Strength and failure characteristics of coal measures mudstone specimens containing a prefabricated flaw under true triaxial tests

Abstract

In this study, a series of coal measures mudstone specimens containing a prefabricated flaw were subjected to true triaxial test (TTT), namely, specimens of the intermediate principal stress (σ₂) parallel to prefabricated flaw (TTT-Flaw-2) and specimens of the minimum principal stress (σ₃) parallel to prefabricated flaw (TTT-Flaw-3). The main objective of this study was to investigate the effects of the loading direction of σ₂ and the position of prefabricated flaw on the strength and failure modes of specimens. The results showed that the peak strength of intact and flawed specimens first increased and then decreased with increasing σ₂, which could be fitted by the Mogi-Coulomb criterion. Under the same loading stresses, the strength of intact specimen was larger than that of flawed specimens, and specimens TTT-Flaw-2 had the lowest strength. The X-ray computerized tomography scanning results revealed that fractures were not always observed to form along the prefabricated flaw tips but were distributed randomly inside the specimen under conventional triaxial test conditions. Under TTT conditions, anti-wing cracks initiated from the vicinity of the prefabricated flaw tip and were observed in σ₂-drrection for specimens TTT-Flaw-2. While for specimens TTT-Flaw-3, shear cracks appeared in σ₂-direction, and few anti-wing cracks were observed in σ₃-direction.

Keywords

true triaxial test / coal measures mudstone / prefabricated flaw / strength / fracture pattern

References

[1] XieH-P, JuY, GaoF, et al. . Groundbreaking theoretical and technical conceptualization of fluidized mining of deep underground solid mineral resources [J]. Tunnelling and Underground Space Technology, 2017, 67: 68-70

[2] PerrasM A, WannenmacherH, DiederichsM S. Underground excavation behaviour of the queenston formation: tunnel back analysis for application to shaft damage dimension prediction [J]. Rock Mechanics and Rock Engineering, 2015, 48(4): 1647-1671

[3] CharletL A E P, WersinP, GilbertB. Diffusive transport and reaction in clay rocks: A storage (nuclear waste, CO₂, H₂), energy (shale gas) and water quality issue [J]. Advances in Water Resources, 2017, 106: 39-59

[4] LiuJ, XueY, FuY, et al. . Numerical investigation on microwave-thermal recovery of shale gas based on a fully coupled electromagnetic, heat transfer, and multiphase flow model [J]. Energy, 2023, 263: 126090

[5] TianJ-W, LiuJ-S, ElsworthD, et al. . Linking fractal theory to a fully coupled coal deformation and two-phase flow multiphysics: The role of fractal dimensions [J]. Energy & Fuels, 2022, 36(20): 12591-12605

[6] VishalV, RanjithP G, SinghT N. CO₂ permeability of Indian bituminous coals: Implications for carbon sequestration [J]. International Journal of Coal Geology, 2013, 10536-47

[7] JING Y, RABBANI A, ARMSTRONG R T, et al. An image-based coal network model for simulating hydro-mechanical gas flow in coal: An application to carbon dioxide geosequestration [J]. Journal of Cleaner Production, 2022, 379. DOI: https://doi.org/10.1016/j.jclepro.2022.134647.

[8] CaiM, KaiserP K, TasakaY, et al. . Generalized crack initiation and crack damage stress thresholds of brittle rock masses near underground excavations [J]. International Journal of Rock Mechanics and Mining Sciences, 2004, 41(5): 833-847

[9] BésuelleP, DesruesJ, RaynaudS. Experimental characterisation of the localisation phenomenon inside a Vosges sandstone in a triaxial cell [J]. International Journal of Rock Mechanics and Mining Sciences, 2000, 37(8): 1223-1237

[10] VishalV, RanjithP G, SinghT N. An experimental investigation on behaviour of coal under fluid saturation, using acoustic emission [J]. Journal of Natural Gas Science and Engineering, 2015, 22: 428-436

[11] HaeriH, ShahriarK, MarjiM F, et al. . Experimental and numerical study of crack propagation and coalescence in pre-cracked rock-like disks [J]. International Journal of Rock Mechanics and Mining Sciences, 2014, 67(4): 20-28

[12] BiJ, ZhouX-P, QianQ-H. The 3D Numerical simulation for the propagation process of multiple preexisting flaws in rock-like materials subjected to biaxial compressive loads [J]. Rock Mechanics and Rock Engineering, 2016, 49(5): 1611-1627

[13] ChenM, YangS-Q, RanjithP G, et al. . Cracking behavior of rock containing non-persistent joints with various joints inclinations [J]. Theoretical and Applied Fracture Mechanics, 2020, 109: 16

[14] AndreevG EBrittle failure of rock materials: test results and constitutive models [M], 1995, Rotterdam, A. A. Balkema

[15] WongT W, BaudP. The brittle-ductile transition in porous rock: A review [J]. Journal of Structural Geology, 2012, 4425-53

[16] SaksalaT, IbrahimbegovicA. Anisotropic viscodamage-viscoplastic consistency constitutive model with a parabolic cap for rocks with brittle and ductile behaviour [J]. International Journal of Rock Mechanics & Mining Sciences, 2014, 70(9): 460-473

[17] MaX-DFailure characteristics of compactive, porous sandstones subjected to true triaxial stresses [D], 2014, Madison, USA, The University of Wisconsin-Madison

[18] LuY-L, WangL-G, ElsworthD. Uniaxial strength and failure in sandstone containing a pre-existing 3-D surface flaw [J]. International Journal of Fracture, 2015, 194(1): 59-79

[19] McgarrA, GayN C. State of stress in the Earth’s crust [J]. Annual Review of Earth & Planetary Sciences, 2003, 6(1): 405-436

[20] BraceW F, KohlstedtD L. Limits on lithospheric stress imposed by laboratory experiments [J]. Journal of Geophysical Research Atmospheres B, 1980, 85(11): 6248-6252

[21] WangZ-W, LiuQ-S. Failure criterion for soft rocks considering intermediate principal stress [J]. International Journal of Mining Science and Technology, 2021, 31(4): 565-575

[22] MogiK. Flow and fracture of rocks under general triaxial compression [J]. Applied Mathematics and Mechanics, 1981, 6: 635-651

[23] HaimsonB, ChangC-D. A new true triaxial cell for testing mechanical properties of rock, and its use to determine rock strength and deformability of Westerly granite [J]. International Journal of Rock Mechanics and Mining Sciences, 2000, 37(1): 285-296

[24] ChangC-D, HaimsonB. True triaxial strength and deformability of the German Continental Deep Drilling Program (KTB) deep hole amphibolite [J]. Journal of Geophysical Research Solid Earth B, 2000, 105(8): 18999-19013

[25] OkuH, HaimsonB, SongS-R. True triaxial strength and deformability of the siltstone overlying the Chelungpu fault (Chi-Chi earthquake), Taiwan [J]. Geophysical Research Letters, 2007, 34(9): 139-158

[26] HaimsonB, RudnickiJ W. The effect of the intermediate principal stress on fault formation and fault angle in siltstone [J]. Journal of Structural Geology, 2010, 32(11): 1701-1711

[27] LeeH, HaimsonB C. True triaxial strength, deformability, and brittle failure of granodiorite from the San Andreas Fault observatory at depth [J]. International Journal of Rock Mechanics and Mining Sciences, 2011, 48(7): 1199-1207

[28] JiangJ-Q, FengX-T, YangC-X, et al. . Experimental study on the failure characteristics of granite subjected to weak dynamic disturbance under different σ₃ conditions [J]. Rock Mechanics and Rock Engineering, 2021, 54(11): 5577-5590

[29] ZhengZ, FengX-T, ZhangX-W, et al. . Residual strength characteristics of CJPL marble under true triaxial compression [J]. Rock Mechanics and Rock Engineering, 2019, 52(4): 1247-1256

[30] FENG Xia-ting, ZHANG Xi-wei, YANG Cheng-xiang, et al. Evaluation and reduction of the end friction effect in true triaxial tests on hard rocks [J]. International Journal of Rock Mechanics & Mining Sciences, 2017: 144–148. DOI: https://doi.org/10.1016/j.ijrmms.2017.04.002.

[31] FengX-T, ZhangX-W, KongR, et al. . A novel Mogi type true triaxial testing apparatus and its use to obtain complete stress - strain curves of hard rocks [J]. Rock Mechanics and Rock Engineering, 2016, 49(5): 1649-1662

[32] LiuY-B, LiM-H, YinG-Z, et al. . Permeability evolution of anthracite coal considering true triaxial stress conditions and structural anisotropy [J]. Journal of Natural Gas Science and Engineering, 2018, 52: 492-506

[33] LuJ, HuangG, GaoH, et al. . Mechanical properties of layered composite coal-rock subjected to true triaxial stress [J]. Rock Mechanics and Rock Engineering, 2020, 53(9): 4117-4138

[34] MaX-D, HaimsonB. Failure characteristics of two porous sandstones subjected to true triaxial stresses [J]. Journal of Geophysical Research: Solid Earth, 2016, 121: 6477-6498

[35] ZhaoJ, FengX-T, ZhangX-W, et al. . Brittleductile transition and failure mechanism of Jinping marble under true triaxial compression [J]. Engineering Geology, 2018, 232: 160-170

[36] VachaparampilA, GhassemiA. Failure characteristics of three shales under true-triaxial compression [J]. International Journal of Rock Mechanics and Mining Sciences, 2017, 100: 151-159

[37] LuW-B, ZhuZ-D, HeY-X, et al. . Strength characteristics and failure mechanism of a columnar jointed rock mass under uniaxial, triaxial, and true triaxial confinement [J]. Rock Mechanics and Rock Engineering, 2021, 54(5): 2425-2439

[38] ChangX, ZhangX, DangF-N, et al. . Failure behavior of sandstone specimens containing a single flaw under true triaxial compression [J]. Rock Mechanics and Rock Engineering, 2022, 55(4): 2111-2127

[39] GaoY-H, FengX-T, WangZ-F, et al. . Strength and failure characteristics of jointed marble under true triaxial compression [J]. Bulletin of Engineering Geology and the Environment, 2020, 79(2): 891-905

[40] LuY-L, PuH, WangL-G, et al. . Fracture evolution in mudstone specimens containing a pre-existing flaw under true triaxial compression [J]. International Journal of Rock Mechanics and Mining Sciences, 2021, 138: 104594

[41] LuY-L, LiW-S, WangL-G, et al. . Damage evolution and failure behavior of sandstone under true triaxial compression [J]. Geotechnical Testing Journal, 2019, 42(3): 610-637

[42] MaX-D, RudnickiJ W, HaimsonB. The application of a Matsuoka-Nakai-Lade-Duncan failure criterion to two porous sandstones [J]. International Journal of Rock Mechanics and Mining Sciences, 2017, 929-18

[43] Al-AjmiA M, ZimmermanR W. Relation between the Mogi and the Coulomb failure criteria [J]. International Journal of Rock Mechanics and Mining Sciences, 2005, 42(3): 431-439

[44] ChangC-D, HaimsonB. A failure criterion for rocks based on true triaxial testing [J]. Rock Mechanics and Rock Engineering, 2012, 45(6): 1007-1010

[45] YangS-Q, RanjithP G, GuiY-L. Experimental study of mechanical behavior and X-Ray micro CT observations of sandstone under conventional triaxial compression [J]. Geotechnical Testing Journal, 2015, 38(2): 20140209

[46] LiZ-L, WangL-G, JiangC-Y, et al. . Three-dimensional fracture evolution patterns of rocks under true triaxial conditions based on real-time CT scanning [J]. Journal of China Coal Society, 2021, 463937-949(in Chinese)