Valorization of biogas digestate through hydrothermal humification for nitrogen-enriched artificial humic acid production

Abstract

Biogas digestate (BD), a nutrient-rich and low-cost carbon source, can be converted into artificial humic acid (AHA) through hydrothermal humification (HTH). However, the process is often constrained by low efficiency and inconsistent product quality. In this study, the effects of different reaction media, including biogas slurry (BS) and deionized water, on the properties of AHA derived from BD at various temperatures (180–260 °C) were investigated. The results showed that BS addition increased both AHA yield and nitrogen content, with a maximum AHA selectivity of 40.16% in the hydrochar at 220 °C. FT-ICR-MS, 3D-EEM, and solid-state ¹³C NMR analyses indicated that lignin in BD was the main precursor for aromatic AHA synthesis in the deionized water system. When BS was introduced into the HTH process, lignin depolymerization and nitrogen-involving Maillard reactions were likely enhanced, resulting in greater nitrogen incorporation into AHA, with a maximum of 26.02 mg N retained in AHA at 220 °C. This enhanced nitrogen retention was associated with the formation of reactive intermediates and subsequent incorporation of nitrogen into more stable heterocyclic structures. This study provides a sustainable pathway for the efficient conversion of biogas plant residues into nutrient- and humic-rich products with potential as soil amendments.

Keywords

Hydrothermal humification / Biogas digestate / Reaction medium / Nitrogen-rich artificial humic acid / Hydrochar

References

[1] Ahmad F, Silva EL, Varesche MBA. Hydrothermal processing of biomass for anaerobic digestion – a review. Renew Sustain Energy Rev, 2018, 98: 108-124.

[2] Basar IA, Liu H, Carrere H, et al. A review on key design and operational parameters to optimize and develop hydrothermal liquefaction of biomass for biorefinery applications. Green Chem, 2021, 23: 1404-1446.

[3] Cai S, Zhang Y, Hu A, et al. Dissolved organic matter transformation mechanisms and process optimization of wastewater sludge hydrothermal humification treatment for producing plant biostimulants. Water Res, 2023, 235. 119910

[4] Cao Z, Jung D, Olszewski MP, et al. Hydrothermal carbonization of biogas digestate: effect of digestate origin and process conditions. Waste Manag, 2019, 100: 138-150.

[5] Celletti S, Bergamo A, Benedetti V, et al. Phytotoxicity of hydrochars obtained by hydrothermal carbonization of manure-based digestate. J Environ Manage, 2021, 280. 111635

[6] Chen P, Yang R, Pei Y, et al. Hydrothermal synthesis of similar mineral-sourced humic acid from food waste and the role of protein. Sci Total Environ, 2022, 828. 154440

[7] Daer D, Luo L, Shang Y, et al. Co-hydrothermal carbonization of waste biomass and phosphate rock: promoted carbon sequestration and enhanced phosphorus bioavailability. Biochar, 2024, 6. 70

[8] Deng F, Cao Z, Luo Y, et al. Production of artificial humic acid from corn straw acid hydrolysis residue with biogas slurry impregnation for fertilizer application. J Environ Manage, 2023, 345. 118845

[9] Devi P, Eskicioglu C. Effects of biochar on anaerobic digestion: a review. Environ Chem Lett, 2024, 22: 2845-2886.

[10] Fan Y, Hornung U, Dahmen N, et al. Hydrothermal liquefaction of protein-containing biomass: study of model compounds for Maillard reactions. Biomass Convers Biorefin, 2018, 8: 909-923.

[11] Gao J, Li L, Yuan S, et al. The neglected effects of polysaccharide transformation on sludge humification during anaerobic digestion with thermal hydrolysis pretreatment. Water Res, 2022, 226. 119249

[12] Guo X, Liu H, Wu S. Humic substances developed during organic waste composting: formation mechanisms, structural properties, and agronomic functions. Sci Total Environ, 2019, 662: 501-510.

[13] MHB Hayes RS Swift (2020) Vindication of Humic Substances as a Key Component of Organic Matter in Soil and Water https://doi.org/10.1016/bs.agron.2020.05.001

[14] Hu J, Liu C, Zhang W, et al. Decomposing the molecular complexity and transformation of dissolved organic matter for innovative anaerobic bioprocessing. Nat Commun, 2025.

[15] Jiang H, Deng F, Luo Y, et al. Hydrothermal carbonization of corn straw in biogas slurry. J Clean Prod, 2022, 353. 131682

[16] Ke L, Liu X, Du B, et al. Component analysis and risk assessment of biogas slurry from biogas plants. Chin J Chem Eng, 2022, 44: 182-191.

[17] Kim J, Oh J, Tsang YF, et al. CO2-assisted catalytic pyrolysis of digestate with steel slag. Energy (Oxf), 2020, 191. 116529

[18] Lehmann J, Bossio DA, Kogel-Knabner I, et al. The concept and future prospects of soil health. Nat Rev Earth Environ, 2020, 1: 544-553.

[19] Lei T, Su J, Chang L, et al. Artificial humic acid produced from wet distillers grains in a microwave-assisted hydrothermal process: physicochemical characteristics and stimulation to plant growth. Chemosphere, 2024, 364. 142979

[20] Li C, Cai R. Preparation of solid organic fertilizer by co-hydrothermal carbonization of peanut residue and corn cob: a study on nutrient conversion. Sci Total Environ, 2022, 838. 155867

[21] Liu T, Zhou X, Li Z, et al. Effects of liquid digestate pretreatment on biogas production for anaerobic digestion of wheat straw. Bioresour Technol, 2019, 280: 345-351.

[22] Liu Z, Su J, Yao Z, et al. Enhancing humic acids production from cornstalk under fast hydrothermal conditions: insights into new pathways of skeleton self-polymerization and branch growth. Bioresour Technol, 2024, 406. 131020

[23] Liu W, Xia R, Li G, et al. Three-dimensional analysis of foulant distribution in ultrafiltration membrane treating biogas slurry. J Membr Sci, 2025, 735. 124571

[24] Lu J, Cheng M, Zhao C, et al. Application of lignin in preparation of slow-release fertilizer: current status and future perspectives. Ind Crops Prod, 2022, 176. 114267

[25] Marzban N, Libra JA, Rotter VS, et al. Maximizing the value of liquid products and minimizing carbon loss in hydrothermal processing of biomass: an evolution from carbonization to humification. Biochar, 2024, 6. 44

[26] Mikusińska J, Szkadłubowicz K, Prus Z, et al. Fuel properties characterization of hydrochars derived from agricultural digestate. Renew Energy, 2025, 244. 122639

[27] Nagel E, Zhang C. Hydrothermal decomposition of a lignin dimer under neutral and basic conditions: a mechanism study. Ind Eng Chem Res, 2019, 58: 18866-18880.

[28] Shao Y, Bao M, Huo W, et al. From biomass to humic acid: is there an accelerated way to go?. Chem Eng J, 2023, 452. 139172

[29] Shao Y, Huo W, Ye R, et al. Hydrothermal humification of lignocellulosic components: who is doing what?. Chem Eng J, 2023, 457. 141180

[30] Song S, Zhang T, Shi Z, et al. Biogas slurry impregnation-driven hydrothermal synthesis of artificial humic acid: mechanistic insights and agricultural implications. Bioresour Technol, 2025, 439. 133279

[31] Su X, Zhang R, Cao H, et al. Adsorption of humic acid from different organic solid waste compost to phenanthrene, is fluorescence excitation or quenching?. Environ Pollut, 2024, 347. 123712

[32] Wang R, Zhou B, Wang Z. Study on the preparation and application of lignin-derived polycarboxylic acids. J Chem, 2019.

[33] Wang R, Lin Z, Meng S, et al. Effect of lignocellulosic components on the hydrothermal carbonization reaction pathway and product properties of protein. Energy (Oxf), 2022, 259. 125063

[34] Wang X, Zhang D, Wang F, et al. Effects of biogas slurry on hydrothermal carbonization of digestate: synergistic valorization of hydrochars and aqueous phase. J Environ Manage, 2024, 362. 121317

[35] Wang D, Liu Z, Su J, et al. Mechanistic insights into nitrogen-mediated carbon transformation during hydrothermal humification for the synthesis of nutrient-enriched artificial humic acids. Bioresour Technol, 2025, 437. 133100

[36] Wu B, Berg SM, Remucal CK, et al. Evolution of N-containing compounds during hydrothermal liquefaction of sewage sludge. ACS Sustain Chem Eng, 2020, 8: 18303-18313.

[37] Xu Z, Song H, Zhang S, et al. Co-hydrothermal carbonization of digested sewage sludge and cow dung biogas residue: investigation of the reaction characteristics. Energy (Oxf), 2019, 187. 115972

[38] Xu M, Chen P, Wang J, et al. Oxygen-promoted low-temperature hydrothermal conversion of Chinese medicinal herbal residues into humic acids. Carbon Neutr, 2025.

[39] Zhang D, Wang F, Shen X, et al. Comparison study on fuel properties of hydrochars produced from corn stalk and corn stalk digestate. Energy (Oxf), 2018, 165: 527-536.

[40] Zhang C, Wang X, Shao M, et al. Synthesis of nitrogen-enriched hydrochar via co-hydrothermal reaction of liquid digestate and corn stalk. Sci Total Environ, 2022, 836. 155572

[41] Zhou X, Li J, Zhang J, et al. Bioaugmentation mechanism on humic acid formation during composting of food waste. Sci Total Environ, 2022, 830. 154783

[42] Zhu Y, Cao Y, Fu B, et al. Waste milk humification product can be used as a slow release nano-fertilizer. Nat Commun, 2024, 15: 128.

Funding

Innovation Program of Chinese Academy of Agricultural Sciences(CAAS-CSGLCA-202401)

The Agricultural Science and Technology Innovation Program(ASTIP)

National Natural Science Foundation of China(32301726)

Rights & permissions

The Author(s)