Co-transport of contaminants by disintegrated and residual superfine particles in biocarbon-based adsorbents

Abstract

Activated carbon (AC) is widely used in water and wastewater treatment, while biochar (BC) is emerging as a cost-effective and environmentally sustainable alternative. However, the release of superfine AC/BC particles may impair treated-water quality and facilitate contaminant transport. This study investigated residual superfine particles and particle-associated contaminant transport in fixed-bed filters and stirred-tank suspensions followed by sequential coarse-sand, fine-sand, 0.45 μm membrane, and 0.02 μm membrane filtration. Particle characterization revealed apparent size-distribution peaks at 5 μm, 0.5–1 μm, and 100–200 nm. Lead (Pb), used as a tracer contaminant, was detected on residual AC/BC particles. Quantitative fractionation combined with acid digestion and ICP-OES showed that particle-bound Pb accounted for 84.5–90.2% of total Pb in fine-sand filtrates. Pb-bearing particles in the 0.02–0.45 μm fraction also remained after 0.45 μm membrane filtration. The apparent 5 μm fraction is more plausibly attributed to secondary aggregation of nanoscale and submicrometer particles during filtration, sample handling, or measurement than to direct passage of intact 5 μm particles through the membrane. These findings identify particle-facilitated transport as a potentially overlooked pathway in post-filtration systems, and demonstrate the need to evaluate both dissolved and particle-associated contaminants when assessing treatment performance.

Keywords

Biochar / Activated carbon / Water treatment / Co-transport / Post-filtration

Highlight

•	Residual superfine (< 5 μm) AC/BC particles occurred in fixed-bed effluents and stirred-tank suspensions.
•	Particle-size distributions showed apparent peaks at 5 μm, 0.5–1 μm, and 100–200 nm after post-filtration.
•	Most Pb in fine-sand filtrates was associated with residual carbonaceous particles.
•	Pb-bearing particles in the 0.02–0.45 μm fraction remained after 0.45 μm membrane filtration.

References

[1] Bamdad H, Papari S, MacQuarrie S, Hawboldt KStudy of surface heterogeneity and nitrogen functionalizing of biochars: molecular modeling approach. Carbon, 2021, 171: 161-170.

[2] Cerato A, Lutenegger ADetermination of surface area of fine-grained soils by the ethylene glycol monoethyl ether (EGME) method. Geotech Test J, 2002, 25(3): 315-321.

[3] Chai WS, Cheun JY, Kumar PS, Mubashir M, Majeed Z, Banat F, Ho S-H, Show PLA review on conventional and novel materials towards heavy metal adsorption in wastewater treatment application. J Clean Prod, 2021, 296: 126589.

[4] Cui L, Wang W, Quan G, Wang H, Hina K, Hussain Q, Liu Y, Yan JBiochar-induced charosphere microenvironment modulates soil cadmium bioavailability and wheat uptake. Sustain Carbon Mater, 2026

[5] Dalahmeh SS, Alziq N, Ahrens LPotential of biochar filters for onsite wastewater treatment: effects of active and inactive biofilms on adsorption of per- and polyfluoroalkyl substances in laboratory column experiments. Environ Pollut, 2019, 247155-164.

[6] Dargahi A, Hasani K, Mokhtari SA, Vosoughi M, Moradi M, Vaziri YHighly effective degradation of 2,4-Dichlorophenoxyacetic acid herbicide in a three-dimensional sono-electro-Fenton (3D/SEF) system using powder activated carbon (PAC)/Fe₃O₄ as magnetic particle electrode. J Environ Chem Eng, 2021, 9(5): 105889.

[7] Flegal AR, Scelfo GMCaballero BLead | properties and determination. Encyclopedia of food sciences and nutrition (second edition), 2003, Oxford: Academic Press, 3477-3482.

[8] Freundlich HÜber die Adsorption in Lösungen. Z Phys Chem, 1907, 57U(1): 385-470.

[9] Fundneider T, Acevedo Alonso V, Abbt-Braun G, Wick A, Albrecht D, Lackner SEmpty bed contact time: the key for micropollutant removal in activated carbon filters. Water Res, 2021, 191: 116765.

[10] Gao T, Shi W, Zhao M, Huang Z, Liu X, Ruan WPreparation of spiramycin fermentation residue derived biochar for effective adsorption of spiramycin from wastewater. Chemosphere, 2022, 296133902.

[11] Gao F, Li J, Yang C, Zhang W, Huang H, Peng Z, Gong TAdvances on research of H2S removal by deep eutectic solvents as green solvent. Nat Gas Ind B, 2025, 12(1): 26-36.

[12] Gutierrez M, Grillini V, Mutavdzic Pavlovic D, Verlicchi PActivated carbon coupled with advanced biological wastewater treatment: A review of the enhancement in micropollutant removal. Sci Total Environ, 2021, 790148050.

[13] Hameed R, Lei C, Fang J, Lin DCo-transport of biochar colloids with organic contaminants in soil column. Environ Sci Pollut Res, 2021, 28(2): 1574-1586.

[14] Ho YS, McKay GPseudo-second order model for sorption processes. Process Biochem, 1999, 34(5): 451-465.

[15] Inyang M, Dickenson EThe potential role of biochar in the removal of organic and microbial contaminants from potable and reuse water: a review. Chemosphere, 2015, 134232-240.

[16] Inyang MI, Gao B, Yao Y, Xue Y, Zimmerman A, Mosa A, Pullammanappallil P, Ok YS, Cao XA review of biochar as a low-cost adsorbent for aqueous heavy metal removal. Crit Rev Environ Sci Technol, 2015, 46(4): 406-433.

[17] Jain M, Khan SA, Pandey A, Pant KK, Ziora ZM, Blaskovich MATInstructive analysis of engineered carbon materials for potential application in water and wastewater treatment. Sci Total Environ, 2021, 793: 148583.

[18] Kah M, Sigmund G, Xiao F, Hofmann TSorption of ionizable and ionic organic compounds to biochar, activated carbon and other carbonaceous materials. Water Res, 2017, 124673-692.

[19] Kawasaki N, Matsushige K, Komatsu K, Kohzu A, Nara FW, Ogishi F, Yahata M, Mikami H, Goto T, Imai AFast and precise method for HPLC-size exclusion chromatography with UV and TOC (NDIR) detection: importance of multiple detectors to evaluate the characteristics of dissolved organic matter. Water Res, 2011, 45(18): 6240-6248.

[20] Krahnstöver T, Wintgens TSeparating powdered activated carbon (PAC) from wastewater – technical process options and assessment of removal efficiency. J Environ Chem Eng, 2018, 6(5): 5744-5762.

[21] Lagergren SYZur Theorie der sogenannten Adsorption gelöster Stoffe. K Sven Vetenskapsakad Handl, 1898, 24(4): 1-39

[22] Langmuir IThe adsorption of gases on plane surfaces of glass, mica and platinum. J Am Chem Soc, 1918, 40(9): 1361-1403.

[23] Liu YIs the free energy change of adsorption correctly calculated?. J Chem Eng Data, 2009, 54(7): 1981-1985.

[24] Liu Z, Zhang FSRemoval of lead from water using biochars prepared from hydrothermal liquefaction of biomass. J Hazard Mater, 2009, 167(1-3): 933-939.

[25] Liu Y, Wu J, Cheng N, Gan P, Li Y, Liu W, Ye J, Tong M, Liang JThe overlooked role of UV(185) induced high-energy excited states in the dephosphorization of organophosphorus pesticide by VUV/persulfate. Chemosphere, 2023, 334: 138993.

[26] Liu X, He Y, Li J, Zheng S, Zhang L, Zhang J, Tang XBiochar-regulated transport of weakly hydrophobic antibiotics between macropore and matrix domains in structured soil. Biochar, 2026, 8(1): 86.

[27] Medeiros D, Nzediegwu C, Benally C, Messele SA, Kwak JH, Naeth MA, Ok YS, Chang SX, Gamal El-Din MPristine and engineered biochar for the removal of contaminants co-existing in several types of industrial wastewaters: a critical review. Sci Total Environ, 2022, 809151120.

[28] Missau J, Bertuol DA, Tanabe EHHighly efficient adsorbent for removal of crystal violet dye from aqueous solution by CaAl/LDH supported on biochar. Appl Clay Sci, 2021, 214106297.

[29] Nakazawa Y, Matsui Y, Hanamura Y, Shinno K, Shirasaki N, Matsushita TIdentifying, counting, and characterizing superfine activated-carbon particles remaining after coagulation, sedimentation, and sand filtration. Water Res, 2018, 138160-168.

[30] Newcombe GNewcombe G, Dixon DChapter 8 - removal of natural organic material and algal metabolites using activated carbon. Interface science and technology, 2006, Amsterdam: Elsevier, 133-153.

[31] Pei M, Zhang B, He Y, Su J, Gin K, Lev O, Shen G, Hu SState of the art of tertiary treatment technologies for controlling antibiotic resistance in wastewater treatment plants. Environ Int, 2019, 131105026.

[32] Pivokonsky M, Kopecka I, Cermakova L, Fialova K, Novotna K, Cajthaml T, Henderson RK, Pivokonska LCurrent knowledge in the field of algal organic matter adsorption onto activated carbon in drinking water treatment. Sci Total Environ, 2021, 799149455.

[33] Rajabi H, Hadi Mosleh M, Mandal P, Lea-Langton A, Sedighi MEmissions of volatile organic compounds from crude oil processing – global emission inventory and environmental release. Sci Total Environ, 2020, 727138654.

[34] Rajabi H, Hadi Mosleh M, Prakoso T, Ghaemi N, Mandal P, Lea-Langton A, Sedighi MCompetitive adsorption of multicomponent volatile organic compounds on biochar. Chemosphere, 2021, 283131288.

[35] Rajabi H, Mosleh MH, Mandal P, Lea-Langton A, Sedighi MSorption behaviour of xylene isomers on biochar from a range of feedstock. Chemosphere, 2021, 268129310.

[36] Rocha LS, Pereira D, Sousa E, Otero M, Esteves VI, Calisto VRecent advances on the development and application of magnetic activated carbon and char for the removal of pharmaceutical compounds from waters: a review. Sci Total Environ, 2020, 718137272.

[37] Singh P, Pathy A, Sharma S, Dhanorkar M, Naeth MA, Chang SXExpanding the frontiers of nanobiochar and biochar nanocomposites as versatile biomaterials for sustainable development. Biochar, 2026, 8(1): 15.

[38] Sun Y, Zhang Z, Heng J, Gao C, Jin Q, Chen Z, Guo ZCo-transport of U(VI) and colloidal biochar in quartz sand heterogeneous media. Sci Total Environ, 2022, 816151606.

[39] Sun Z, Liao Y, Zhang Y, Sun S, Kan Q, Wu Z, Yu L, Dong Z, Wang Z, He R, Wang L, Meng Q, Wang H, Wang Q, Mao L, Pan D, Wang S, Zhang Z, Zhu W, Liu S, Wakeel M, Hu B, Duan T, Tai X, Wang XSustainable carbon materials in environmental and energy applications. Sustain Carbon Mater, 2025

[40] Tong M, Li T, Li M, He L, Ma ZCotransport and deposition of biochar with different sized-plastic particles in saturated porous media. Sci Total Environ, 2020, 713136387.

[41] Wang Z, Sedighi MDisintegration of biochar adsorbent under the hydraulic conditions of fixed bed water treatment. Chemosphere, 2023, 336139294.

[42] Wang X, Zeng W, Guo Q, Geng Q, Yan Y, Hu XThe further activation and functionalization of semicoke for CO(2) capture from flue gases. RSC Adv, 2018, 8(62):35521-35527.

[43] Wang X, Zeng W, Zhang H, Li D, Tian H, Hu X, Wu Q, Xin C, Cao X, Liu WThe dynamic CO(2) adsorption of polyethylene polyamine-loaded MCM-41 before and after methoxypolyethylene glycol codispersion. RSC Adv, 2019, 9(46): 27050-27059.

[44] Wang X, Zeng W, Liu W, Cao X, Hou C, Ding Q, Lü YCO2 adsorption of lignite chars after one-step KOH activation. New J Chem, 2020, 44(32): 13755-13763.

[45] Wang Z, Sedighi M, Lea-Langton AFiltration of microplastic spheres by biochar: removal efficiency and immobilisation mechanisms. Water Res, 2020, 184116165.

[46] Wang X, Zeng W, Kong X, Xin C, Dong Y, Hu X, Guo QDevelopment of low-cost porous carbons through alkali activation of crop waste for CO(2) capture. ACS Omega, 2022, 7(50): 46992-47001.

[47] Wang X, Zeng W, Xin C, Kong X, Hu X, Guo QThe development of activated carbon from corncob for CO(2) capture. RSC Adv, 2022, 12(51): 33069-33078.

[48] Wang X, Kong F, Zeng W, Zhang H, Xin C, Kong XThe resource utilization of poplar leaves for CO(2) adsorption. Molecules, 2024

[49] Weber WJ, Morris JCKinetics of adsorption on carbon from solution. J Sanit Eng Div, 1963, 89(2): 31-59.

[50] Xu F, Zhu J, Liu K, Wang M, Liu H, Lian J, Qu X, Wang BColloidal stability of dissolved black carbon: interfacial mechanisms and environmental implications. Biochar, 2026, 8(1): 108.

[51] Yuan J, Passeport E, Hofmann RUnderstanding adsorption and biodegradation in granular activated carbon for drinking water treatment: a critical review. Water Res, 2022, 210118026.

[52] Zhang J, Xie X, Meng X, Li Y, Zhu WRelease and transport of Pb(II) adsorbed on graphene oxide under alkaline conditions in a saturated sand column. J Hazard Mater, 2019, 377357-364.

[53] Zhang F, Zhou B, Fu Q, Jia H, Li Y-F, Ding Y, Cui SBinding mechanisms of Pb(II) adsorption by biochar-derived dissolved organic matter: unraveling site heterogeneity and kinetics through advanced spectral analysis. Biochar, 2025, 7(1):116.

[54] Zhao J, Mathew RA, Yang DS, Vekilov PG, Hu Y, Louie SMNatural organic matter flocculation behavior controls lead phosphate particle aggregation by mono- and divalent cations. Sci Total Environ, 2023, 866161346.

Rights & permissions

The Author(s)