Optimized sampling protocol for mass spectrometry-based metabolomics in Streptomyces

Abstract

In quantitative metabolomics studies, the most crucial step was arresting snapshots of all interesting metabolites. However, the procedure customized for Streptomyces was so rare that most studies consulted the procedure from other bacteria even yeast, leading to inaccurate and unreliable metabolomics analysis. In this study, a base solution (acetone: ethanol = 1:1, mol/mol) was added to a quenching solution to keep the integrity of the cell membrane. Based on the molar transition energy (E_T) of the organic solvents, five solutions were used to carry out the quenching procedures. These were acetone, isoamylol, propanol, methanol, and 60% (v/v) methanol. To the best of our knowledge, this is the first report which has utilized a quenching solution with E_T values. Three procedures were also adopted for extraction. These were boiling, freezing–thawing, and grinding ethanol. Following the analysis of the mass balance, amino acids, organic acids, phosphate sugars, and sugar alcohols were measured using gas chromatography with an isotope dilution mass spectrometry. It was found that using isoamylol with a base solution (5:1, v/v) as a quenching solution and that freezing–thawing in liquid nitrogen within 50% (v/v) methanol as an extracting procedure were the best pairing for the quantitative metabolomics of Streptomyces ZYJ-6, and resulted in average recoveries of close to 100%. The concentration of intracellular metabolites obtained from this new quenching solution was between two and ten times higher than that from 60% (v/v) methanol, which until now has been the most commonly used solution. Our findings are the first systematic quantitative metabolomics tools for Streptomyces ZYJ-6 and, therefore, will be important references for research in fields such as ¹³C based metabolic flux analysis, multi-omic research and genome-scale metabolic model establishment, as well as for other Streptomyces.

Keywords

Quantitative metabolomics / Streptomyces / Quenching / Leakage / Extraction

References

[1] Berdy J. Bioactive microbial metabolites. J Antibiot, 2005, 58(1): 1-26.

[2] Bolten CJ, Kiefer P, Letisse F, Portais JC, Wittmann C. Sampling for metabolome analysis of microorganisms. Anal Chem, 2007, 79(10): 3843-3849.

[3] Canelas AB, Ras C, ten Pierick A, van Dam JC, Heijnen JJ, Van Gulik WM. Leakage-free rapid quenching technique for yeast metabolomics. Metabolomics, 2008, 4(3): 226-239.

[4] Canelas AB, ten Pierick A, Ras C, Seifar RM, van Dam JC, van Gulik WM, . Quantitative evaluation of intracellular metabolite extraction techniques for yeast metabolomics. Anal Chem, 2009, 81(17): 7379-7389.

[5] Carnicer M, Canelas AB, ten Pierick A, Zeng Z, van Dam J, Albiol J, . Development of quantitative metabolomics for Pichia pastoris. Metabolomics, 2012, 8(2): 284-298.

[6] Cheng JS, Cui SF, Ding MZ, Yuan YJ. Insights into the roles of exogenous glutamate and proline in improving streptolydigin production of Streptomyces lydicus with metabolomic analysis. J Ind Microbiol Biotechnol, 2013, 40(11): 1303-1314.

[7] Cipollina C, ten Pierick A, Canelas AB, Seifar RM, van Maris AJA, van Dam JC, . A comprehensive method for the quantification of the non-oxidative pentose phosphate pathway intermediates in Saccharomyces cerevisiae by GC-IDMS. J Chromatogr B, 2009, 877(27): 3231-3236.

[8] de Jonge LP, Buijs NA, ten Pierick A, Deshmukh A, Zhao Z, Kiel JA, . Scale-down of penicillin production in Penicillium chrysogenum. Biotechnol J, 2011, 6(8): 944-958.

[9] de Jonge LP, Douma RD, Heijnen JJ, van Gulik WM. Optimization of cold methanol quenching for quantitative metabolomics of Penicillium chrysogenum. Metabolomics, 2012, 8(4): 727-735.

[10] Douma RD, de Jonge LP, Jonker CTH, Seifar RM, Heijnen JJ, van Gulik WM. Intracellular metabolite determination in the presence of extracellular abundance: application to the penicillin biosynthesis pathway in Penicillium chrysogenum. Biotechnol Bioeng, 2010, 107(1): 105-115.

[11] Guo Gang, Tian Ping-ping, Tang Dan, Wang Xiaoxia, Yang Hong-jin, Cao Peng, Gao Qiang. Metabolomics Analysis Between Wild-Type and Industrial Strains of Streptomyces avermitilis Based on Gas Chromatography–Mass Spectrometry Strategy. Lecture Notes in Electrical Engineering, 2015, Berlin, Heidelberg: Springer Berlin Heidelberg, 477-485.

[12] Hong M, Mou H, Liu X, Huang M, Chu J. ¹³C-assisted metabolomics analysis reveals the positive correlation between specific erythromycin production rate and intracellular propionyl-CoA pool size in Saccharopolyspora erythraea. Bioprocess Biosyst Eng, 2017, 40: 1337-1348.

[13] Hwang K-S, Kim HU, Charusanti P, Palsson BØ, Lee SY. Systems biology and biotechnology of Streptomyces species for the production of secondary metabolites. Biotechnol Adv, 2014, 32(2): 255-268.

[14] Japelt KB, Christensen JH, Villas-Boas SG. Metabolic fingerprinting of Lactobacillus paracasei: the optimal quenching strategy. Microb Cell Fact, 2015, 14: 132-141.

[15] Kapoore RV, Coyle R, Staton CA, Brown NJ, Vaidyanathan S. Influence of washing and quenching in profiling the metabolome of adherent mammalian cells: a case study with the metastatic breast cancer cell line MDA-MB-231. Analyst, 2017, 142(11): 2038-2049.

[16] Kassama Y, Xu Y, Dunn WB, Geukens N, Anne J, Goodacre R. Assessment of adaptive focused acoustics versus manual vortex/freeze-thaw for intracellular metabolite extraction from Streptomyces lividans producing recombinant proteins using GC-MS and multi-block principal component analysis. Analyst, 2010, 135(5): 934-942.

[17] Koning WD, Dam KV. A method for the determination of changes of glycolytic metabolites in yeast on a subsecond time scale using extraction at neutral pH. Anal Biochem, 1992, 204(1): 118-123.

[18] Lameiras F, Heijnen JJ, van Gulik WM. Development of tools for quantitative intracellular metabolomics of Aspergillus niger chemostat cultures. Metabolomics, 2015, 11: 1253-1264.

[19] Link H, Anselment B, Weuster-Botz D. Leakage of adenylates during cold methanol/glycerol quenching of Escherichia coli. Metabolomics, 2008, 4(3): 240-247.

[20] Lu H, Liu X, Huang M, Xia J, Chu J, Zhuang Y, . Integrated isotope-assisted metabolomics and ¹³C metabolic flux analysis reveals metabolic flux redistribution for high glucoamylase production by Aspergillus niger. Microb Cell Fact, 2015, 14(1): 147-160.

[21] Lu C, Zhang X, Jiang M, Bai L. Enhanced salinomycin production by adjusting the supply of polyketide extender units in Streptomyces albus. Metab Eng, 2016, 35: 129-137.

[22] Maharjan RP, Ferenci T. Global metabolite analysis: the influence of extraction methodology on metabolome profiles of Escherichia coli. Anal Biochem, 2003, 313(1): 145-154.

[23] Mashego M, Van Gulik W, Vinke J, Heijnen J. Critical evaluation of sampling techniques for residual glucose determination in carbon-limited chemostat culture of Saccharomyces cerevisiae. Biotechnol Bioeng, 2003, 83(4): 395-399.

[24] Min HS, Lee DY, Liu KH, Fiehn O, Kim KH, Chem A. Evaluation of sampling and extraction methodologies for the global metabolic profiling of Saccharophagus degradans. Anal Chem, 2010, 82(15): 6660-6666.

[25] Muhamadali H, Xu Y, Ellis DI, Trivedi DK, Rattray NJW, Bernaerts K, . Metabolomics investigation of recombinant mTNFα production in Streptomyces lividans. Microb Cell Fact, 2015, 14(1): 157-168.

[26] Reichardt C. Empirical parameters of solvent polarity. Angew Chem Int Ed, 1979, 18(2): 98-110.

[27] Seifar RM, Ras C, van Dam JC, van Gulik WM, Heijnen JJ, van Winden WA. Simultaneous quantification of free nucleotides in complex biological samples using ion pair reversed phase liquid chromatography isotope dilution tandem mass spectrometry. Anal Biochem, 2009, 388(2): 213-219.

[28] Seifar RM, Ras C, Deshmukh AT, Bekers KM, Suarez-Mendez CA, da Cruz ALB, . Quantitative analysis of intracellular coenzymes in Saccharomyces cerevisiae using ion pair reversed phase ultra high performance liquid chromatography tandem mass spectrometry. J Chromatogr A, 2013, 1311: 115-120.

[29] Smart KF, Aggio RB, Van Houtte JR, Villas-Bôas SG. Analytical platform for metabolome analysis of microbial cells using methyl chloroformate derivatization followed by gas chromatography–mass spectrometry. Nat Protoc, 2010, 5(10): 1709-1729.

[30] Taymaz-Nikerel H, De MM, Ras C, Ten PA, Seifar RM, van Dam JC, . Development and application of a differential method for reliable metabolome analysis in Escherichia coli. Anal Biochem, 2009, 386(1): 9-19.

[31] van Dam JC, Eman MR, Frank J, Lange HC, van Dedem GW, Heijnen SJ. Analysis of glycolytic intermediates in Saccharomyces cerevisiae using anion exchange chromatography and electrospray ionization with tandem mass spectrometric detection. Anal Chim Acta, 2002, 460(2): 209-218.

[32] Villasbôas SG. Global metabolite analysis of yeast: evaluation of sample preparation methods. Yeast, 2005, 22(14): 1155-1169.

[33] Villas-Bôas SG, Bruheim P. Cold glycerol–saline: the promising quenching solution for accurate intracellular metabolite analysis of microbial cells. Anal Biochem, 2007, 370(1): 87-97.

[34] Villas-Boas SG, Mas S, Akesson M, Smedsgaard J, Nielsen J. Mass spectrometry in metabolome analysis. Mass Spectrom Rev, 2005, 24(5): 613-646.

[35] Wang B, Liu J, Liu H, Huang D, Wen J. Comparative metabolic profiling reveals the key role of amino acids metabolism in the rapamycin overproduction by Streptomyces hygroscopicus. J Ind Microbiol Biotechnol, 2015, 42(6): 1-15.

[36] Wentzel A, Sletta H Consortium S Ellingsen TE, Bruheim P. Intracellular metabolite pool changes in response to nutrient depletion induced metabolic switching in Streptomyces coelicolor. Metabolites, 2012, 2(1): 178-194.

[37] Winder CL, Dunn WB, Schuler S, Broadhurst D, Jarvis R, Stephens GM, . Global metabolic profiling of Escherichia coli cultures: an evaluation of methods for quenching and extraction of intracellular metabolites. Anal Chem, 2008, 80(8): 2939-2948.

[38] Wordofa GG, Kristensen M, Schrübbers L, Mccloskey D, Forster J, Schneider K. Quantifying the metabolome of Pseudomonas taiwanensis VLB120: evaluation of hot and cold combined quenching/extraction approaches. Anal Chem, 2017, 89: 8738-8747.

[39] Wu L, Mashego MR, van Dam JC, Proell AM, Vinke JL, Ras C, . Quantitative analysis of the microbial metabolome by isotope dilution mass spectrometry using uniformly ¹³C-labeled cell extracts as internal standards. Anal Biochem, 2005, 336(2): 164-171.

[40] Xia ML, Huang D, Li SS, Wen JP, Jia XQ, Chen YL. Enhanced FK506 production in Streptomyces tsukubaensis by rational feeding strategies based on comparative metabolic profiling analysis. Biotechnol Bioeng, 2013, 110(10): 2717-2730.

[41] Zhou YJ, Li JL, Zhu J, Chen S, Bai LQ, Zhou XF, . Incomplete beta-ketone processing as a mechanism for polyene structural variation in the FR-008/candicidin complex. Chem Biol, 2008, 15(6): 629-638.

Funding

Major State Basic Research Development Program of China(2012CB721000G)

NWO-MoST Joint Program(2013DFG32630)

National Key Special Program(2017YFF 0204600)