Room temperature gas sensor based on tube-like hydroxyapatite modified with gold nanoparticles

Abstract

The main goal of this work is to explore the possibility of using Au-modified hydroxyapatite (HA) as a potential sensor material. Tube-like HA structure was fabricated with the aid of a Nafion N-117 cation exchange membrane and gold (Au) nanoparticles were added by a hydrothermal method. The morphology, structure and composition were characterized by scanning electron microscopy (SEM), transmission electron microscopy (TEM), X-ray diffraction (XRD), and X-ray photoelectron spectroscopy (XPS). The gas sensing properties were also investigated. Results show that Au nanoparticles are dispersed into the HA powder, which is tube-like, with rough inner and outer surfaces. Compared with pure HA, Au-modified HA exhibits improved sensing properties for NH₃. 5% (mass fraction) Au-modified HA shows the highest response with relatively short response/recovery time. The response is up to 79.2% when the corresponding sensor is exposed to 200×10^-6 NH₃ at room temperature, and the response time and recovery time are 20 s and 25 s, respectively. For lower concentration, like 50×10^-6, the response is still up to 70.8%. Good selectivity and repeatability are also observed. The sensing mechanism of high response and selectivity for NH₃ gas was also discussed. These results suggest that Au-HA composite is a promising material for NH₃ sensors operating at room temperature.

Keywords

gas sensor / Au nanoparticles / hydroxyapatite / gas selectivity / ammonia gas

References

[1] MahaboleM P, MeneR U, KhairnarR S. Gas sensing and dielectric studies on cobalt doped hydroxyapatite thick films [J]. Advanced Materials Letters, 2013, 4(1): 46-52

[2] ChoiY J, HwangI S, ParkJ G, ChoiK J, ParkJ H, LeeJ H. Novel fabrication of an SnO₂ nanowire gas sensor with high sensitivity [J]. Nanotechnology, 2008, 19: 095508

[3] YangT Y, LinH M, WeiB Y, WuC Y, LinC K. UV enhancement of the gas sensing properties of nano-TiO2 [J]. Review Advance Materials Science, 2003, 4: 48-54

[4] XuJ, PanQ, ShunY A, TianZ. Grain size control and gas sensing properties of ZnO gas sensor [J]. Sensors and Actuators B: Chemical, 2000, 66: 277-279

[5] ElliottJ CStructure and chemistry of the apatites and other calcium orthophosphates [M], 1994AmsterdamElsevier

[6] HuangJ, WangL C, LiuY M, CaoY, HeH Y, FanK N. Gold nanoparticles supported on hydroxylapatite as high performance catalysts for low temperature CO oxidation [J]. Applied Catalysis B: Environmental, 2011, 101: 560-569

[7] DomN M, RomerosF, CentenoM, OdriozolaJ. Gold/hydroxyapatite catalysts: Synthesis, characterization and catalytic activity to CO oxidation [J]. Applied Catalysis B: Environmental, 2009, 87: 245-251

[8] FujiiE, KawabataK, AndoK, TsuruK, HayakawaS, OsakaA. Synthesis and structural characterization of silica-hybridized hydroxyapatite with gas adsorption capability [J]. Journal of the Ceramic Society of Japan, 2006, 114(9): 769-773

[9] MeneR U, MahaboleM P, KhairnarR. Surface modification of cobalt doped hydroxyapatite thick films via swift heavy ion irradiations for CO and CO₂ gas sensing application [C]//. Proceedings IMCS, 20121180-1183

[10] MeneR U, MahaboleM P, SharmaR, KhairnarR S. Enhancement in CO gas sensing properties of hydroxyapatite thick films: Effect of swift heavy ion irradiation [J]. Vacuum, 2011, 86: 66-71

[11] ZhangD, LiC, LiuX, HanS, TangT, ZhouC. Doping dependent NH₃ sensing of indium oxide nanowires [J]. Applied Physics Letters, 2003, 83: 1845-1847

[12] ZhuJ. Photocatalytic properties of thin films of ruthenium metallopolymers/gold nanoparticle: Polyoxometalate composites using visible excitation [J]. Journal of Central South University, 2013, 20: 2657-2662

[13] WangX, ZhangJ, ZhuZ, ZhuJ. Effect of Pd²⁺ doping on ZnO nanotetrapods ammonia sensor [J]. Colloids and Surfaces A: Physicochemical and Engineering Aspects, 2006, 276: 59-64

[14] RamgirN S, HwangY K, JhungS H, KimH K, HwangJ S, MullaI S, ChangJ S. CO sensor derived from mesostructured Au-doped SnO₂ thin film [J]. Applied Surface Science, 2006, 252: 4298-4305

[15] TienL, SadikP, NortonD, VossL, PeartonS, WangH, KangB, RenF, JunJ, LinJ. Hydrogen sensing at room temperature with Pt-coated ZnO thin films and nanorods [J]. Applied Physics Letters, 2005, 87: 222106

[16] GuoJ, ZhangJ, ZhuM, JuD, XuH, CaoB. High-performance gas sensor based on ZnO nanowires functionalized by Au nanoparticles [J]. Sensors and Actuators B: Chemical, 2014, 199: 339-345

[17] TangH, YanM, ZhangH, LiS, MaX, WangM, YangD. A selective NH₃ gas sensor based on Fe₂O₃–ZnO nanocomposites at room temperature [J]. Sensors and Actuators B: Chemical, 2006, 114: 910-915

[18] ManiG K, RayappanJ B B. A highly selective and wide range ammonia sensor—Nanostructured ZnO:Co thin film [J]. Materials Science and Engineering B, 2015, 191: 41-50

[19] ZhangY, LiuY, JiX, BanksC E, ZhangW. Sea cucumber-like hydroxyapatite: cation exchange membrane-assisted synthesis and its application in ultra-sensitive heavy metal detection [J]. Chemical Communication, 2011, 47: 4126-4128

[20] ZhangY, LiK, ZhangQ, LiuW, LiuY, BanksC E. Multi-dimensional hydroxyapatite (HAp) nanocluster architectures fabricated via Nafion-assisted biomineralization [J]. New Journal of Chemistry, 2015, 39(1): 750-754

[21] SangpourP, AkhavanO, MoshfeghA, RoozbehiM. Formation of gold nanoparticles in heat-treated reactive co-sputtered Au-SiO₂ thin films [J]. Applied Surface Science, 2007, 254: 286-290

[22] HarutaM. Nanoparticulate gold catalysts for low-temperature CO oxidation [J]. Journal of New Materials for Electrochemical Systems, 2004, 7: 163-172

[23] TavoliF, AlizadehN. Optical ammonia gas sensor based on nanostructure dye-doped polypyrrole [J]. Sensors and Actuators B: Chemical, 2013, 176: 761-767

[24] Dhayal RajA, PazhanivelT, Suresh KumarP, MangalarajD, NatarajD, PonpandianN. Self assembled V₂O₅ nanorods for gas sensors [J]. Current Applied Physics, 2010, 10: 531-537

[25] TuanC V, TuanM A, HieuN V, TrungT. Electrochemical synthesis of polyaniline nanowires on Pt interdigitated microelectrode for room temperature NH₃ gas sensor application [J]. Current Applied Physics, 2012, 12: 1011-1016

[26] LeeS K, ChangD, KimS W. Gas sensors based on carbon nanoflake/tin oxide composites for ammonia detection [J]. Journal of Hazardous Materials, 2014, 268: 110-114

[27] BalamuruganC, LeeD W. A selective NH₃ gas sensor based on mesoporous p-type NiV₂O₆ semiconducting nanorods synthesized using solution method [J]. Sensors and Actuators B: Chemical, 2014, 192: 414-422

[28] MaciakE, PustelnyT. An optical ammonia (NH₃) gas sensing by means of Pd/CuPc interferometric nanostructures based on white light interferometry [J]. Sensors and Actuators B: Chemical, 2013, 189: 230-239

[29] XiaX, GuoS, ZhaoW, XuP, YuH, XuT, LiX. Carboxyl functionalized gold nanoparticles in situ grown on reduced graphene oxide for micro-gravimetric ammonia sensing [J]. Sensors and Actuators B: Chemical, 2014, 202: 846-853

[30] NagaiM, NishinoT. Surface conduction of porous hydroxyapatite ceramics at elevated temperatures [J]. Solid State Ionics, 1988, 28: 1456-1461

[31] ShingayaY, KuboH, ItoM. Coadsorption of ammonia and electrolyte anions on a Pt(111) electrode [J]. Surface Science, 1999, 427/428: 173-178