Thermal management matters in photovoltaic-electrocatalysis for solar hydrogen production

Abstract

Photovoltaic-electrolysis (PV-EC) system currently exhibits the highest solar to hydrogen conversion efficiency (STH) among various technical routes. This perspective shifts the focus from the materials exploration in photovoltaics and electrolysis to the critical aspect of thermal management in a PV-EC system. Initially, the theoretical basis that elucidates the relationships between temperature and the performance of both photovoltaics and electrolyzers are presented. Following that, the impact of thermal management on the performance of PV-EC for solar hydrogen production is experimentally demonstrated by designing variables-controlling experiments. It is observed that while utilizing identical PV and EC cells under varying thermal conditions, the highest STH can reach 22.20%, whilst the lowest is only 15.61%. This variation underscores the significance of thermal management in optimizing PV-EC systems. Finally, increased efforts to enhancing heat transfer and optimizing heat distribution are proposed, thus facilitating the design of more efficient PV-EC systems with minimized thermal energy losses.

Keywords

device design / photovoltaic-electrolysis / solar to hydrogen / thermal management / water electrolyzer

References

[1] Lewis NS. Research opportunities to advance solar energy utilization. Science. 2016; 351(6271):aad1920.

[2] Tuller HL. Solar to fuels conversion technologies: a perspective. Mater Renew Sustain Energy. 2017; 6(1): 3.

[3] Hosseini SE, Wahid MA. Hydrogen production from renewable and sustainable energy resources: promising green energy carrier for clean development. Renew Sustain Energy Rev. 2016; 57: 850-866.

[4] Dutta S. Review on solar hydrogen: its prospects and limitations. Energy Fuels. 2021; 35(15): 11613-11639.

[5] Song H, Luo S, Huang H, Deng B, Ye J. Solar-driven hydrogen production: recent advances, challenges, and future perspectives. ACS Energy Lett. 2022; 7(3): 1043-1065.

[6] Sharma A, Longden T, Catchpole K, Beck FJ. Comparative techno-economic analysis of different PV-assisted direct solar hydrogen generation systems. Energy Environ Sci. 2023; 16(10): 4486-4501.

[7] Zhao D, Wang Y, Dong C-L, et al. Boron-doped nitrogen-deficient carbon nitride-based Z-scheme heterostructures for photocatalytic overall water splitting. Nat Energy. 2021; 6(4): 388-397.

[8] Kim JH, Hansora D, Sharma P, Jang J-W, Lee JS. Toward practical solar hydrogen production - an artificial photosynthetic leaf-to-farm challenge. Chem Soc Rev. 2019; 48(7): 1908-1971.

[9] Chang WJ, Lee K-H, Ha H, et al. Design principle and loss engineering for photovoltaic-electrolysis cell system. ACS Omega. 2017; 2(3): 1009-1018.

[10] Sriramagiri GM, Luc W, Jiao F, Ayers K, Dobson KD, Hegedus SS. Computation and assessment of solar electrolyzer field performance: comparing coupling strategies. Sustain Energy Fuels. 2019; 3(2): 422-430.

[11] . https://www.nrel.gov/pv/cell-efficiency.html. 2024.

[12] Li Z. Prospects of photovoltaic technology. Engineering. 2023; 21: 28-31.

[13] Yu F, Zhou H, Huang Y, et al. High-performance bifunctional porous non-noble metal phosphide catalyst for overall water splitting. Nat Commun. 2018; 9(1):2551.

[14] Lv F, Feng J, Wang K, et al. Iridium-tungsten alloy nanodendrites as pH-universal water-splitting electrocatalysts. ACS Cent Sci. 2018; 4(9): 1244-1252.

[15] Jacobsson TJ, Fjällström V, Sahlberg M, Edoff M, Edvinsson T. A monolithic device for solar water splitting based on series interconnected thin film absorbers reaching over 10% solar-to-hydrogen efficiency. Energy Environ Sci. 2013; 6(12): 3676-3683.

[16] Jia J, Seitz LC, Benck JD, et al. Solar water splitting by photovoltaic-electrolysis with a solar-to-hydrogen efficiency over 30. Nat Commun. 2016; 7(1):13237.

[17] Luo J, Im J-H, Mayer MT, et al. Water photolysis at 12.3% efficiency via perovskite photovoltaics and Earth-abundant catalysts. Science. 2014; 345(6204): 1593-1596.

[18] Gao J, Sahli F, Liu C, et al. Solar water splitting with perovskite/silicon tandem cell and TiC-supported Pt nanocluster electrocatalyst. Joule. 2019; 3(12): 2930-2941.

[19] Liu R-T, Xu Z-L, Li F-M, et al. Recent advances in proton exchange membrane water electrolysis. Chem Soc Rev. 2023; 52(16): 5652-5683.

[20] Li Z, Fang S, Sun H, Chung R-J, Fang X, He J-H. Solar hydrogen. Adv Energy Mater. 2023; 13(8):2203019.

[21] Bonke SA, Wiechen M, MacFarlane DR, Spiccia L. Renewable fuels from concentrated solar power: towards practical artificial photosynthesis. Energy Environ Sci. 2015; 8(9): 2791-2796.

[22] Shaker LM, Al-Amiery AA, Hanoon MM, Al-Azzawi WK, Kadhum AAH. Examining the influence of thermal effects on solar cells: a comprehensive review. Sustai Energy Res. 2024; 11(1): 6.

[23] Vaillon R, Dupré O, Cal RB, Calaf M. Pathways for mitigating thermal losses in solar photovoltaics. Sci Rep. 2018; 8(1):13163.

[24] Adibi T, Sojoudi A, Saha SC. Modeling of thermal performance of a commercial alkaline electrolyzer supplied with various electrical currents. Int J Thermofluids. 2022; 13:100126.

[25] Rashidi S, Karimi N, Sunden B, Kim KC, Olabi AG, Mahian O. Progress and challenges on the thermal management of electrochemical energy conversion and storage technologies: fuel cells, electrolysers, and supercapacitors. Prog Energy Combust Sci. 2022; 88:100966.

[26] Kölbach M, Rehfeld K, May MM. Efficiency gains for thermally coupled solar hydrogen production in extreme cold. Energy Environ Sci. 2021; 14(8): 4410-4417.

[27] Varshni YP. Temperature dependence of the energy gap in semiconductors. Physica. 1967; 34(1): 149-154.

[28] Green MA. Solar cell fill factors: general graph and empirical expressions. Solid State Electron. 1981; 24(8): 788-789.

[29] Green MA. Solar Cells: Operating Principles, Technology, and System Applications. Prentice-Hall, Inc.; 1982.

[30] . https://www.pveducation.org/pvcdrom/solar-cell-operation/effect-of-temperature

[31] Bonanno M, Müller K, Bensmann B, et al. Review and prospects of PEM water electrolysis at elevated temperature operation. Adv Mater Technol. 2024; 9(2):2300281.

[32] Sun C, Zou Y, Qin C, Zhang B, Wu X. Temperature effect of photovoltaic cells: a review. Adv Compos Hybrid Mater. 2022; 5(4): 2675-2699.

[33] Kothari R, Buddhi D, Sawhney RL. Studies on the effect of temperature of the electrolytes on the rate of production of hydrogen. Int J Hydrogen Energy. 2005; 30(3): 261-263.

[34] Incropera FP, DeWitt DP, Bergman TL, Lavine AS. Fundamentals of Heat and Mass Transfer. Vol. 6. Wiley New York; 1996.

[35] Ya C, Ghajar A, Ma H. Heat and Mass Transfer Fundamentals and Applications. McGraw-Hill; 2015.

[36] Togun H, Sultan HS, Mohammed HI, et al. A critical review on phase change materials (PCM) based heat exchanger: different hybrid techniques for the enhancement. J Energy Storage. 2024; 79:109840.

[37] Harris M, Wu H, Zhang W, Angelopoulou A. Overview of recent trends in microchannels for heat transfer and thermal management applications. Chem Eng Process - Process Intensification. 2022; 181:109155.

[38] Kakaç S, Bergles AE, Mayinger F, Yüncü H. Heat Transfer Enhancement of Heat Exchangers. Vol. 355. Springer Science and Business Media; 2013.

RIGHTS & PERMISSIONS

2024 The Author(s). EcoEnergy published by John Wiley & Sons Australia, Ltd on behalf of China Chemical Safety Association.