 PMCID:PMC9693040

[42] Wang H,Runge T.Impacts to hydrogen sulfide concentrations in biogas when poplar wood chips, steam treated wood chips, and biochar are added to manure-based anaerobic digestion systems.Bioresour Technol Rep2019;7:100232

[43] Silverstein RM.Spectrometric identification of organic compounds.J Chem Educ1962;39:546

[44] Korus A,Loska K,Samson A.The importance of inherent inorganics and the surface area of wood char for its gasification reactivity and catalytic activity towards toluene conversion.Renew Energy2021;173:479-97

[45] Zhou C,Xing X.Pilot-scale pyrolysis and activation of typical biomass chips in an interconnected dual fluidized bed: comparison and analysis of products.Renew Energy2024;225:120339

[46] Tan J,Tang L,Liu H.Study on the pyrolysis characteristics and char gasification kinetics of pre-separated automobile shredder residues.J Environ Chem Eng2024;12:112520

[47] Zeghioud H,Djelal H,Kane A.A comprehensive review of biochar in removal of organic pollutants from wastewater: characterization, toxicity, activation/functionalization and influencing treatment factors.J Water Process Eng2022;47:102801

[48] Wu L,Li C.Free-radical behaviors of co-pyrolysis of low-rank coal and different solid hydrogen-rich donors: a critical review.Chem Eng J2023;474:145900

[49] Jiang X,Hu B,Li K.Formation mechanism of CH₄ during lignin pyrolysis: a theoretical study.J Energy Inst2022;100:237-44

[50] Hwang SY,Kim H.Influence of mixed methods on the surface area and gas products of activated carbon.Carbon Lett2020;30:603-11

[51] Zhou Q,Leung CW,Huang Z.Explosion characteristics of bio-syngas at various fuel compositions and dilutions in a confined vessel.Fuel2020;259:116254

[52] Skřínský J,Čespiva J,Borovec K.Charakterystyka eksplozji gazu syntezowego z procesu zgazowania.Inżynieria Mineralna2020;2:195-200

[53] Shivapuji AM.Influence of fuel hydrogen fraction on syngas fueled SI engine: fuel thermo-physical property analysis and in-cylinder experimental investigations.Int J Hydrogen Energy2015;40:10308-28

[54] Solferini de Carvalho F,Malheiro de Oliveira E.Experimental investigation of hydrogen-producer gas mixtures in an optically accessible SI engine.Int J Hydrogen Energy2024;58:500-13

[55] Lin X,Wang C.The effects of pore structures and functional groups on the catalytic performance of activated carbon catalysts for the co-pyrolysis of biomass and plastic into aromatics and hydrogen-rich syngas.Renew Energy2023;202:855-64

[56] Villardon A,Dorado F.Enhancing carbon dioxide uptake in biochar derived from husk biomasses: optimizing biomass particle size and steam activation conditions.J Environ Chem Eng2024;12:113352

[57] Zango ZU,Haruna A.A systematic review on applications of biochar and activated carbon derived from biomass as adsorbents for sustainable remediation of antibiotics from pharmaceutical wastewater.J Water Process Eng2024;67:106186

[58] Bélanger N,Francis M.Assessment and enhancement of starch-based biochar as a sustainable filler in styrene-butadiene rubber composites via steam and CO₂ activation treatments.Biomass Bioenergy2024;184:107174

[59] Mlonka-Mędrala A,Buk P,Nowak W.The influence of KCl on biomass ash melting behaviour and high-temperature corrosion of low-alloy steel.Energy2019;188:116062

[60] Scala F.Particle agglomeration during fluidized bed combustion: Mechanisms, early detection and possible countermeasures.Fuel Process Technol2018;171:31-8

[61] Damø AJ,Pedersen MN.Full-scale investigations of initial deposits formation in a cement plant co-fired with coal and SRF.Fuel2023;344:128058

[62] Mlonka-Mędrala A,Gajek M,Nowak W.Alkali metals association in biomass and their impact on ash melting behaviour.Fuel2020;261:116421

[63] Sieradzka M,Magdziarz A.Comprehensive investigation of the CO₂ gasification process of biomass wastes using TG-MS and lab-scale experimental research.Fuel2022;330:125566

[64] Attalla M,Salem Ahmed M,Hassan M.Experimental study of solar powered ice maker using adsorption pair of activated carbon and methanol.Appl Therm Eng2018;141:877-86

[65] Taghipour H,Aslani H,Dehghanzadeh R.Characterizing and quantifying solid waste of rural communities.J Mater Cycles Waste Manag2016;18:790-7

[66] Tuck CO,Horváth IT,Poliakoff M.Valorization of biomass: deriving more value from waste.Science2012;337:695-9