Experimental study of leakage characteristics and microscopic mechanisms in the sealing plug areas of underground compressed air energy storage caverns

Abstract

To investigate the leakage mechanism of the sealing plug area in compressed air energy storage (CAES) caverns under various conditions, the leakage evolution characteristics of the simulated samples were systematically studied via a self-developed triaxial seepage testing system. Combined with CT scanning, the development and propagation mechanisms of internal defects were elucidated. The results indicate that the leakage index is significantly positively correlated with the peak air pressure and injection rate but negatively correlated with the confining pressure. Leakage behavior during the charging phase is governed primarily by the peak pressure and injection rate, whereas that during the storage phase is predominantly controlled by the pressure magnitude. A distinct time lag, dominated by peak pressure, was identified between the leakage index and pressure characteristic points. The average peak leakage rate exhibited a "decreasing-then-increasing” trend, transitioning from an initial value of 9.3289 to 7.3267 cm³/s and then rebounding to 8.8093 cm³/s. The cyclic process enhanced the connectivity of the pore-fracture network; fracture coalescence reduced the number of large pores (> 0.9 mm) but increased the total pore count. This research provides valuable insights for evaluating the sealing performance and rock concrete interface seepage of artificial CAES caverns.

Keywords

Compressed air energy storage (CAES) / Sealing plug / Leakage assessment / Crack pore coupled leakage mechanism / Microscopic defect development

References

[1] Guerra OJ, Zhang JZ, Eichman J, Denholm P, Kurtz J, Hodge BM. The value of seasonal energy storage technologies for the integration of wind and solar power. Energy Environ Sci 2020; 13(7):1909-22.

[2] Li Q, Liu W, Jiang L, Ju Y, Hassanpouryouzband A, Zhang G, et al. Harnessing sediment voids of low—grade salt mines for compressed air energy storage: Experimental and theoretical insights. Int J Min Sci Technol 2025; 35(8):1303—22.

[3] Bazdar E, Sameti M, Nasiri F, Haghighat F. Compressed air energy storage in integrated energy systems: A review. Renew Sustain Energy Rev 2022; 167:112701.

[4] Mouli—Castillo J, Wilkinson M, Mignard D, McDermott C, Haszeldine RS, Shipton ZK. Inter—seasonal compressed—air energy storage using saline aquifers. Nat Energy 2019; 4(2):131-9.

[5] Yang CH, Wang TT, Chen HS. Theoretical and technological challenges of deep underground energy storage in China. Engineering 2023; 25:168-81.

[6] Crotogino F, Mohmeyer K—U, Scharf DR. Huntorf CAES: More than 20 Years of Successful Operation n.d.

[7] Li H, Ma HL, Liu J, Zhu SJ, Zhao K, Zheng ZY, et al. Large—scale CAES in bedded rock salt: A case study in Jiangsu Province. China. Energy 2023; 281:128271.

[8] Compressed—Air Energy Storage Technology Strategy Assessment. The U.S. Department ofEnergy; 2023. Energy 2023.

[9] Chen XH, Wang JG. Stability analysis for compressed air energy storage cavern with initial excavation damage zone in an abandoned mining tunnel. J Energy Storage 2022; 45:103725.

[10] Kim HM, Rutqvist J, Ryu DW, Choi BH, Sunwoo C, Song WK. Exploring the concept of compressed air energy storage (CAES) in lined rock Caverns at shallow depth: A modeling study of air tightness and energy balance. Appl Energy 2012; 92:653-67.

[11] Yan BQ, Qi QJ, Liu JZ, Cai MF, Li XS, Wang PT. Fracture propagation and permeability evolution mechanism of jointed rock mass in coastal mines. Rock Mech Rock Eng 2023; 56(4):2763—78.

[12] Ma Y, Rao QH, Huang DY, Liu ZL, Yi W, Li P. Gas—mechanical coupled crack initiation analysis for local air—leakage of compressed air energy storage (CAES) cavern with consideration of seepage effect. Theor Appl Fract Mech 2023; 125:103827.

[13] Wang WX, Sui WH, Faybishenko B, Stringfellow WT. Permeability variations within mining—induced fractured rock mass and its influence on groundwater inrush. Environ Earth Sci 2016; 75(4):326.

[14] Geissbühler L, Becattini V, Zanganeh G, Zavattoni S, Barbato M, Haselbacher A, et al. Pilot—scale demonstration of advanced adiabatic compressed air energy storage, Part 1: Plant description and tests with sensible thermal—energy storage. J Energy Storage 2018; 17:129-39.

[15] Hökmark H. Numerical study of the performance of tunnel plugs. Eng Geol 1998; 49(3—4):327-35.

[16] Yu XP. Research on the Deformation and Leakage Mechanism of Compressed Air Energy Storage Chambers in Abandoned Mines. Shandong university; 2024. Master’s thesis. In chinese.

[17] Li J, Chen YD, Liang WG, Zhang SL, Qiu YC. Experimental investigation on permeability and mechanical properties of cement—salt rock interface subjected to cyclic loading. Rock Mech Rock Eng 2023; 56(10):7281-99.

[18] Chen XH. Numerical Simulation Research on the Safety of Compressed Air Energy Storage Cavern in Abandoned Coal Mine. China University of Mining and Technology; 2023. Master’s thesis. In chinese.

[19] Zhu HH, Chen XY, Cai YC, Chen JF, Wang ZL. The fracture influence on the energy loss of compressed air energy storage in hard rock. Math Probl Eng 2015; 2015(1):921413.

[20] Han C. Study on the sealing performance of concrete plugs in Pressurised gas storage reservoirs under temperature and pressure alternation of cyclic injection mining. Shandong university; 2025. Master’s thesis. In chinese.

[21] Liu XY, Yang JP, Yang CH, Zhang ZY, Chen WZ. Numerical simulation on cavern support of compressed air energy storage(CAES)considering thermo—mechanical coupling effect. Energy 2023; 282:128916.

[22] Khaledi K, Mahmoudi E, Datcheva M, Schanz T. Analysis of compressed air storage Caverns in rock salt considering thermo—mechanical cyclic loading. Environ Earth Sci 2016; 75(15):1149.

[23] Wan F, Jiang ZM. Seepage and heat transfer characteristics of gas leakage under the condition of CAES air reservoir cracking. Geofluids 2021; 2021(1):5182378.

[24] Jiang ZM, Qin SZ, Tang D. Numerical study on accumulative damage characteristics of underground rock Caverns for compressed air energy storage. Chin J Geotech Eng 2020; 42(2):230—8.in Chinese.

[25] Wu D, Wang JG, Hu BW, Yang SQ. A coupled thermo—hydro—mechanical model for evaluating air leakage from an unlined compressed air energy storage cavern. Renew. Energy 2020; 146(C):907-20.

[26] Wang J, Liu X, Zhang Q, Liu X, Song Z, Feng S. Fatigue properties and damage constitutive model of salt rock based on CT scanning. Int J Min Sci Technol 2024; 34(2):245—59.

[27] Zhang B, Wang HP, Yuan L, Du QZ, Fan JG, Sui JC, Li MT. Establishment and analysis of thermo—hydro—mechanical coupling similarity criteria for compressed air energy storage process in abandoned coal mines. J China Univ Min Technol 2025; 54(4):743—53.in Chinese.

[28] Park D, Kim HM, Ryu DW, Synn JH, Song WK. Numerical study on the optimal shape of concrete plug for compressed air energy storage Caverns. Tunn Undergr Space 2011; 21(3):164-73.

[29] Hou ZS, Jin KQ, Zhang SL, Zhang HC, Jiang Y, Sun JH. Thermodynamic model for transient discharge of high—pressure hydrogen in storage tanks based on behaviors of ideal and real gases. Int J Hydrog Energy 2026; 197:152619.

[30] Wang ZQ, Li HY, Liu SY, Xu JC, Liu JR, Wang XP. Risk evaluation of CO2 leakage through fracture zone in geological storage reservoir. Fuel 2023; 342:127896.

[31] Liu W, Chen J, Jiang DY, Shi XL, Li YP, Daemen JJK, et al. Tightness and suitability evaluation of abandoned salt Caverns served as hydrocarbon energies storage under adverse geological conditions (AGC). Appl Energy 2016; 178:703—20.

[32] Bandis SC, Lumsden AC, Barton NR. Fundamentals of rock joint deformation. Int J Rock Mech Min Sci Geomech Abstr 1983; 20(6):249-68.

[33] Mitchell TM, Faulkner DR. Experimental measurements of permeability evolution during triaxial compression of initially intact crystalline rocks and implications for fluid flow in fault zones. J Geophys Res Solid Earth 2008; 113(B11):2008JB005588.

[34] Petrini C, Madonna C, Gerya T. Inversion in the permeability evolution of deforming Westerly granite near the brittle—ductile transition. Sci Rep 2021; 11(1):24027.

[35] He XP, Sinan M, Kwak H, Hoteit H. A corrected cubic law for single—phase laminar flow through rough—walled fractures. Adv Water Resour 2021; 154:103984.

[36] Yang SS, Liang MC, Yu BM, Zou MQ. Permeability model for fractal porous media with rough surfaces. Microfluid Nanofluid 2015; 18(5):1085-93.

[37] Dong C. Law and mechanism of spatio—temporal evolution for unsaturated gas—water two—phase flow in fractured sandstone. China University of Mining and Technology (Beijing); 2024. Doctoral thesis. In Chinese.

[38] Miao TJ, Yang SS, Long ZC, Yu BM. Fractal analysis of permeability of dual—porosity media embedded with random fractures. Int J Heat Mass Transf 2015; 88:814—21.

[39] Nakata M, Yamachi H, Nakayama A, Sakurai S, Shidahara T. Thermo—dynamical approach to compressed air energy storage system. Doboku Gakkai Ronbunshu 1998; 1998(610):31-42.

[40] Huang Z, Zhao K, Li XZ, Zhong W, Wu Y. Numerical characterization of groundwater flow and fracture—induced water inrush in tunnels. Tunn Undergr Space Technol 2021; 116:104119.

[41] Nelson RA. 5 — Analysis Procedures in Fractured Reservoirs. In: Nelson RA, editor. Geol. Anal. Nat. Fract. Reserv. Second Ed., Woburn: Gulf Professional Publishing; 2001, p. 223—53.

[42] Lee SH, Lough MF, Jensen CL. Hierarchical modeling of flow in naturally fractured formations with multiple length scales. Water Resour Res 2001; 37(3):443-55.

[43] Lu YL, Elsworth D, Wang LG. Microcrack—based coupled damage and flow modeling of fracturing evolution in permeable brittle rocks. Comput Geotech 2013; 49:226-44.

[44] Wu ZK, Li XZ, Xiao HM, Liu XW, Lin W, Rao Y, et al. The establishment and evaluation method of artificial microcracks in rocks. Energies 2021; 14(10):2780.