Migration and release characteristics of gases in excavation of a tunnel within magmatic rocks reservoir

Abstract

The emission of hazardous gases from surrounding rocks is one of the major factors threatening the safety of deep underground engineering construction. In particular, for non-coal-bearing strata, increasing attention has been paid to identifying the types of hazardous gas reservoirs and predicting the gas release patterns from the surrounding rock. This study reveals the generation and occurrence mechanisms of hazardous gases within magmatic rock strata in the Qinghai–Tibet Plateau. Based on the characteristics of the gas reservoirs, a model test was conducted to analyze the deformation of the surrounding rock and the gas migration behavior during tunnel excavation. To represent the characteristics of low-porosity magmatic rock fracture reservoirs, a gas migration–release evolution model was developed based on the ideal gas law. The evolution of gas migration and release in the surrounding rock throughout the tunnel excavation process was investigated. Furthermore, the influence of borehole layout on the tunnel face on the gas release efficiency was examined. The results show that the long-term gas release process can be divided into three stages: stable release stage, gas replenishment stage, and residual gas release stage. Before the tunnel intersects the reservoir, the gas escape is primarily driven by pore seepage. After the tunnel enters the reservoir, the fracture gas velocity increases rapidly and then decreases gradually, with the escaping gas predominantly originating from the reservoir fractures. In addition, the installation of exhaust boreholes results in an ‘‘S-shaped” increase in the gas flow volume at the tunnel face as the borehole area increases. The gas release efficiency is maximized when the ratio of the fracture trace length to the exhaust borehole area (l/a) ranges between 0.064 and 0.096. These findings provide deeper insights into the gas migration and release characteristics of tunnel surrounding rocks in magmatic rock strata.

Keywords

Hazardous gases / Tunnel excavation / Magmatic rock / Gas migration characteristics / Exhaust borehole

References

[1] Ahmadi, M. H., & Hekmat, M. H. (2021). Numerical and experimental investigation of air flow behavior and H₂S gas release through an inclined traversed tunnel . Journal of the Brazilian Society of Mechanical Sciences and Engineering, 43(10).

[2] Cassiaux, M., Proust, D., Siitari-Kauppi, M., Sardini, P., & Leutsch, Y. (2006). Clay minerals formed during propylitic alteration of a granite and their influence on primary porosity: A multi-scale approach. Clay and Clay Minerals, 54(5), 541-554.

[3] Chen, C. H., Luo, J., Cao, J., Liang, J., Li, X. C., Cao, T. K., Xu, Y. H., Cai, L. F., Yu, P., & Zhu, T. Y. (2025). A novel method for calculating the dynamic reserves of tight gas wells considering stress sensitivity is under consideration. Earth Energy Science, 1(1), 1-8.

[4] Chen, Y. F., Zeng, J., Shi, H. T., Wang, Y. F., Hu, R., Yang, Z. B., & Zhou, C. B. (2021). Variation in hydraulic conductivity of fractured rocks at a dam foundation during operation. Journal of Rock Mechanics and Geotechnical Engineering, 13(2), 351-367.

[5] Chen, Z. Y., Su, P. D., Huang, L., Chen, H. D., & Du, Y. B. (2020). Study on monitoring and prevention technique for harmful gas in no.1 inclined shaft of Hongdoushan Tunnel. Modern Tunneling Technology, 57(4), 178-184 (in Chinese).

[6] Cheng, L., Ge, Z. L., Chen, J. F., Ding, H., Zou, L. S., & Li, K. (2018). A sequential approach for integrated coal and gas mining of closely-spaced outburst coal seams: Results from a case study including mine safety improvements and greenhouse gas reductions. Energies, 11(11).

[7] Cui, J. P., Tao, H., Ren, Z. L., Jin, W., Liu, H., Meng, Z. Y., & Cheng, K. Z. (2022). Genesis and accumulation period of CO₂ gas reservoir in Hailar Basin . Energies, 15(17).

[8] Czarny, R., Malinowski, M., Chamarczuk, M., Cwiekala, M., Olechowski, S., Isakow, Z., & Sierodzki, P. (2021). Dispersive seismic waves in a coal seam around the roadway in the presence of excavation damaged zone. International Journal of Rock Mechanics and Mining Sciences, 148.

[9] Fang, L., Zhou, X. H., Liu, X. R., Zhang, J. L., Wang, Y., & Suliman, L. (2025). Mechanical behaviors and permeability characteristics of granite considering through-crack inclination and seepage gas pressure. Theoretical and Applied Fracture Mechanics (pp. 136).

[10] Fang, Y., Yao, Z. G., & Lei, S. (2019). Air flow and gas dispersion in the forced ventilation of a road tunnel during construction. Underground Space, 4(2), 168-179.

[11] Feng, Y., Seol, H., Lee, J. K., & Eun, J. (2023). Numerical analysis of gas-bearing ground deformation and failure mode around the parallel tunnel cross-passage. In Geo-Congress on Sustainable Infrastructure Solutions from the Ground Up (541-550). Los Angeles, CA.

[12] Gao, H., Qing, L. B., Ma, G. W., & Zhang, D. C. (2023). Numerical investigation on grout spread and grouting parameter analysis in fracture with flowing water. Journal of Petroleum Science and Engineering, 221.

[13] Goff, F., & Janik, C. J. (2002). Gas geochemistry of the Valles caldera region, New Mexico and comparisons with gases at Yellowstone, Long Valley and other geothermal systems. Journal of Volcanology and Geothermal Research, 116(3-4), 299-323.

[14] Guo, B. H., Li, Y. Z., Jiao, F., Luo, T., & Ma, Q. (2018). Experimental study on coal and gas outburst and the variation characteristics of gas pressure. Geomechanics, Geophysics, Geosystems, 4(4), 355-368.

[15] He, J., Wei, X. Y., & Yin, M. (2023). Study on the long-term performance of shield tunnel passing through the gas-bearing strata. Underground Space, 9, 1-19.

[16] Huo, Z. G., Xue, W. T., & Shu, L. Y. (2021). Exploration on outburst mechanism of rock and carbon dioxide in coal mines of China. Coal Science and Technology, 49(1), 155-161 (in Chinese).

[17] Ishibashi, T., Asanuma, H., Mukuhira, Y., & Watanabe, N. (2023). Laboratory hydraulic shearing of granitic fractures with surface roughness under stress states of EGS: Permeability changes and energy balance. International Journal of Rock Mechanics and Mining Sciences, 170.

[18] Kang, X. B., Xu, M., Luo, S., & Xia, Q. (2013). Study on formation mechanism of gas tunnel in non-coal strata. Natural Hazards, 66(2), 291-301.

[19] Kong, Y., Zhu, Z. D., & Ruan, H. N. (2018). Stress-seepage coupling characteristics of jointed rock mass under three principal stresses. Rock and Soil Mechanics, 39(6), 2008-2016 (in Chinese).

[20] Lei, Q. H., Doonechaly, N. G., & Tsang, C. F. (2021). Modelling fluid injection-induced fracture activation, damage growth, seismicity occurrence and connectivity change in naturally fractured rocks. International Journal of Rock Mechanics and Mining Sciences, 138.

[21] Li, M., & Liu, X. S. (2021). Experimental and numerical investigation of the failure mechanism and permeability evolution of sandstone based on hydro-mechanical coupling. Journal of Natural Gas Science and Engineering, 95.

[22] Liu, L., Gao, Y. Q., Qu, X. Y., Meng, Q. A., Gao, F. H., Ren, Y. G., & Zhu, D. F. (2006). Petrology and carbon-oxygen isotope of inorganic CO2 gas reservoir in Wuerxun Depression, Hailaer Basin. Acta Petrologica Sinica, 22(8), 2229-2236.

[23] Liu, X. R., Zhang, J. L., Zhou, X. H., Liu, Y. Y., Wang, Y., & Luo, X. Y. (2024). Damage-seepage evolution mechanism of fractured rock masses considering the influence of lateral stress on fracture deformation under loading and unloading process. Rock Mechanics and Rock Engineering, 57(12), 10973-10999.

[24] Lu, Y. Y., Zhao, G. L., Ge, Z. L., Jia, Y. Z., Tang, J. R., Gong, T. Y., Huang, S., Li, Z. T., Fu, W. Y., & Mi, J. Y. (2025). Challenges and development direction of deep fragmented soft coalbed methane in China. Earth Energy Science, 1(1), 38-64.

[25] Luo, Y., Gong, H. L., Qu, D. X., Li, X. P., Hu, S. H., Zhu, Y. W., & Pu, Q. S. (2022). Research on the escape mechanism and influencing factors of harmful gas induced by blasting excavation in deep rock tunnel. Environmental Earth Sciences, 81(18).

[26] Qiu, P., Su, P. D., Li, Y. G., Lu, X. H., Chen, W. Y., Ahmed, M. S., Gentzis, T., & Mansour, A. (2025). Formation processes, accumulation patterns and risk mitigation strategies for harmful gases in tunnels within the complex geological structure area of Southwest China. Bulletin of Engineering Geology and the Environment, 84(6).

[27] Shahin, H. M., Nakai, T., Ishii, K., Iwata, T., & Kuroi, S. (2016). Investigation of influence of tunneling on existing building and tunnel: Model tests and numerical simulations. Acta Geotechnica, 11(3), 679-692.

[28] Stefánsson, A. (2017). Gas chemistry of Icelandic thermal fluids. Journal of Volcanology and Geothermal Research, 346, 81-94.

[29] Sun, Q. H., Liu, X., Bao, Y. H., De Corte, W., & Taerwe, L. (2025). Experimental study on the leakage-induced structural collapse of segmental tunnels. Underground Space, 24, 22-43.

[30] Sun, S. B., Yan, S. H., Cao, X. P., & Zhang, W. (2023). Distribution law of the initial temperature field in a railway tunnel with high rock temperature: A model test and numerical analysis. Applied Sciences-Basel, 13(3).

[31] Surma, F., & Geraud, Y. (2003). Porosity and thermal conductivity of the Soultz-sous-Forets granite. Pure and Applied Geophysics, 160(5-6), 1125-1136.

[32] Tang, Z. Q., Gao, K., Tao, C. F., Liu, Y. J., & Qi, Z. P. (2024). The influence of tunnel aspect ratio on the gas temperature distribution in advancing tunnel. Tunnelling and Underground Space Technology, 149, 105818.

[33] Torno, S., & Toraño, J. (2023). Methane emission outbursts in the mine face of two galleries: Computational fluid dynamics analysis and on-site calibration. Energies, 16(21).

[34] Tu, S. Q., Li, W., Zhang, C. P., Wang, L. B., Jin, Z. X., & Wang, S. X. (2024). Seepage effect on progressive failure of shield tunnel face in granular soils by coupled continuum-discrete method. Computers and Geotechnics, 166.

[35] Wang, C. Y., Zhang, D. M., Tan, D. J., Ye, J. H., Wang, X. L., Wang, C. Y., & Li, Q. L. (2024). Study on the evolution of limestone damage and permeability under the tunnel driving stress path. Construction and Building Materials, 425.

[36] Watanabe, Y., Yokoyama, S., Shimbashi, M., Yamamoto, Y., & Goto, T. (2023). Saturated hydraulic conductivity of compacted bentonite-sand mixtures before and after gas migration in artificial seawater. Journal of Rock Mechanics and Geotechnical Engineering, 15(1), 216-226.

[37] Xu, G. A., Jing, H. W., & Qiu, Y. (2019). Development and application of a test system for modeling tunnel excavation with transparent rock surrogate. Geotechnical Testing Journal, 42(3), 638-655.

[38] Yuan, C. L., Xian, X. H., & Chai, X. Q. (2022). Study on comprehensive disaster control mode of coal and gas (CO2) outburst and steep coal steam. China Coal, 48(S2), 180-186 (in Chinese).

[39] Zhang, F. S., He, G. P., An, M. K., Huang, R., & Elsworth, D. (2025). Permeability evolution of fluid-injection-reactivated granite fractures of contrasting roughnesses. Underground Space, 20, 33-45.

[40] Zhang, H. Y., Chen, L., Liu, J., Wang, C. P., Ma, L. K., & Wang, W. (2023). Effect of stress induced damage on gas permeability of Beishan granite. European Journal of Environmental and Civil Engineering, 27(8), 2717-2730.

[41] Zhao, C. X., Lei, Q. H., & Zhang, Z. X. (2025). Impact of fracture networks on the structural deformation of lined rock caverns under high internal gas pressure. Underground Space, 21, 252-269.

[42] Zhou, Y. F., Li, C. F., & Song, G. M. (2016). Discussion on control measures for H2S in Yuelongmen Tunnel on Chengdu-Lanzhou Railway. Tunnelling and Construction, 36(10), 1251-1257 (in Chinese).

[43] Zhu, C. F., & Cai, S. (2020). Study on borehole arrangement methods for gas extraction by hydraulic slotting in long-distance through-coal seam tunnel. Geofluids, 2020.

[44] Zhu, G. Y., Zhang, S. C., & Liang, Y. B. (2007). The controlling factors and distribution prediction of H₂S formation in marine carbonate gas reservoir, China . Chinese Science Bulletin, 52, 150-163.