Experimental study on stress-permeability evolution of rocks under complex mining-induced loading: Insights into water inrush risk in floor strata

Abstract

Water inrush hazards from the floor strata of longwall workingface are commonly encountered in North China coalfields, which essentially result from the evolution of permeability in the floor rock under complex mining-induced stress conditions. Current research rarely addresses the evolution of rock permeability under such complex stress paths. Describing this evolution using only one stress parameter, such as effective stress, deviatoric stress, axial stress, or confining stress, is highly challenging. In this study, we developed a laboratory loading scheme that simulates mining-induced stress evolution. Hydro-mechanical experiments were conducted to investigate the evolution of rock permeability under mining stress. The mechanism on the change of stress-permeability relationships in mining-disturbed rock is revealed, supporting to the analysis of management strategies for floor water-inrush disasters. The results show that rock permeability evolves through four stages, including rapid decline, gradual fluctuation, sharp increase, and slow attenuation. 1–2 permeability surges occurred during mining-stress loading, closely linked to the emergence and reversal of deviatoric stress in magnitude and direction. With the first permeability surge, the deviatoric stress within the mudstone reached approximately 1.7 MPa, whereas that of the sandstone was about 1 MPa. The second permeability surge in the mudstone corresponded to the secondary rotation of the principal stress direction. CT and ultrasonic tests suggested an increase in microcracks in both rocks during the first permeability surge. However, the deviatoric stress-permeability plot before and after mining indicated that the fracture of mudstone sample changed significantly, while that of the sandstone remained unchanged. The permeability surges observed at different stages are interpreted as resulting from shear-induced reopening of pre-existing fractures and the formation of new shear-failure fractures. A stress-permeability model jointly governed by effective mean stress and deviatoric stress was established. Furthermore, two strategies are proposed for the floor water-inrush disasters prevention, (i) timely backfilling to reduce deviatoric stress, (ii) grouting after the first permeability surge. This work provides insights into stress-seepage behavior in rocks under complex stress evolution and offers new perspectives for identifying potential water inrush pathways in the floor strata of coal seam during longwall mining.

Keywords

Stress / Permeability / Mining-disturbed / Hydro-mechanical tests / Workingface floor

CRediT authorship contribution statement

Jinghua Li: Writing – original draft, Methodology, Investigation, Conceptualization. Guichen Li: Supervision, Project administration, Funding acquisition, Conceptualization. Lei Zhang: Funding acquisition, Conceptualization. Kaijun Miao: Methodology, Investigation. Xiaofang Wo: Visualization, Software, Methodology. Yingqi Yuan: Visualization. Zhongwei Chen: Writing – review & editing, Supervision, Conceptualization.

Declaration of competing interest

The authors declare that they have no known competing financial interests or personal relationships that could have appeared to influence the work reported in this paper.

Acknowledgements

This work was supported by the National Natural Science Foundation of China (Nos. U22A20165 and 52474156), the Key Research and Development Program of Xinjiang Uyghur Autonomous Region (No. 2023B01010-1), and the China Scholarship Council (No. 202406420054).

References

[1] Adhikary DP, Guo H . Modelling of longwall mining—induced strata permeability change. Rock Mech Rock Eng 2015; 48(1): 345-59.

[2] Gao MZ, Xie J, Guo J, Lu YQ, He ZQ, Li C . Fractal evolution and connectivity characteristics of mining—induced crack networks in coal masses at different depths. Geomech Geophys Geo Energy Geo Resour 2021; 7(1): 9.

[3] Miao KJ, Tu SH, Tu HS, Liu X, Li WL, Zhao HB, Tang L, Ma JY, Li Y . Research on fractal evolution characteristics and safe mining technology of overburden fissures under gully water body. Fractal Fract 2022; 6(9): 486.

[4] Yan T, Zhu CQ, Li QF, Wu H, Peng YJ . Investigating fracture evolution mechanisms in thick coal seam mining under upper hard and lower soft overburden: A case study. Sci Rep 2025; 15: 11358.

[5] Zhang BY, He QY, Lin ZB, Li ZH . Experimental study on the flow behaviour of water—sand mixtures in fractured rock specimens. Int J Min Sci Technol 2021; 31(3): 377—85.

[6] Ali A, Strezov V, Davies P, Wright I . Environmental impact of coal mining and coal seam gas production on surface water quality in the Sydney basin, Australia. Environ Monit Assess 2017; 189(8): 408.

[7] Yuan L, Wang E, Ma Y, Liu Y, Li X . Research progress of coal and rock dynamic disasters and scientific and technological problems in China. J China Coal Soc 2023; 48(5): 1825—45. in Chinese.

[8] Meng SH, Wu Q, Zeng YF, Gu LY . Enhancing mine groundwater system prediction: Full—process simulation of mining—induced spatio—temporal variations in hydraulic conductivities via modularized modeling. Int J Min Sci Technol 2024; 34(12): 1625—42.

[9] He JH, Li WP, Fan KF, Qiao W, Wang QQ, Li LN . A method for predicting the water—flowing fractured zone height based on an improved key stratum theory. Int J Min Sci Technol 2023; 33(1): 61-71.

[10] Cao ZD, Gu QX, Huang Z, Fu JJ . Risk assessment of fault water inrush during deep mining. Int J Min Sci Technol 2022; 32(2): 423—34.

[11] Crandall D, Moore J, Gill M, Stadelman M . CT scanning and flow measurements of shale fractures after multiple shearing events. Int J Rock Mech Min Sci 2017; 100: 177-87.

[12] Zhu N, Yu QC . Temporal evolution of fracture transport properties of fractured shales during long—term stress compaction. Eng Geol 2024; 339: 107663.

[13] Wang HC, Fu XH, Jian K, Li T, Luo PP . Changes in coal pore structure and permeability during N₂ injection. J Nat Gas Sci Eng 2015; 27: 1234—41.

[14] Kozhevnikov EV, Turbakov MS, Riabokon EP, Gladkikh EA . Apparent permeability evolution due to colloid migration under cyclic confining pressure: On the example of porous limestone. Transp Porous Medium 2024; 151(2): 263-86.

[15] Xie YT, Liu HM, Zhang KH, Jia WH, Li J, Meng XY . Dynamic evaluation of microscopic damage and fluid flow behavior in reservoir shale under deviatoric stress. Energy 2023; 283: 128391.

[16] Fan GW, Chen MW, Zhang DS, Wang Z, Zhang SZ, Zhang CG, Li QZ, Cao BB . Experimental study on the permeability of weakly cemented rock under different stress states in triaxial compression tests. Geofluids 2018; 2018(1): 9035654.

[17] Zhou P, Ma HC, Wang JP, Qian JZ . Experimental and theoretical study of seepage models under confining pressure for a single rock fracture. KSCE J Civ Eng 2024; 28(5): 1799-808.

[18] Jia HY, Zou DL . Study on the permeability evolution model of mining—disturbed coal. Geofluids 2021; 2021(1): 1810915.

[19] Lu HF, Shan N, Zhang YK, Liang XY . Effect of strain—dependent hydraulic conductivity of coal rock on groundwater inrush in mining. Geofluids 2020; 2020(1): 8887392.

[20] Liu C, Zhang JH, Wu SW, Qi JH, Yu BC, Wang L . Experimental study on permeability evolution of deep high—stressed coal under major horizontal stress unloading paths. Int J Min Sci Technol 2024; 34(11): 1495-508.

[21] Zhang L, Huang MQ, Xue JH, Li MX, Li JH . Repetitive mining stress and pore pressure effects on permeability and pore pressure sensitivity of bituminous coal. Nat Resour Res 2021; 30(6): 4457—76.

[22] Zeng SP, Zhang L, Luo L, Ye ZW, Wang C . Permeability evolution of anthracite subjected to liquid nitrogen treatment under repeated loading—unloading conditions. Nat Resour Res 2023; 32(6): 2753—67.

[23] Ishibashi T, Elsworth D, Fang Y, Riviere J, Madara B, Asanuma H, Watanabe N, Marone C . Friction—stability—permeability evolution of a fracture in granite. Water Resour Res 2018; 54(12): 9901—18.

[24] Min KB, Rutqvist J, Tsang CF, Jing LR . Stress—dependent permeability of fractured rock masses: A numerical study. Int J Rock Mech Min Sci 2004; 41(7): 1191-210.

[25] Zhu WL, Wong TF . The transition from brittle faulting to cataclastic flow: Permeability evolution. J Geophys Res Solid Earth 1997; 102(B2): 3027-41.

[26] Scuderi MM, Kitajima H, Carpenter BM, Saffer DM, Marone C . Evolution of permeability across the transition from brittle failure to cataclastic flow in porous siltstone. Geochem Geophys Geosyst 2015; 16(9): 2980—93.

[27] Zhang JL, Zhou XH, Liu XR, Fang L, Liu YY, Wang Y . Deformation and permeability of fractured rocks using fluid—solid coupling under loading—unloading conditions. J Rock Mech Geotech Eng 2025; 17(8): 4889-907.

[28] Liu Y, Liu SL, Huo ZC, Sun K, Wang T, Li WG . Failure characteristics of coal seam floor and risk assessment of water inrush caused by underground coal mining. Energy Explor Exploit 2023; 41(2): 677-95.

[29] Dong S, Liu Z, Wang H . Mechanism analysis of stope floor water inrush based on principal stress state transition. J Min Saftey Eng 2023; 40(4): 691-703. in Chinese.

[30] Zhao YL, Tang JZ, Chen Y, Zhang LY, Wang WJ, Wan W, Liao JP . Hydromechanical coupling tests for mechanical and permeability characteristics of fractured limestone in complete stress—strain process. Environ Earth Sci 2016; 76(1): 24.

[31] Chen YL, Hao XJ, Xue DJ, Li Z, Ma XR . Creep behavior and permeability evolution of coal pillar dam for underground water reservoir. Int J Coal Sci Technol 2023; 10(1): 11.

[32] Liu XS, Lin YS, Kong J . Study of hydro—mechanical coupling of fractured rock masses considering unloading effect. Rock Soil Mech 2007; 28: 192-6. in Chinese.

[33] Peng K, Shi SW, Zou QL, Zhang YJ, Tan GW . Gas permeability characteristics and energy evolution laws of gas—bearing coal under multi—level stress paths. Nat Resour Res 2020; 29(5): 3137—58.

[34] Liu JF, Xu XM, Zhang YH, Wang ZH, Arif M, Wang Q . Understanding the irreversible evolution of coal permeability under cyclic axial deviatoric stress. Nat Resour Res 2024; 33(2): 887-905.

[35] Ma HC, Zhou P, Qian JZ, Deng YP, Shi YF, Lian B . Evolution of gas seepage properties in shale fractures under different confining pressure and temperature conditions. Int Commun Heat Mass Transf 2025; 165: 109039.

[36] Wang JP, Ma HC, Qian JZ, Feng PC, Tan XH, Ma L . Experimental and theoretical study on the seepage mechanism characteristics coupling with confining pressure. Eng Geol 2021; 291: 106224.

[37] Li MH, Yin GZ, Xu J, Cao J, Song ZL . Permeability evolution of shale under anisotropic true triaxial stress conditions. Int J Coal Geol 2016; 165: 142—8.

[38] Liu YB, Li MH, Yin GZ, Zhang DM, Deng BZ . Permeability evolution of anthracite coal considering true triaxial stress conditions and structural anisotropy. J Nat Gas Sci Eng 2018; 52: 492-506.

[39] Lu J, Yin GZ, Li X, Li MH, Zhang DM, Zhang WZ, Kang QR . Deformation and CO₂ gas permeability response of sandstone to mean and deviatoric stress variations under true triaxial stress conditions . Tunn Undergr Space Technol 2019; 84: 259-72.

[40] Huang MQ, Zhang L, Zhang C, Chen S . Characteristics of permeability changes in bituminous coal under conditions of stress variation due to repeated mining activities. Nat Resour Res 2020; 29(3): 1687-704.

[41] Hu K, Cao Y . Fundamental research on floor water inrush and its prevention principles in mining working faces. J Geol Miner Resour Northern China 1997; 12(3): 203-25. in Chinese.

[42] Gao Z, Meng X, Zheng Z . Research on evolution rules of coal seam floor crack under mining stress effect. Chinese J Undergr Space Eng 2016; 12(1): 90—5. in Chinese.

[43] Li C, Cui C, Lei G, Zuo J, Yu X, He T, Li X, Du W . Tensile fracture mechanism of rock mass induced by the unloading—seeping of confining pressure in deep coal mining. J China Coal Soc 2022; 47(8): 3069—82. in Chinese.

[44] Lang PS, Paluszny A, Nejati M, Zimmerman RW . Relationship between the orientation of maximum permeability and intermediate principal stress in fractured rocks. Water Resour Res 2018; 54(11): 8734—55.

[45] Li G, Li J, Sun Y, Yang S . Advance of multi—scale study on both analytic models and water—rock interaction characteristics of mudstone. J China Coal Soc 2022; 47(3): 1138-54. in Chinese.

[46] Ma D, Duan HY, Zhang JX, Bai HB . A state—of—the—art review on rock seepage mechanism of water inrush disaster in coal mines. Int J Coal Sci Technol 2022; 9(1): 50.

[47] Ma TS, Yang CH, Chen P, Wang XD, Guo YT . On the damage constitutive model for hydrated shale using CT scanning technology. J Nat Gas Sci Eng 2016; 28: 204—14.

[48] Zhang L, Ye ZW, Huang MQ, Zhang C . Characteristics of bituminous coal permeability response to the pore pressure and effective shear stress in the Huaibei Coalfield in China. Geofluids 2019; 2019: 5489051.

[49] Ma HC, Wang J, Qian JZ, Xu Y, Xie CL, Ma L . Micro—scale shale fracture wear under normal stress: 3D point cloud—coupled experiments/simulations study. Mater Des 2025; 259: 114690.

[50] Ma K, Sun XY, Tang CA, Yuan FZ, Wang SJ, Chen T . Floor water inrush analysis based on mechanical failure characters and microseismic monitoring. Tunn Undergr Space Technol 2021; 108: 103698.