Start-up of a nutrient removal system using Scenedesmus vacuolatus and Chlorella vulgaris biofilms

Abstract

Microalgal biofilm-based technologies are of strong interest due to their high biomass concentrations and ability to remove nutrients from wastewater, utilize CO₂ and produce secondary valuable products. This study investigated the biomass production and nutrient removal efficiency of the microalgae Scenedesmus vacuolatus ACUF_053 and Chlorella vulgaris ACUF_809 from a synthetic wastewater, describing a start-up process in a new biofilm photobioreactor (PBR) configuration. Two sets of experiments were performed. The first one compared the performance of a suspended and attached cell system under batch conditions. The second set of experiments was addressed under semi-batch conditions to study the microalgae biofilm development in the PBR. Five stages in the development of the biofilm were identified for S. vacuolatus: attachment, biofilm formation, maturation I, adaptation and maturation II. The biofilm development phases had a different nutrient removal efficiency. S. vacuolatus biofilm showed a higher phosphate demand during the first attachment and formation phases, while it had a higher nitrate demand during the subsequent phases. C. vulgaris biofilm formation was affected by the pH increase (up to 10.6). The biofilm PBR design using both S. vacuolatus and C. vulgaris showed potential for wastewater treatment due the higher nutrient removal rates.

Keywords

Biofilm / Microalgae / Nutrient removal / Photobioreactor / Attached cells

References

[1] Abdel-Raouf N, Al-Homaidan AA, Ibraheem IB. Microalgae and wastewater treatment. Saudi J Biol Sci, 2012, 19: 257-275.

[2] APHA. Standard methods for the examination of water and wastewater, 2005, APHA: Washington, D.C.

[3] Babu M. Effect of algal biofilm and operational conditions on nitrogen removal in waste stabilization ponds, 2011, Delft: Doctor in Philosophy, UNESCO-IHE Institute for Water Education

[4] Barranguet C, Veuger B, Van Beusekom SAM, Marvan P, Sinke JJ, Admiraal W. Divergent composition of algal–bacterial biofilms developing under various external factors. Eur J Phycol, 2005, 40: 1-8.

[5] Barros AI, Gonçalves AL, Simões M. Microalgal/cyanobacterial biofilm formation on selected surfaces: the effects of surface physicochemical properties and culture media composition. J Appl Phycol, 2018, 31: 375-387.

[6] Berner F, Heimann K, Sheehan M. Microalgal biofilms for biomass production. J Appl Phycol, 2015, 27: 1793-1804.

[7] Bernstein HC, Kesaano M, Moll K, Smith T, Gerlach R, Carlson RP, Miller CD, Peyton BM, Cooksey KE, Gardner RD, Sims RC. Direct measurement and characterization of active photosynthesis zones inside wastewater remediating and biofuel producing microalgal biofilms. Bioresour Technol, 2014, 156: 206-215.

[8] Bethmann B, Schönknecht G. pH regulation in an acidophilic green alga—a quantitative analysis. New Phytol, 2009, 183: 327-339.

[9] Bhaiji T. Enhancing microalgae attachment for biofilm-based photobioreactors, 2016, Cranfield: PhD, School of Aerospace, Transport and Manufacturing, Cranfield University.

[10] Blanken W, Janssen M, Cuaresma M, Libor Z, Bhaiji T, Wijffels RH. Biofilm growth of Chlorella sorokiniana in a rotating biological contactor based photobioreactor. Biotechnol Bioeng, 2014, 111: 2436-2445.

[11] Boelee NC, Temmink H, Janssen M, Buisman CJ, Wijffels RH. Nitrogen and phosphorus removal from municipal wastewater effluent using microalgal biofilms. Water Res, 2011, 45: 5925-5933.

[12] Carbone DA, Gargano I, Pinto G, De Natale A, Pollio A. Evaluating microalgal attachment to surfaces: a first approach towards a laboratory integrated assessment. Chem Eng Trans, 2017, 57: 73-78.

[13] Craggs R, McAuley P, Smith V. Wastewater nutrient removal by marine microalgae grown on a corrugated raceway. Water Res, 1997, 31: 1701-1707.

[14] D’Acunto B, Frunzo L, Klapper I, Mattei MR. Modeling multispecies biofilms including new bacterial species invasion. Math Biosci, 2015, 259: 20-26.

[15] de Godos I, Gonzalez C, Becares E, Garcia-Encina PA, Munoz R. Simultaneous nutrients and carbon removal during pretreated swine slurry degradation in a tubular biofilm photobioreactor. Appl Microbiol Biotechnol, 2009, 82: 187-194.

[16] El-Sheekh MM, Mohamed Khairy H, El-Shenody R. Algal production of extra and intra-cellular polysaccharides as an adaptive response to the toxin crude extract of Microcystis aeruginosa. Iranian J Environ Health Sci Eng, 2012, 9: 10.

[17] Gao F, Yang ZH, Li C, Zeng GM, Ma DH, Zhou L. A novel algal biofilm membrane photobioreactor for attached microalgae growth and nutrients removal from secondary effluent. Bioresour Technol, 2015, 179: 8-12.

[18] Gargano I, Olivieri G, Andreozzi R, Marotta R, Marzocchella A, Pollio A. Biodiesel production in outdoor cultures of Scenedesmus vacuolatus. Chem Eng Trans, 2016, 49: 397-402.

[19] Goldman JC, Azov Y, Riley CB, Dennett MR. The effect of pH in intensive microalgal cultures. I. Biomass regulation. J Exp Mar Biol Ecol, 1982, 57: 1-13.

[20] Gross M, Henry W, Michael C, Wen Z. Development of a rotating algal biofilm growth system for attached microalgae growth with in situ biomass harvest. Bioresour Technol, 2013, 150: 195-201.

[21] Gross M, Jarboe D, Wen Z. Biofilm-based algal cultivation systems. Appl Microbiol Biotechnol, 2015, 99: 5781-5789.

[22] Gupta PL, Choi HJ, Lee SM. Enhanced nutrient removal from municipal wastewater assisted by mixotrophic microalgal cultivation using glycerol. Environ Sci Pollut R, 2016, 23: 10114-10123.

[23] Han T, Lu HF, Ma SS, Zhang YH, Liu ZD, Duan N. Progress in microalgae cultivation photobioreactors and applications in wastewater treatment: a review. Int J Agric Biol Eng, 2017, 10: 1-29.

[24] Heeg JS, Wolf M. ITS2 and 18S rDNA sequence-structure phylogeny of Chlorella and allies (Chlorophyta, Trebouxiophyceae, Chlorellaceae). Plant Gene, 2015, 4: 20-28.

[25] Hegewald E, Bock C, Krienitz L. Aphylogenetic study on Scenedesmaceae with the description of Pectinodesmus and the new genera Verrucodesmus and Chodatodesmus (Chlorophyta, Chlorophyceae). Fottea Olomouc, 2013, 13: 149-164.

[26] Hill RW, Fanta SE. Phosphorous and light colimit growth at subsaturating irradiances. Freshwater Biol, 2008, 53: 215-225.

[27] Huang Y, Zheng Y, Li J, Liao Q, Fu Q, Xia A, Fu J, Sun Y. Enhancing microalgae biofilm formation and growth by fabricating microgrooves onto the substrate surface. Bioresour Technol, 2018, 261: 36-43.

[28] Hunt SM, Werner EM, Huang B, Hamilton MA, Stewart PS. Hypothesis for the role of nutrient starvation in biofilm detachment. Appl Environ Microbiol, 2004, 70: 7418-7425.

[29] Irving TE, Allen DG. Species and material considerations in the formation and development of microalgal biofilms. Appl Microbiol Biotechnol, 2011, 92: 283-294.

[30] Johnson MB, Wen Z. Development of an attached microalgal growth system for biofuel production. Appl Microbiol Biotechnol, 2010, 85: 525-534.

[31] Katarzyna L, Sai G, Singh OA. Non-enclosure methods for non-suspended microalgae cultivation: literature review and research needs. RenewSust Energ Rev, 2015, 42: 1418-1427.

[32] Kebede-Westhead E, Pizarro C, Mulbry WW. Treatment of swine manure effluent using freshwater algae: production, nutrient recovery, and elemental composition of algal biomass at four effluent loading rates. J Appl Phycol, 2006, 18: 41-46.

[33] Kesaano M, Sims RC. Algal biofilm based technology for wastewater treatment. Algal Res, 2014, 5: 231-240.

[34] La Russa M (2009) Green algae selection useful for phycoremediation of olive-mill wastewaters and increase of their lipid content by genetic engineering. Ph.D., Department of Biology, University of Naples “Federico II”, Napoli, Italy

[35] Li X, Hu H, Gan K, Sun Y. Effects of different nitrogen and phosphorus concentrations on the growth, nutrient uptake, and lipid accumulation of a freshwater microalga Scenedesmus sp. Bioresour Technol, 2010, 101: 5494-5500.

[36] Liu T, Wang J, Hu Q, Cheng P, Ji B, Liu J, Chen Y, Zhang W, Chen X, Chen L, Gao L, Ji C, Wang H. Attached cultivation technology of microalgae for efficient biomass feedstock production. Bioresour Technol, 2013, 127: 216-222.

[37] Mata TM, Martins AA, Caetano NS. Microalgae for biodiesel production and other applications: a review. RenewSust Energ Rev, 2010, 14: 217-232.

[38] Matos ÂP, Brasileiro F, de Oliveira Torres RC, Ito Morioka LR, Machado Canella MH, Rotta J, da Silva T, Siegel Moecke EH, Sant’Anna ES. Optimization of biomass production of Chlorella vulgaris grown in desalination concentrate. J Appl Phycol, 2015, 27: 1473-1483.

[39] Matsumoto T, Yamamura H, Hayakawa J, Watanabe Y, Harayama S. Influence of extracellular polysaccharides (EPS) produced by two different green unicellular algae on membrane filtration in an algae-based biofuel production process. Water Sci Technol, 2014, 69: 1919-1925.

[40] Mattei MR, Frunzo L, D’Acunto B, Pechand Y, Pirozzi F, Esposito G. Continuum and discrete approach in modeling biofilm development and structure: a review. J Math Biol, 2018, 76: 945-1003.

[41] Moheimani NR, Borowitzka MA, Isdepsky A, FonSing S. Borowitzka MA, Moheimani NR. Standard methods for measuring growth of algae and their composition. Algae for biofuels and Energy, 2013, Dordrecht: Springer, 265-284.

[42] Molina Grima E, Belarbia E-H, Acién Fernández FG, Robles Medinaa A, Chisti Y. Recovery of microalgal biomass and metabolites:process options and economics. Biotechnol Adv, 2003, 20: 491-515.

[43] Moreno Osorio JH, Luongo V, Del Mondo A, Pinto G, Frunzo L, Lens PNL, Esposito G. Nutrient removal from high strength nitrate containing industrial wastewater using Chlorella sp. strain ACUF_802. Ann Microbiol, 2018, 68: 899-913.

[44] Muñoz R, Kollner C, Guieysse B. Biofilm photobioreactors for the treatment of industrial wastewaters. J Hazard Mater, 2009, 161: 29-34.

[45] Naumann T, Çebi Z, Podola B, Melkonian M. Growing microalgae as aquaculture feeds on twin-layers: a novel solid-state photobioreactor. J Appl Phycol, 2013, 25: 1413-1420.

[46] Nayak M, Rath SS, Thirunavoukkarasu M, Panda PK, Mishra BK, Mohanty RC. Maximizing biomass productivity and CO₂ biofixation of microalga, Scenedesmus sp. by using sodium hydroxide. J Microbiol Biotechnol, 2013, 23: 1260-1268.

[47] Ozkan A, Berberoglu H. Cell to substratum and cell to cell interactions of microalgae. Colloids Surf B Biointerfaces, 2013, 112: 302-309.

[48] Ozkan A, Kinney K, Katz L, Berberoglu H. Reduction of water and energy requirement of algae cultivation using an algae biofilm photobioreactor. Bioresour Technol, 2012, 114: 542-548.

[49] Powell N, Shilton A, Chisti Y, Pratt S. Towards a luxury uptake process via microalgae—defining the polyphosphate dynamics. Water Res, 2009, 43: 4207-4213.

[50] Prajapati SK, Kaushik P, Malik A, Vijay VK. Phycoremediation coupled production of algal biomass, harvesting and anaerobic digestion: possibilities and challenges. Biotechnol Adv, 2013, 31: 1408-1425.

[51] Qureshi N, Annous BA, Ezeji TC, Karcher P, Maddox IS. Biofilm reactors for industrial bioconversion processes: employing potential of enhanced reaction rates. Microb Cell Fact, 2005, 4: 24.

[52] Rajendran A, Hu B. Mycoalgae biofilm: development of a novel platform technology using algae and fungal cultures. Biotechnol Biofuels, 2016, 9: 112.

[53] Romaní AM, Fund K, Artigas J, Schwartz T, Sabater S, Obst U. Relevance of polymeric matrix enzymes during biofilm formation. Microb Ecol, 2008, 56: 427-436.

[54] Schnurr PJ, Espie GS, Allen DG. Algae biofilm growth and the potential to stimulate lipid accumulation through nutrient starvation. Bioresour Technol, 2013, 136: 337-344.

[55] Schumacher G, Sekoulov I. Polishing of secondary effluent by an algal biofilm process. Water Sci Technol, 2002, 46: 83-90.

[56] Shen Y, Xu X, Zhao Y, Lin X. Influence of algae species, substrata and culture conditions on attached microalgal culture. Bioprocess Biosyst Eng, 2014, 37: 441-450.

[57] Shen Y, Zhang H, Xu X, Lin X. Biofilm formation and lipid accumulation of attached culture of Botryococcus braunii. Bioprocess Biosyst Eng, 2015, 38: 481-488.

[58] Shi J, Podola B, Melkonian M. Removal of nitrogen and phosphorus from wastewater using microalgae immobilized on twin layers: an experimental study. J Appl Phycol, 2007, 19: 417-423.

[59] Silva-Aciares FR, Riquelme CE. Comparisons of the growth of six diatom species between two configurations of photobioreactors. Aquacult Eng, 2008, 38: 26-35.

[60] Singha TK. Microbial extracellular polymeric substances: production, isolation and applications. IOSR J Pharm, 2012, 2: 276-281.

[61] Sirmerova M, Prochazkova G, Siristova L, Kolska Z, Branyik T. Adhesion of Chlorella vulgaris to solid surfaces, as mediated by physicochemical interactions. J Appl Phycol, 2013, 25: 1687-1695.

[62] Spolaore P, Joannis-Cassan C, Duran E, Isambert A. Commercial applications of microalgae. J Biosci Bioeng, 2006, 101: 87-96.

[63] Tam NFY, Lau PS, Wong YS. Wastewater inorganic N removal and P removal by immobilized Chlorella vulgaris. Water Sci Technol, 1994, 30: 369-374.

[64] Toninelli AE, Wang J, Liu M, Wu H, Liu T. Scenedesmus dimorphus biofilm: photoefficiency and biomass production under intermittent lighting. Sci Rep, 2016, 6: 32305.

[65] Wei Q, Hu Z, Li G, Xiao B, Sun H, Tao M. Removing nitrogen and phosphorus from simulated wastewater using algal biofilm technique. Front Environ Sci Eng, 2008, 2: 446-451.

[66] Wildman RB, Benner BL, Held DD, Schauberger CW. Influence of blue-green algae on the pH and buffer capacity of culture media. Proc Iowa Acad Sci, 1974, 81: 192-196.

[67] Wilkie AC, Mulbry WW. Recovery of dairy manure nutrients by benthic freshwater algae. Bioresour Technol, 2002, 84: 81-91.

[68] Wolfstein K, Stal JL. Production of extracellular polymeric substances (EPS) by benthic diatoms: effect of irradiance and temperature. Mar Ecol Prog Ser, 2002, 236: 13-22.

[69] Xiao R, Zheng Y. Overview of microalgal extracellular polymeric substances (EPS) and their applications. Biotechnol Adv, 2016, 34: 1225-1244.

[70] Yan C, Luo X, Zheng Z. Effects of various LED light qualities and light intensity supply strategies on purification of slurry from anaerobic digestionprocess by chlorella vulgaris. Int Biodeterior Biodegradation, 2013, 79: 81-87.

[71] Young AM. Zeolite-Based agae biofilm rotating photobioreactor for algae and biomass production Mster of Science, Biological Engineering, 2011, Utah: Utah State University.

[72] Zamalloa C, Boon N, Verstraete W. Decentralized two-stage sewage treatment by chemical–biological flocculation combined with microalgae biofilm for nutrient immobilization in a roof installed parallel plate reactor. Bioresour Technol, 2013, 130: 152-160.

[73] Zhang H, Kuang Y, Zhe L, Liu C. Influence on surface characteristics of microalgae cell by solution chemistry. Adv Mater Res, 2011, 287–290: 1938-1942.

[74] Zheng Y, Huang Y, Liao Q, Fu Q, Xia A, Zhu X. Impact of the accumulation and adhesion of released oxygen during Scenedesmus obliquus photosynthesis on biofilm formation and growth. Bioresour Technol, 2017, 244: 198-205.

Funding

Erasmus Mundus Joint Doctorate: ETeCoS3(FPA no. 2010-0009)