Acid-catalyzed transformation of orange waste into furfural: the effect of pectin degree of esterification

Abstract

The transformation of biomasses from agro-industrial waste can significantly impact the production of green chemicals from sustainable resources. Pectin is a biopolymer present in lignocellulosic biomass as Orange Peel Waste (OPW) and has possibilities for making platform compounds such as furfural for sustainable chemistry. In this work, we studied the transformation to furfural of OPW, pectins, and d-galacturonic acid (D-GalA), which is the main component (65 wt%) of pectin. We analyzed pectins with different degrees of esterification (45, 60 and 95 DE) in a one-pot hydrolysis reaction system and studied the differences in depolymerization and dehydration of the carbohydrates. The results show that the production of furfural decreases as the DE value increases. Specifically, low DE values favor the formation of furfural since the decarboxylation reaction is favored over deesterification. Interestingly, the furfural concentration is dependent upon the polysaccharide composition of pentoses and uronic acid. The obtained concentrations of furfural (13 and 14 mmol/L), d-xylose (6.2 and 10 mmol/L), and L-arabinose (2.5 and 2.7 mmol/L) remained the same when the galacturonic acid was fed either as a polymer or a monomer under the same reaction conditions (0.01 M SA, 90 min and 433 K). OPW is proposed as a feedstock in a biorefinery, in which on a per kg OPW dry basis, 90 g of pectin and 15 g of furfural were produced in the most favorable case. We conclude that the co-production of pectin and furfural from OPW is economically feasible.

Keywords

Pectin hydrolysis / Decarboxylation / Dehydration / Degree of esterification / Furfural

References

[1] Alonso DM, Wettstein SG, Dumesic JA. Gamma-valerolactone, a sustainable platform molecule derived from lignocellulosic biomass. Green Chem, 2013, 15(3): 584-595.

[2] Anukam A, Berghel J. Biomass pretreatment and characterization: a review. Biotechnol Appl Biomass, 2021

[3] Arollado EC, Ramirez RLF, Richelle AM, Manalo GL, Dela Torre T, Kerstin MG, Ponsaran SM, Salvador M, Siocson MPF. Optimization of the isolation and purification method of pharmaceutical grade pectin from pomelo fruit peels (Citrus maxima Merr. [Family Rutaceae]). Acta Med Philipp, 2018

[4] Bochek AM, Zabivalova NM, Petropavlovskii GA. Determination of the esterification degree of polygalacturonic acid. Russ J Appl Chem, 2001, 74(5): 796-799.

[5] Bornik MA, Kroh LW. D-galacturonic acid as a highly reactive compound in nonenzymatic browning. 1. Formation of browning active degradation products. J Agric Food Chem, 2013, 61(14): 3494-3500.

[6] Chen H, Liu J, Chang X, Chen D, Xue Y, Liu P, Lin H, Han S. A review on the pretreatment of lignocellulose for high-value chemicals. Fuel Process Technol, 2017, 160: 196-206.

[7] Ciriminna R, Fidalgo A, Delisi R, Ilharco LM, Pagliaro M. Pectin production and global market. Agro Food Ind Hi Tech, 2016, 27(5): 17-20.

[8] Conrad M. The decarboxylation of galacturonic acid with special reference to the hypothetical formation of l- arabinose. J Am Chem Soc, 1931, 53(6): 2282-2287.

[9] Constant S, Lancefield CS, Vogelzang W, Pazhavelikkakath Purushothaman RK, Frissen AE, Houben K, Peinder P, Baldus M, Weckhuysen BM, van Es DS, Bruijnincx PCA. Molecular structure and composition elucidation of an industrial humin and its fractions. Green Chem Adv Article, 2024, 1: 13.

[10] Food and Agriculture Organization FAOSTAT (2023) Available online: http://www.fao.org/faostat/en/data/QC. Accessed 13 Oct 2023.

[11] Gallo JMR, Alonso DM, Mellmer MA, Yeap JH, Wong HC, Dumesic JA. Production of furfural from lignocellulosic biomass using beta zeolite and biomass-derived solvent. Top Catal, 2013, 56(18–20): 1775-1781.

[12] Garrett ER, Dvorchik BH. Kinetics and mechanisms of the acid degradation of the aldopentoses to furfural. J Pharm Sci, 1969, 58(7): 813-820.

[13] Lavarack BP, Griffin GJ, Rodman D. The acid hydrolysis of sugarcane bagasse hemicellulose to produce xylose arabinose glucose and other products. Biomass Bioenergy, 2002, 23(5): 367-380.

[14] Lei L, Qing L, Junhua D, Yucai H, Cuiluan M. Improved synthesis of furfurylamine from a high titer of biomass-derived furfural by a thermostable triple mutant ω-transaminase in a three-component deep eutectic solvent ChCl/lactic acid/malonic acid system. ACS Sustain Chem Eng, 2023, 11(19): 7515-7525.

[15] Li X, Jia P, Wang T. Furfural: a promising platform compound for sustainable production of C4 and C5 chemicals. ACS Catal, 2016, 6(11): 7621-7640.

[16] Liu S, Zhu Y, Liao Y, Wang H, Liu Q, Ma L, Wang C. Advances in understanding the humins: formation, prevention and application. Appl Energy Combust Sci, 2022, 10(February

[17] Liu Y, Lei L, Cuiluan M, Yu-Cai H. Chemobiocatalytic transfromation of biomass into furfurylamine with mixed amine donor in an eco-friendly medium. Biores Technol, 2023, 387.

[18] Liu Y, Yuqi W, Yu-Cai H, Cuiluan M. Synthesis of furoic acid from biomasses by sequential catalysis with fish scale-rice husk-based heterogeneous chemocatalyst and dehydrogenase biocatalyst. Ind Crops Prod, 2023, 202.

[19] López F, García MT, Feria MJ, García JC, de Diego CM, Zamudio MAM, Díaz MJ. Optimization of furfural production by acid hydrolysis of eucalyptus globulus in two stages. Chem Eng J, 2014, 240: 195-201.

[20] Marín-Proa YE (2012) Extracción de pectina de cáscara de naranja (Citrus sinensis) y estudio de la factibilidad de aplicación en el encapsulado de bacteria lácticas. Dissertation, Universidad Autónoma de San Luis Potosí

[21] McMillan JD. Pretreatment of lignocellulosic biomass. Biomass Biofuels, 2016

[22] Müller-Maatsch J, Bencivenni M, Caligiani A, Tedeschi T, Bruggeman G, Bosch M, Petrusan J, Van Droogenbroeck B, Elst K, Sforza S. Pectin content and composition from different food waste streams. Food Chem, 2016, 201: 37-45.

[23] Nanda S, Mohammad J, Reddy SN, Kozinski JA, Dalai AK. Pathways of lignocellulosic biomass conversion to renewable fuels. Biomass Convers Biorefinery, 2014, 4: 157-191.

[24] Naqash F, Masoodi FA, Rather SA, Wani SM, Gani A. Emerging concepts in the nutraceutical and functional properties of pectin—A Review. Carbohydr Polym, 2017, 168: 227-239.

[25] Oriez V, Peydecastaing J, Pontalier PY. Lignocellulosic biomass fractionation by mineral acids and resulting extract purification processes: conditions, yields, and purities. Molecules, 2019, 24(23): 1-21.

[26] Ortiz-Sanchez M, Cardona-Alzate CA. Comparative environmental life cycle assessment of orange peel waste in present productive chains. J Clean Prod, 2021, 322.

[27] Ortiz-Sanchez M, Solarte-Toro JC, Orrego-Alzate CE, Acosta-Medina CD, Cardona-Alzate CA. Integral use of orange peel waste through the biorefinery concept: an experimental, technical, energy, and economic assessment. Biomass Convers Biorefinery, 2021, 11(2): 645-659.

[28] Ortiz-Sanchez M, Cardona Alzate CA, Solarte-Toro JC. Orange peel waste as a source of bioactive compounds and valuable products: insights based on chemical composition and biorefining. Biomass, 2024, 4(1): 107-131.

[29] Patil SKR, Heltzel J, Lund CRF. Comparison of structural features of humins formed catalytically from glucose, fructose, and 5-hydroxymethylfurfuraldehyde. Energy Fuels, 2012, 26(8): 5281-5293.

[30] Peters MS, Timmerhaus KD, West RE (1991) Plant design and economics for chemical engineers. 4th ed. New York

[31] Roman-Benn A, Contador CA, Li MW, Lam HM, Ah-Hen K, Ulloa PE, Ravanal MC. Pectin: an overview of sources, extraction and applications in food products, biomedical, pharmaceutical and environmental issues. Food Chem Adv, 2023, 2(2023

[32] Rungraeng N, Kraithong S. Effect of acid type and concentration on properties of pectin extracted from unripe Cavendish banana peel and its application in raspberry jam. Eng Agric Environ Food, 2020, 13(1): 1-8.

[33] Sabater C, Villamiel M, Montilla A. Integral use of pectin-rich by-products in a biorefinery context: a holistic approach. Food Hydrocoll, 2022, 128.

[34] Sayah MY, Chabir R, Benyahia H, Kandri YR, Chahdi FO, Touzani H, Errachidi F. Yield, esterification degree and molecular weight evaluation of pectins isolated from orange and grapefruit peels under different conditions. PLoS ONE, 2016, 11(9): 1-16.

[35] Shi N, Liu Q, Cen H, Ju R, He X, Ma L. Formation of humins during degradation of carbohydrates and furfural derivatives in various solvents. Biomass Convers Biorefinery, 2020, 10(2): 277-287.

[36] Shrotri A, Kobayashi H, Fukuoka A. Cellulose depolymerization over heterogeneous catalysts. Acc Chem Res, 2018, 51(3): 761-768.

[37] Sistema de Información Agroalimentaria y Pesquera (SIAP) Cierre de la Producción por Estado (2023) Available online: http://infosiap.siap.gob.mx:8080/agricolasiapgobmx/AvanceNacionalCultivo.do. 8080. Accessed 13 Oct 2023

[38] Świątek K, Gaag S, Klier A, Kruse A, Sauer J, Steinbach D. Acid hydrolysis of lignocellulosic biomass: sugars and furfurals formation. Catalysts, 2020, 10(4): 437.

[39] Tao J, Pan Y, Zhou H, Tang Y, Ren G, Yu Z, Li J, Zhang R, Li X, Qiao Y, Lu X, Xiong J. Catalytic systems for 5-hydroxymethylfurfural preparation from different biomass feedstocks: a review. Catalysts, 2024

[40] Tsilomelekis G, Orella MJ, Lin Z, Cheng Z, Zheng W, Nikolakis V, Vlachos DG. Molecular structure, morphology and growth mechanisms and rates of 5-hydroxymethyl furfural (HMF) derived humins. Green Chem, 2016, 18(7): 1983-1993.

[41] U.S. and World Population Clock (2023). Available online: https://www.census.gov/popclock/. Accessed 10 Jan 2024

[42] Vaez S, Karimi K, Mirmohamadsadeghi S, Jeihanipour A. An optimal biorefinery development for pectin and biofuels production from orange wastes without enzyme consumption. Process Saf Environ Prot, 2021, 152: 513-526.

[43] Vaithyanathan VK, Goyette B, Rajagopal R. A critical review of the transformation of biomass into commodity chemicals: prominence of pretreatments. Environ Chall, 2023, 11(January

[44] Vigneshwar SS, Swetha A, Gopinath KP, Goutham R, Pa R, Arun J, SundarRajan P, Bhatnagar A, Lan Chi NT, Pugazhendhi A. Bioprocessing of biowaste derived from food supply chain side-streams for extraction of value added bioproducts through biorefinery approach. Food Chem Toxicol, 2022, 165.

[45] Wang Y, Yanan D, Tianhao W, Mengling L, Ying Z, Liping Z. Efficient conversion of xylose to furfural over modified zeolite in the recyclable water/n-butanol system. Fuel Process Technol, 2022, 237.

[46] WEO (2023) World Energy Outlook. Int Energy Agency. https://doi.org/10.1787/20725302

[47] Xiao C, Anderson CT. Roles of pectin in biomass yield and processing for biofuels. Front Plant Sci, 2013, 4: 1-7.

[48] Xu H, Dong C, Wang W, Liu Y, Li B, Liu F. Machine learning prediction of deep eutectic solvents pretreatment of lignocellulosic biomass. Ind Crops Prod, 2023, 196.

[49] Yang Q, Wei T, Cuiluan M, Yu-Cai H. Efficient co-production of xylooligosaccharides, furfural and reducing sugars from yellow bamboo via the pretreatment with biochar-based catalyst. Biores Technol, 2023, 387.

[50] Yang L, Yuting L, Yu P, Yu-Cai H, Cuiluan M. Chemobiocatalytic transformation of biomass-derived D-xylose into furfuryl alcohol in a sustainable reaction system. Catal Commun, 2023, 184.

[51] Zhou L, Yang X, Xu J, Shi M, Wang F, Chen C, Xu J. Depolymerization of cellulose to glucose by oxidation-hydrolysis. Green Chem, 2015, 17(3): 1519-1524.

Funding

Conahcyt(CB 255527-2016)