Numerical simulation research on response characteristics of surrounding rock for deep super-large section chamber under dynamic and static combined loading condition

Abstract

The stability control of surrounding rock for large or super-large section chamber is a difficult technical problem in deep mining condition. Based on the in-site geological conditions of Longgu coal mine, this paper used the dynamic module of FLAC^3D to study the response characteristics of deep super-large section chamber under dynamic and static combined loading condition. Results showed that under the static loading condition, the maximum vertical stress, deformation and failure range are large, where the stress concentration coefficient is 1.64. The maximum roof-to-floor and two-sides deformations are 54.6 mm and 53.1 mm, respectively. Then, under the dynamic and static combined loading condition: (1) The influence of dynamic load frequency on the two-sides is more obvious; (2) The dynamic load amplitude has the greatest influence on the stress concentration degree, and the plastic failure tends to develop to the deeper; (3) With the dynamic load source distance increase, the response of surrounding rock is gradually attenuated. On this basis, empirical equations for each dynamic load conditions were obtained by using regression analysis method, and all correlation coefficients are greater than 0.99. This research provided reference for the supporting design of deep super-large section chamber under same or similar conditions.

Keywords

deep mining / super-larger section chamber / static load / dynamic load frequency / dynamic load amplitude / dynamic load source distance

References

[1] ZhangG-C, HeF-L, LaiY-H, JiaH-G. Ground stability of underground gateroad with 1 km burial depth: A case study from Xingdong coal mine, China [J]. Journal of Central South University, 2018, 25(6): 1386-1398

[2] RanjithP G, ZhaoJ, JuM-H, De SilvaR V S, RathnaweeraT D, BandaraA K M S. Opportunities and challenges in deep mining: A brief review [J]. Engineering, 2017, 3: 546-551

[3] FanD-Y, LiuX-S, TanY-L, YanL, SongS-L, NingJ-G. An innovative approach for gob-side entry retaining in deep coal mines: A case study [J]. Energy Science and Engineering, 2019, 7: 2321-2335

[4] KonicekP, SoucekK, StasL, SinghR. Long-hole destress blasting for rockburst control during deep underground coal mining [J]. International Journal of Rock Mechanics and Mining Sciences, 2013, 61: 141-153

[5] KongB, WangE-Y, LuW, LiZ-H. Application of electromagnetic radiation detection in high-temperature anomalous areas experiencing coalfield fires [J]. Energy, 2019, 189: 1-13

[6] KnappsteinR, KuenneG, BeckerL G, DiM F, SadikiA, DreizlerA, JanickaJ. Large eddy simulation of a novel gas-assisted coal combustion chamber [J]. Flow, Turbulence and Combustion, 2018, 101(3): 895-926

[7] MaQ, TanY-L, LiuX-S, GuQ-H, LiX-B. Effect of coal thicknesses on energy evolutioncharacteristics of roof rock-coal-floor rock sandwich composite structure and its damage constitutivemodel [J]. Composites Part B, 2020, 198: 108086

[8] ZHAO Zeng-hui, ZHANG Ming-zhong, MA Qing, CHEN Bao-sen. Deviation effect of coaxiality on the rock brazilian split [J]. Advances in Mathematical Physics, 2020: 5782457. DOI: https://doi.org/10.1155/2020/5782457.

[9] TanY-L, FanD-Y, LiuX-S, SongS-L, LiX-F, WangH-L. Numerical investigation on failure evolution of surrounding rock for super-large section chamber group in deep coal mine [J]. Energy Science and Engineering, 2019, 73124-3146

[10] ZhouW-L, ZhangP-S, WuR-X, HuX-Y. Dynamic monitoring the deformation and failure of extra-thick coal seam floor in deep mining [J]. Journal of Applied Geophysics, 2019, 163: 132-138

[11] JiaP, ZhuW-C. Dynamic-static coupling analysis on rockburst mechanism in jointed rock mass [J]. Journal of Central South University, 2012, 19(11): 3285-3290

[12] YinT-B, WangP, LiX-B, ShuR-H, YeZ-Y. Effects of thermal treatment on physical and mechanical characteristics of coal rock [J]. Journal of Central South University, 2016, 23(9): 2336-2345

[13] HuS-C, TanY-L, ZhouH, RuW-K, NingJ-G, WangJ, HuangD-M, LiZ. Anisotropic modeling of layered rocks incorporating planes of weakness and volumetric stress [J]. Energy Science and Engineering, 2019, 8(3): 789-803

[14] SONG Shi-lin, LIU Xue-sheng, TAN Yun-liang, FAN De-yuan, MA Qing, WANG Hong-lei. Study on failure modes and energy evolution of coal-rock combination under cyclic loading [J]. Shock and Vibration, 2020: 5731721. DOI: https://doi.org/10.1155/2020/5731721.

[15] ZHAO Tong-bin, ZHANG Wei, GUO Wei-yao. Digital image correlation analysis of displacement based on corrected three surface fitting algorithm [J]. Complexity, 2019: 4620858. DOI: https://doi.org/10.1155/2019/4620858.

[16] WangJ, NingJ-G, JiangJ-Q, BuT-T. Structural characteristics of strata overlying of a fully mechanized longwall face: a case study [J]. Journal of the Southern African Institute of Mining and Metallurgy, 2018, 118: 1195-1204

[17] TanY-L, LiuX-S, ShenB-T, GuQ-H, NingJ-G. New approaches to testing and evaluating the rockburst risk of coal seam with hard roof and/or floor in coal mines [J]. Geomechanics and Engineering, 2018, 14(4): 367-376

[18] FanD-Y, LiuX-S, TanY-L, SongS-L, GuQ-H, YanL, XuQ. Roof cutting parameters design for gob-side entry in deep coal mine: A case study [J]. Energies, 2019, 12: 2032

[19] LiM, ZhangJ-X, ZhouN, HuangY-L. Effect of particle size on energy evolution of crushed waste rock in coal mines [J]. Rock Mechanics and Rock Engineering, 2017, 50(5): 1347-1354

[20] WangM, ZhengD-J, NiuS-J, LiW-F. Large deformation of tunnels in longwall coal mines [J]. Environmental Earth Sciences, 2019, 78(2): 45

[21] LiM, AminossadatiS M, WuC. Numerical simulation of air ventilation in super-large underground developments [J]. Tunnelling and Underground Space Technology, 2016, 5238-43

[22] LiuD-Q, WangY, HuX-X, RenF-Q. Calculation and test analysis on stress of surrounding rock in mine roadway with mine pressure bump occurred by dynamic load [J]. Coal Science and Technology, 2015, 43(9): 42-46

[23] LiK, ZhangJ-H, ZhangK-Z, XiaoL-P, XuY-L, DuanYu. Study on mechanism of deep roadway rock burst induced by dynamic load in high ground stress region [J]. Safety in Coal Mines, 2017, 48(7): 52-56

[24] XiaoT-Q, BaiJ-B, WangX-Y, ChenY, YuY. Stability principle and control of surrounding rock in deep coal roadway with large section and thick top-coal [J]. Rock and Soil Mechanics, 2011, 32(6): 1874-1880

[25] LiuX-S, NingJ-G, TanY-L, GuQ-H. Damage constitutive model based on energy dissipation for intact rock subjected to cyclic loading [J]. International Journal of Rock Mechanics and Mining Sciences, 2016, 8527-32

[26] LiuX-S, TanY-L, NingJ-G, LuY-W, GuQ-H. Mechanical properties and damage constitutive model of coal in coal-rock combined body [J]. International Journal of Rock Mechanics and Mining Sciences, 2018, 110: 140-150

[27] LiuX-S, GuQ-H, TanY-L, NingJ-G, JiaZ-C. Mechanical characteristics and failure prediction of cement mortar with a sandwich structure [J]. Minerals, 2019, 9: 143

[28] KongB, WangE-Y, LiZ-H, LuW. Study on the feature of electromagnetic radiation under coal oxidation and temperature rise based on multi-fractal theory [J]. Fractals, 2019, 271950038-14

[29] ChakrabortyT, MishraS, LoukusJ, HalonenB, BekkalaB. Characterization of three Himalayan rocks using a split Hopkinson pressure bar [J]. International Journal of Rock Mechanics and Mining Sciences, 2016, 85: 112-118

[30] GONG Feng-qiang, LI Xi-bing, LIU Xi-ling, ZHAO J. Energy Dissipation characteristic of red sandstone in the dynamic brazilian disc test with SHPB setup [J]. Advances in Civil Engineering, 2020: 7160937. DOI: https://doi.org/10.1155/2020/7160937.

[31] LiuS-H, PanJ-F, MaoD-B, WangS-W, PanL-M. Experiment research on axial force quantitative loss law of anchor bolt in blasting in high impact danger roadway [J]. Journal of China Coal Society, 2016, 41(5): 1120-1128

[32] CaiW, DouL-M, WangG-F, HuY-W. Mechanism of fault reactivation and its induced coal burst caused by coal mining activities [J]. Journal of Mining and Safety Engineering, 2019, 36(6): 1193-1202

[33] HuoB-J, JingX-D, FanZ-L, XieW, DuanZ-H, XieZ-H. Mechanism of dynamic load of longwall mining under shallow room mining goaf [J]. Chinese Journal of Geotechnical Engineering, 2019, 41(6): 1116-1123

[34] XieL, DouL-M, LvC-G, YuG-L, WangYi. Study on the effect of floor burst induced by dynamic disturbance at different lateral pressure coefficients [J]. Journal of Mining and Safety Engineering, 2013, 30(2): 251-255

[35] HanZ-P, DouL-M, WangZ-Y, QiaoZ-D. Research on stress distribution law of two ribs in large dip angle working face under influence of dynamic and static loads [J]. Coal Science and Technology, 2019, 47(9): 183-188

[36] YangZ-L, ZangC-W, TanY-L, LiJ-Z. Numerical simulation of static and dynamic load variation characteristics of surrounding rock in deep roadway [J]. Coal Mining Technology, 2015, 20(4): 62-65

[37] JiaoJ-K, JuW-J, WuY-Z, HeJ. Multi-layer control technologies for surrounding rock stability of dynamic-loading rock burst roadway [J]. Coal Science and Technology, 2019, 47(12): 10-17

[38] WangZ-Y, DouL-M, WangG-F. Failure mechanism of anchored bolt supporting structure of circular roadway under dynamic load [J]. Chinese Journal of Geotechnical Engineering, 2019, 37(10): 1901-1909

[39] FairhurstC E, HudsonJ A. Draft ISRM suggested method for the complete stress-strain curve for intact rock in uniaxial compression [J]. International Journal of Rock Mechanics & Mining Science, 1999, 36(3): 281-289

[40] ZhengH, FengX-T, ChenZ-Y, HudsonJ A, WangY-J. ISRM suggested method for reporting rock laboratory test data in electronic format [J]. Rock Mechanics and Rock Engineering, 2014, 47(1): 221-254

[41] MohammadN, ReddishD J, StaceL R. The relation between in situ, and laboratory rock properties used in numerical modelling [J]. International Journal of Rock Mechanics and Mining Science, 1997, 34: 289-297

[42] CaiM-F, HeM-C, LiuD-YRock mechanics and engineering[M], 2013, Beijing, Science Press

[43] ChenX-J, LiL-Y, WangL, QiL-L. The current situation and prevention and control countermeasures for typical dynamic disasters in kilometer-deep mines in China [J]. Safety Science, 2019, 115: 229-236

[44] LiuX-S, NingJ-G, TanY-L, GuQ-H. Coordinated supporting method of gob-side entry retaining in coal mines and a case study with hard roof [J]. Geomechanics and Engineering, 2018, 15(6): 1173-1182

[45] YuanZ-H, CaoZ-G, CaiY-Q, GengX-Y, WangX-Q. An analytical solution to investigate the dynamic impact of a moving surface load on a shallowly-buried tunnel [J]. Soil Dynamics and Earthquake Engineering, 2019, 126105816

[46] LiD-Y, XiaoP, HanZ-Y, ZhuQ-Q. Mechanical and failure properties of rocks with a cavity under coupled static and dynamic loads [J]. Engineering Fracture Mechanics, 2020, 225106195

[47] XuJ-K, ZhouR, SongD-Z, LiN, ZhangK, XiD. Deformation and damage dynamic characteristics of coal-rock materials in deep coal mines [J]. International Journal of Damage Mechanics, 2019, 28(1): 58-78

[48] DuB-B, WangS-B, WangD-J, DuH. Study on numerical simulation of seismic wave transmission law in coal and rock mass [J]. Coal Science and Technology, 2014, 42(S1): 7-9

[49] LI Feng, BI Ming-xin, TIAN Jing, FANG Shu-hao. The dynamic damage mechanisms and failure modes of coal-rock masses under the action of high order P-waves [J]. Shock and Vibration, 2018: 5386123. DOI: https://doi.org/10.1155/2018/5386123.