Failure mechanisms and destruction characteristics of cemented coal gangue backfill under compression effect of non-uniform load

Abstract

Backfill mining is one of the most important technical means for controlling strata movement and reducing surface subsidence and environmental damage during exploitation of underground coal resources. Ensuring the stability of the backfill bodies is the primary prerequisite for maintaining the safety of the backfilling working face, and the loading characteristics of backfill are closely related to the deformation and subsidence of the roof. Elastic thin plate model was used to explore the non-uniform subsidence law of the roof, and then the non-uniform distribution characteristics of backfill bodies’ load were revealed. Through a self-developed non-uniform loading device combined with acoustic emission (AE) and digital image correlation (DIC) monitoring technology, the synergistic dynamic evolution law of the bearing capacity, apparent crack, and internal fracture of cemented coal gangue backfills (CCGBs) under loads with different degrees of non-uniformity was deeply explored. The results showed that: 1) The uniaxial compressive strength (UCS) of CCGB increased and then decreased with an increase in the degree of non-uniformity of load (DNL). About 40% of DNL was the inflection point of DNL-UCS curve and when DNL exceeded 40%, the strength decreased in a cliff-like manner; 2) A positive correlation was observed between the AE ringing count and UCS during the loading process of the specimen, which was manifested by a higher AE ringing count of the high-strength specimen. 3) Shear cracks gradually increased and failure mode of specimens gradually changed from “X” type dominated by tension cracks to inverted “Y” type dominated by shear cracks with an increase in DNL, and the crack opening displacement at the peak stress decreased and then increased. The crack opening displacement at 40% of the DNL was the smallest. This was consistent with the judgment of crack size based on the AE b-value, i.e., it showed the typical characteristics of “small b-value-large crack and large b-value-small crack”. The research results are of significance for preventing the instability and failure of backfill.

References

[1] BaiE-H, GuoW-B, TanY, et al. . Green coal mining and water clean utilization under Neogene aquifer in Zhaojiazhai coalmine of central China [J]. Journal of Cleaner Production, 2022, 368: 133134

[2] QiR, LiS, QuL, et al. . Critical factors to green mining construction in China: A two-step fuzzy DEMATEL analysis of state-owned coal mining enterprises [J]. Journal of Cleaner Production, 2020, 273: 122852

[3] ZamanA U. A comprehensive review of the development of zero waste management: Lessons learned and guidelines [J]. Journal of Cleaner Production, 2015, 91: 12-25

[4] YaoY, CuiZ-D, WuR-Z. Development and challenges on mining backfill technology [J]. Journal of Materials Science Research, 2012, 1(4): 73

[5] RoyR, ChakrabortyS, BisaiR, et al. . Gravity blind backfilling of abandoned underground mine voids using suitable mix proportion of fill materials and method of filling [J]. Geotechnical and Geological Engineering, 2023, 41(3): 1801-1819

[6] ShirinS, JamalA, EmmanouilC, et al. . Assessment and characterization of waste material used as backfilling in an abandoned mine [J]. International Journal of Coal Preparation and Utilization, 2023, 43(8): 1402-1410

[7] QianM-G. On sustainable coal mining in China [J]. Journal of China Coal Society, 2010, 35(4): 529-534(in Chinese)

[8] QiR, LiuT-Y, JiaQ-X, et al. . Simulating the sustainable effect of green mining construction policies on coal mining industry of China [J]. Journal of Cleaner Production, 2019, 226: 392-406

[9] LiuJ-G, LiX-W, HeT. Application status and prospect of backfill mining in Chinese coal mines [J]. Journal of China Coal Society, 2020, 45(1): 141-150(in Chinese)

[10] FengG-R, DuX-J, GuoY-X, et al. . Basic theory of constructional backfill mining and the underground space utilization concept [J]. Journal of China Coal Society, 2019, 44(1): 74-84(in Chinese)

[11] FengG-R, BaiJ-W, CaoG-M, et al. . Scientific connotation on the key location backfilling for carbon storage space reconstruction in the residual mining area [J]. Journal of China University of Mining & Technology, 2023, 52(3): 432-445(in Chinese)

[12] ZhangX-Y, XuM-Y, LiuL, et al. . Heat storage/heat release of phase-change filling body with casing heat exchanger for extracting geothermal energy [J]. Journal of Thermal Science, 2023, 32(3): 1171-1189

[13] XuJ-L, XuanD-Y, ZhuW-B, et al. . Study and application of coal mining with partial backfilling [J]. Journal of China Coal Society, 2015, 40(6): 1303-1312(in Chinese)

[14] XuanD-Y, XuJ-L. Longwall surface subsidence control by technology of isolated overburden grout injection [J]. International Journal of Mining Science and Technology, 2017, 27(5): 813-818

[15] XuanD-Y, XuJ-L. Grout injection into bed separation to control surface subsidence during longwall mining under villages: Case study of Liudian coal mine, China [J]. Nat Hazards, 2014, 73(2): 883-906

[16] XuanD-Y, XuJ-L, ZhuW-B. Dynamic disaster control under a massive igneous sill by grouting from surface boreholes [J]. International Journal of Rock Mechanics and Mining Sciences, 2014, 71: 176-187

[17] DaiH-Y, GuoJ-T, YanY-G, et al. . Principle and application of subsidence control technology of mining coordinately mixed with backfilling and keeping [J]. Journal of China Coal Society, 2014, 39(8): 1602-1610(in Chinese)

[18] ZhangX-G, LiuW-T, SunX-K, et al. . Research and practice on shortwall part filling technology using fly ash high-water material [J]. Journal of China Coal Society, 2016, 41(12): 3016-3023(in Chinese)

[19] ZhuM-B, LiuL, WangS-M, et al. . Short-and long-walls backfilling pillarless coal mining method [J]. Journal of Mining & Safety Engineering, 2022, 39(6): 1116-1124(in Chinese)

[20] CuiB-Q, FengG-R, BaiJ-W, et al. . Acoustic emission characteristics and damage evolution process of backfilling body-coal pillar-backfilling body composite structure [J]. Bulletin of Engineering Geology and the Environment, 2022, 81(8): 300

[21] LiZ, FanJ-Y, FengG-R, et al. . A new method for identifying coal pillar instability based on energy and stress correlation characteristics and its engineering application [J]. Minerals, 2023, 13(12): 1507

[22] ZhuW-B, XuJ-M, XuJ-L, et al. . Pier-column backfill mining technology for controlling surface subsidence [J]. International Journal of Rock Mechanics and Mining Sciences, 2017, 96: 58-65

[23] DuX-J, FengG-R, ZhangM, et al. . Influence of backfilling rate on the stability of the “backfilling body-immediate roof” cooperative bearing structure [J]. International Journal of Mining Science and Technology, 2022, 32(6): 1197-1206

[24] FengG-R, LiuW-H, DuX-J, et al. . Crack evolution characteristics of cemented-gangue-fly-ash backfill with different proportions of fly ash and cement [J]. Construction and Building Materials, 2023, 385: 131498

[25] ZhuX-J, ZhaF, GuoG-L, et al. . Subsidence control design method and application to backfill-strip mining technology [J]. Advances in Civil Engineering, 2021, 2021: 5177174

[26] DuX-J, FengG-R, QiT-Y, et al. . Failure characteristics of large unconfined cemented gangue backfill structure in partial backfill mining [J]. Construction and Building Materials, 2019, 194: 257-265

[27] ChenG, YeY-C, YaoN, et al. . Deformation failure and acoustic emission characteristics of continuous graded waste rock cemented backfill under uniaxial compression [J]. Environmental Science and Pollution Research, 2022, 29(53): 80109-80122

[28] LiY-L, BianY-N, LiuC-H. Damage and failure mechanism of basalt fiber-reinforced gangue-cemented backfill under uniaxial compression [J]. Construction and Building Materials, 2023, 400: 132872

[29] YangL-J, HouC, ZhuW-C, et al. . Monitoring the failure process of cemented paste backfill at different curing times by using a digital image correlation technique [J]. Construction and Building Materials, 2022, 346: 128487

[30] RanH-Y, ElchalakaniM, GuoY-X, et al. . Effects of width-height ratio and roof-floor strength on the mechanical characteristics of cemented gangue backfill pier-column [J]. Environmental Science and Pollution Research, 2023, 30(3): 6313-6344

[31] GuoY-X, ZhaoY-H, FengG-R, et al. . Study on damage size effect of cemented gangue backfill body under uniaxial compression [J]. Chinese Journal of Rock Mechanics and Engineering, 2021, 40(12): 2434-2444(in Chinese)

[32] FengG-R, XieW-S, GuoY-X, et al. . Effect of early load on mechanical properties and damage of cemented gangue backfill [J]. Chinese Journal of Rock Mechanics and Engineering, 2022, 41(4): 775-784(in Chinese)

[33] LiX-L, ZhouQ-L, WangJ-G, et al. . Study on energy dissipation characteristics and damage law of backfill under cyclic impact [J]. Shock and Vibration, 2022, 2022: 7618440

[34] ZhaoK, ZhouY, YuX, et al. . Strain-rate effects on the crack evolution pattern and damage characteristics of cemented paste backfill [J]. Geotechnical and Geological Engineering, 2023, 41: 295-310

[35] FallM, BelemT, SambS, et al. . Experimental characterization of the stress - strain behaviour of cemented paste backfill in compression [J]. Journal of materials science, 2007, 42: 3914-3922

[36] TuM, LinY-D, ZhangX-Y, et al. . Evolution of overburden structure and reasonable width of section coal pillar in large space isolated island stope [J]. Journal of Mining & Safety Engineering, 2021, 38(5): 857-865(in Chinese)

[37] YangW-L, JiangF-X, YangP, et al. . Prevention of rockburst in large island longwall panels induced by instability of super-thick magmatic strata [J]. Chinese Journal of Rock Mechanics and Engineering, 2017, 36(S1): 3382-3391(in Chinese)

[38] ZhouN, DuE-B, LiM, et al. . Determination of the stability of residual pillars in a room-and-pillar mining goaf under eccentric load [J]. Energy Reports, 2021, 7: 9122-9132

[39] WangX, WenZ-J, MikaelR, et al. . Experimental study of strength properties of coal-rock under non-uniformly distributed load [J]. Rock and Soil Mechanics, 2017, 38(3): 723-730(in Chinese)

[40] XuJ, LiuD, YinZ-G, et al. . Simulation experiment of coal and gas outburst under non-uniform load [J]. Journal of China Coal Society, 2012, 37(5): 836-842(in Chinese)

[41] WangX-F, LuM-Y, WeiR, et al. . Mechanical mechanism analysis of roof fracture evolution in stope with variable length based on elastic-plastic structure theory [J]. Geofluids, 2022, 2022: 2475021

[42] LiZ, YuS-C, ZhuW-B, et al. . Dynamic loading induced by the instability of voussoir beam structure during mining below the slope [J]. International Journal of Rock Mechanics & Mining Sciences, 2020, 132: 104343

[43] WangH-C, FengG-R, QiT-Y, et al. . Influence of the use of corn straw fibers to connect the interfacial transition zone with the mechanical properties of cemented coal gangue backfill [J]. Construction and Building Materials, 2023, 367: 130334

[44] ZhaoY-H, GuoY-X, FengG-R, et al. . Study on strength and deformation characteristics of cemented gangue backfill body under the coupling action of load and salt erosion [J]. Construction and Building Materials, 2022, 342: 128003

[45] QiT-Y, FengG-R, ZhangY-J, et al. . Effects of fly ash content on properties of cement paste backfilling [J]. Journal of Residuals Science & Technology, 2015, 12: 133-141

[46] ZhangX-G, LinJ, LiuJ-X, et al. . Investigation of hydraulic-mechanical properties of paste backfill containing coal gangue-fly ash and its application in an underground coal mine [J]. Energies, 2017, 10(9): 1309

[47] FENG Guo-rui, MA Jing-kai, LI Zhu, et al. Bearing characteristics and damage mechanism of grouting reinforced body for broken surrounding rock [J]. Journal of China Coal Society, 2022, 1 - 13. DOI: https://doi.org/10.13225/j.cnki.jccs.2022.1265. (in Chinese)

[48] ChengA-P, ZhangY-S, DaiS-Y, et al. . Space-time evolution of acoustic emission parameters of cemented backfill and its fracture prediction under uniaxial compression [J]. Rock and Soil Mechanics, 2019, 40(8): 2965-2974(in Chinese)

[49] KimJ S, LeeK S, ChoW J, et al. . A comparative evaluation of stress strain and acoustic emission methods for quantitative damage assessments of brittle rock [J]. Rock Mechanics and Rock Engineering, 2015, 48(2): 495-508

[50] ZhaoK, YuX, ZhuS-T, et al. . Acoustic emission investigation of cemented paste backfill prepared with tantalum-niobium tailings [J]. Construction and Building Materials, 2020, 237: 117523

[51] ZhouY, YinS-H, ZhaoK, et al. . Understanding the static rate dependence of early fracture behavior of cemented paste backfill using digital image correlation and acoustic emission techniques [J]. Engineering Fracture Mechanics, 2023, 283: 109209

[52] YueJ G, KunnathS K, XiaoY. Uniaxial concrete tension damage evolution using acoustic emission monitoring [J]. Construction and Building Materials, 2020, 232: 117281

[53] XiaZ, YaoQ-L, LiX-H, et al. . Acoustic emission characteristics and energy mechanism of CFRP-jacketed coal specimens under uniaxial compression [J]. Construction and Building Materials, 2022, 342: 127936

[54] NavaF A, Márquez-RamírezV H, ZúñigaF R, et al. . Gutenberg-Richter b-value maximum likelihood estimation and sample size [J]. Journal of Seismology, 2017, 21(1): 127-135

[55] HanQ-H, WangL-C, XuJ, et al. . A robust method to estimate the b-value of the magnitude - frequency distribution of earthquakes [J]. Chaos, Solitons & Fractals, 2015, 81: 103-110

[56] ChenT, ZhaoK, YanY-J, et al. . Mechanical properties and acoustic emission response of cemented tailings backfill under variable angle shear [J]. Construction and Building Materials, 2022, 343: 128114