Cell-retention for lipid production in continuous Schizochytrium limacinum SR21 cultures fed with dark fermentation effluent

Abstract

The marine protist Schizochytrium limacinum SR21 is a promising producer of docosahexaenoic acid (DHA) from short-chain carboxylic acids (SCCAs). Dark fermentation effluent (DFE) is an SCCA- and nutrient-rich substrate derived from biogenic residues and has previously been evaluated for microbial lipid production. However, its low carbon concentration limits volumetric productivity and causes substantial culture dilution when larger feed volumes are required.

Membrane-based cell retention is an established process intensification strategy for low-concentration feed solutions, as it decouples hydraulic residence time from biomass residence time. However, the combination of DFE utilisation and cell retention for DHA production by S. limacinum has received little attention. In this study, repeated fed-batch and cell retention strategies were evaluated to overcome dilution limitations and enable intensified biomass and lipid production from DFE. Additional cultivations with defined SCCA mixtures showed preferential uptake of acetate and butyrate over propionate and lactate, which was also observed during DFE conversion. In repeated fed-batch operation, biomass output reached 7.5 g after 95 h. In contrast, a final biomass output of 33 g was achieved in cell retention mode, representing a 4.4-fold increase. This improvement was not associated with enhanced substrate conversion efficiency but resulted from retaining biomass while increasing DFE throughput. While applying cell retention, the specific palmitic acid concentration increased to 116 mg g⁻¹, while DHA remained comparatively stable at 57 mg g⁻¹. This resulted in a DHA titre of 1.9 g L⁻¹ compared with 0.24 g L⁻¹ in repeated fed-batch. Nitrogen and phosphate removal reached 58% and 87%, respectively. However, the relatively high nutrient content of DFE limited the establishment of strong nitrogen limitation.

Overall, cell retention enabled process intensification with a total lipid space-time yield of 0.07 g_lipids L⁻¹ h⁻¹ and a DHA space-time yield of 19.7 mg L⁻¹ h⁻¹. The results demonstrate that cell retention is an effective strategy for valorising low-concentration DFE while operational boundaries for DFE-based DHA production are identified.

Graphical abstract

Keywords

Volatile fatty acids / Microbial hydrolysis / Docosahexaenoic acid / Polyunsaturated fatty acids / Aurantiochytrium limacinum / Membrane bioreactor

References

[1] Akkoyunlu B, Daly S, Casey E. Membrane bioreactors for the production of value-added products: Recent developments, challenges and perspectives. Bioresour Technol, 2021, 341: 125793

[2] Asif MB, Zhang Z. Ceramic membrane technology for water and wastewater treatment: A critical review of performance, full-scale applications, membrane fouling and prospects. Chem Eng J, 2021, 418: 129481

[3] Bartek L, Strid I, Junne S, et al.. Life cycle assessment of fish oil substitute produced by microalgae using food waste. Sustainable Prod Consum, 2021, 27: 2002-2021

[4] Burniol-Figols A, Pinelo M, Skiadas IV, Gavala HN. Enhancing polyhydroxyalkanoate productivity with cell-retention membrane bioreactors. Biochem Eng J, 2020, 161: 107687

[5] Chalima A, Hatzidaki A, Karnaouri A, Topakas E. Integration of a dark fermentation effluent in a microalgal-based biorefinery for the production of high-added value omega-3 fatty acids. Appl Energy, 2019, 241: 130-138

[6] Chalima A, Taxeidis G, Topakas E. Optimization of the production of docosahexaenoic fatty acid by the heterotrophic microalga Crypthecodinium cohnii utilizing a dark fermentation effluent. Renewable Energy, 2020, 152: 102-109

[7] Chalima A, Castro LFD, Burgstaller L, et al.. Waste-derived volatile fatty acids as carbon source for added-value fermentation approaches. FEMS Microbiol Lett, 2021, 368: fnab054

[8] Cieciura-Włoch W, Binczarski M, Tomaszewska J, et al.. The use of acidic hydrolysates after furfural production from sugar waste biomass as a fermentation medium in the biotechnological production of hydrogen. Energies, 2019, 12: 3222

[9] Cieciura-Włoch W, Borowski S, Januszewicz B, Domański J. Effects of sugar beet pulp pretreatment methods on hydrogen production by dark fermentation. Processes, 2024, 12: 1606

[10] Contreras P, Oviedo C. Potential and future perspectives of thraustochytrids in bioremediation. Int J Environ Sci Technol, 2023, 20: 4483-4498

[11] Corsino SF, Di Bella G, Traina F, et al.. Membrane fouling mitigation in MBR via the feast–famine strategy to enhance PHA production by activated sludge. Membranes, 2022, 12: 703

[12] Dar RA, Tsui T-H, Zhang L, et al.. Fermentation of organic wastes through oleaginous microorganisms for lipid production - Challenges and opportunities. Renew Sustain Energy Rev, 2024, 195: 114328

[13] Djuricic I, Calder PC. Beneficial outcomes of omega-6 and omega-3 polyunsaturated fatty acids on human health: an update for 2021. Nutrients, 2021, 13: 2421

[14] Fu R, Fei Q, Shang L, et al.. Enhanced microbial lipid production by Cryptococcus albidus in the high-cell-density continuous cultivation with membrane cell recycling and two-stage nutrient limitation. J Ind Microbiol Biotechnol, 2018, 45: 1045-1051

[15] Heggeset TMB, Ertesvåg H, Liu B, et al.. Lipid and DHA-production in Aurantiochytrium sp. – Responses to nitrogen starvation and oxygen limitation revealed by analyses of production kinetics and global transcriptomes. Sci Rep, 2019, 9: 19470

[16] Hu X-C, Ren L-J, Chen S-L, et al.. The roles of different salts and a novel osmotic pressure control strategy for improvement of DHA production by Schizochytrium sp. Bioprocess Biosystem Eng, 2015, 38: 2129-2136

[17] Janesch E, Pereira J, Neubauer P, Junne S. Phase separation in anaerobic digestion: a potential for easier process combination?. Front Chem Eng, 2021, 3: 711971

[18] Junne S, Cziommer J, Täuber S, Neubauer P (2021) 8 From cellulose to lipids. In: Biorefinery: from biomass to chemicals and fuels. De Gruyter, pp 229–264. https://doi.org/10.1515/9783110705386-009

[19] Katerina K, Berge GM, Turid M, et al.. Microalgal Schizochytrium limacinum biomass improves growth and filet quality when used long-term as a replacement for fish oil, in Modern Salmon Diets. Front Mar Sci, 2020, 7: 57

[20] Koruyucu A, Blums K, Peest T, et al.. High-cell-density yeast oil production with diluted substrates imitating microalgae hydrolysate using a membrane bioreactor. Energies, 2023, 16: 1757

[21] Krikigianni E, Matsakas L, Rova U, et al.. Investigating the bioconversion potential of volatile fatty acids: use of oleaginous yeasts Rhodosporidium toruloides and Cryptococcus curvatus towards the sustainable production of biodiesel and odd-chain fatty acids. Appl Sci (Switzerland), 2022, 12(136541

[22] Liu J, Feng X, Wang S, et al.. Metabolic regulation strategies for enhancing microbial docosahexaenoic acid production by Schizochytrium sp. World J Microb Biotechnol, 2025, 41: 142

[23] Longis M, Pereira JC, Högl TH, et al.. Plug-flow anaerobic digestion with multi-position sensors: the value of gradient measurement for process monitoring. Biomass Bioenergy, 2023, 173: 106803

[24] Lyu Q, Dar RA, Baganz F, et al.. Effects of lignocellulosic biomass-derived hydrolysate inhibitors on cell growth and lipid production during microbial fermentation of oleaginous microorganisms—a review. Fermentation, 2025, 11: 121

[25] Marbà-Ardébol A-M, Emmerich J, Neubauer P, Junne S. Single-cell-based monitoring of fatty acid accumulation in Crypthecodinium cohnii with three-dimensional holographic and in situ microscopy. Process Biochem, 2017, 52: 223-232

[26] Menzel T, Neubauer P, Junne S. Role of microbial hydrolysis in anaerobic digestion. Energies, 2020, 13: 5555

[27] Menzel T, Neubauer P, Junne S. Effect of bioaugmentation with Paenibacillus spp. and thin slurry recirculation on microbial hydrolysis of maize silage and bedding straw in a plug-flow reactor. Biomass Convers Biorefinery, 2023

[28] Menzel T, Neubauer P, Junne S. Plug-flow hydrolysis with lignocellulosic residues: effect of hydraulic retention time and thin-sludge recirculation. Biotechnol Biofuels Bioprod, 2023, 16: 111

[29] Meo A, Priebe XL, Weuster-Botz D. Lipid production with Trichosporon oleaginosus in a membrane bioreactor using microalgae hydrolysate. J Biotechnol, 2017, 241: 1-10

[30] Monlau F, Sambusiti C, Barakat A, et al.. Do furanic and phenolic compounds of lignocellulosic and algae biomass hydrolyzate inhibit anaerobic mixed cultures? A comprehensive review. Biotechnol Adv, 2014, 32: 934-951

[31] Naylor RL, Hardy RW, Buschmann AH, et al.. A 20-year retrospective review of global aquaculture. Nature, 2021, 591: 551-563

[32] Patel A, Rova U, Christakopoulos P, Matsakas L. Assessment of fatty acids profile and omega-3 polyunsaturated fatty acid production by the oleaginous marine thraustochytrid Aurantiochytrium sp. T66 cultivated on volatile fatty acids. Biomolecules, 2020, 10(5): 694

[33] Patel A, Mahboubi A, Horváth IS, et al.. Volatile fatty acids (VFAs) generated by anaerobic digestion serve as feedstock for freshwater and marine oleaginous microorganisms to produce biodiesel and added-value compounds. Front Microbiol, 2021, 12: 614612

[34] Patel A, Krikigianni E, Rova U, et al.. Bioprocessing of volatile fatty acids by oleaginous freshwater microalgae and their potential for biofuel and protein production. Chem Eng J, 2022, 438: 135529

[35] Paul T, Baskaran D, Pakshirajan K, Pugazhenthi G. Continuous bioreactor with cell recycle using tubular ceramic membrane for simultaneous wastewater treatment and bio-oil production by oleaginous Rhodococcus opacus. Chem Eng J, 2019, 367: 76-85

[36] Saheki S, Takeda A, Shimazu T. Assay of inorganic phosphate in the mild pH range, suitable for measurement of glycogen phosphorylase activity. Anal Biochem, 1985, 148: 277-281

[37] Sarker PK, Gamble MM, Kelson S, Kapuscinski AR. Nile tilapia (Oreochromis niloticus) show high digestibility of lipid and fatty acids from marine Schizochytrium sp. and of protein and essential amino acids from freshwater Spirulina sp. feed ingredients. Aquacult Nutr, 2016, 22: 109-119

[38] Sathiyamoorthi E, Kumar P, Kim BS. Lipid production by Cryptococcus albidus using biowastes hydrolysed by indigenous microbes. Bioprocess Biosystem Eng, 2019, 42: 687-696

[39] Schroedter L, Schneider R, Venus J. Transforming waste wood into pure L-(+)-lactic acid: Efficient use of mixed sugar media through cell-recycled continuous fermentation. Bioresour Technol, 2025, 419: 132010

[40] Shafiq M, Zhang BB, Zeb L, et al.. Integrated biorefinery approach for bioconversion of fish manure to volatile fatty acids and its valorization by Schizochytrium sp for docosahexaenoic acid, squalene, and carotenoids production. J Water Process Eng, 2024, 58: 104749

[41] Täuber S, Janesch E, Neubauer P, Junne S. An update on valorising dark fermentation effluent through microbial lipid synthesis. J Environ Manage, 2025, 395: 127912

[42] Täuber S, Riedel SL, Junne S. Polyhydroxyalkanoate production from food residues. Appl Microbiol Biotechnol, 2025, 109: 171

[43] Tian L, Chi G, Lin S, et al.. Marine microorganisms: natural factories for polyunsaturated fatty acid production. Blue Biotechnol, 2024, 1: 15

[44] Tocher DR. Fatty acid requirements in ontogeny of marine and freshwater fish. Aquac Res, 2010, 41: 717-732

[45] Tocher D, Betancor M, Sprague M, et al.. Omega-3 long-chain polyunsaturated fatty acids, EPA and DHA: bridging the gap between supply and demand. Nutrients, 2019, 11: 89

[46] Tsirigka A, Aggeli A, Theodosiou E, et al.. Model-based study of Yarrowia lipolytica cultivation on crude glycerol under different fermentation modes: development of a membrane bioreactor process. Bioresour Technol, 2025, 417: 131773

[47] Wang JM, Jin QQ, Zhang YY, et al.. Reducing the membrane fouling in cross-flow filtration using a facile fluidic oscillator. Sep Purif Technol, 2021, 272: 118854

[48] Wang L, Zhang Z, Wang Y, et al.. Assessing the potential of Schizochytrium sp. HX-308 for microbial lipids production from corn stover hydrolysate. Biotechnol J, 2022, 17: 2100470

[49] Wang Z, Feng G, Yan Z, et al.. Improving the hydrophilicity and antifouling performance of PVDF membranes via PEI amination and further poly (methyl vinyl ether-alt-maleic anhydride) modification. Reactive Funct Polym, 2023, 189: 105610

[50] Zhang Y, E J, Chen C, et al.. Schizochytrium limacinum valorizes volatile fatty acid-rich dark fermentative effluent for docosahexaenoic acid production. Bioresour Technol, 2025, 434: 132780

Funding

Technische Universität Berlin (3136)

Rights & permissions

The Author(s)