The conversion and migration behavior of phosphorus speciation during pyrolysis of different sludges

i

This article has been updated. A Correction to this article was published on .

i

The Original Article was published on

i

The Original Article was published on

i

This article has been updated

i

This article was retracted on

i

This article has been updated

Abstract

The study was enforced to probe the conversion and migration behavior of phosphorus speciation in sludge and the biochar received from pyrolysis of municipal sludge (MS), town sludge (TS), and slaughterhouse sludge (SS). This study creatively used fractionation of soil phosphorus to further differentiate speciation of phosphorus in three sludges (MS, TS, and SS). According to the x-ray diffraction (XRD) analysis and sequential extraction, the study proved the dependence of P speciation conversion on pyrolysis temperature and different types of raw sludge. The results of P-fractionation indicated that Ca-bound IP (Ca-IP) content in all biochars significantly increased at pyrolysis temperature of 350–800 °C, and the proportion of soluble and loosely bound IP (SL-IP), aluminum-bound IP (Al-IP), and Fe-bound IP (Fe-IP) of MS and SS decreased. The difference is that the Al-IP in the TS increased slightly as the pyrolysis temperature increased. Among the three kinds of sludge, the Olsen-P of TS is the lowest because the content of Olsen-P in sludge will decrease with the decrease of pH in the process of sewage treatment after acidification. In addition, XRD patterns of three sludges and biochar further confirmed the low crystallinity of AlPO₄ minerals. Through in-depth research on the environmental behavior of phosphorus, this study might additionally provide essential knowledge for the recovery and utilization of phosphorus in sludge.

Keywords

sludges / pyrolysis / phosphorus / speciation / biochars / minerals

CHANGE HISTORY

A Correction to this paper has been published:
https://doi.org

The Retraction Note was updated to reflect reception of statements of disagreement from all authors.

This article has been retracted.Please see the Retraction Notice for more detail:
https://doi.org

References

[1] Wu Q, Zou D, Zheng X, et al. (2022) Effects of antibiotics on anaerobic digestion of sewage sludge: Performance of anaerobic digestion and structure of the microbial community. Sci Total Environ 845: 157384. https://doi.org/10.1016/j.scitotenv.2022.157384

[2] Keeffe AO, Brooks E, Dunkel C, et al. (2023) Soil moisture routing modeling of targeted biochar amendment in undulating topographies : an analysis of biochar ’ s effects on streamflow. AIMS Environ Sci 10: 529-546. https://doi.org/10.3934/environsci.2023030

[3] Guo Y, Guo Y, Gong H, et al. (2021) Variations of heavy metals, nutrients, POPs and particle size distribution during ‘sludge anaerobic digestion-solar drying-land utilization process’: Case study in China. Sci Total Environ 801: 149609. https://doi.org/10.1016/j.scitotenv.2021.149609

[4] Feng H, Zheng M, Dong H, et al. (2015) Three-dimensional honeycomb-like hierarchically structured carbon for high-performance supercapacitors derived from high-ash-content sewage sludge. J Mater Chem A 3: 15225-15234. https://doi.org/10.1039/C5TA03217B

[5] Yuan S-J, Dai X-H (2015) Heteroatom-doped porous carbon derived from “all-in-one” precursor sewage sludge for electrochemical energy storage. RSC Adv 5: 45827-45835. https://doi.org/10.1039/C5RA07178J

[6] Zhang J, Lü F, Zhang H, et al. (2015) Multiscale visualization of the structural and characteristic changes of sewage sludge biochar oriented towards potential agronomic and environmental implication. Sci Rep 5: 9406. https://doi.org/10.1038/srep09406

[7] Yue Y, Cui L, Lin Q, et al. (2017) Efficiency of sewage sludge biochar in improving urban soil properties and promoting grass growth. Chemosphere 173: 551-556. https://doi.org/10.1016/j.chemosphere.2017.01.096

[8] Fang S, Tsang DCW, Zhou F, et al. (2016) Stabilization of cationic and anionic metal species in contaminated soils using sludge-derived biochar. Chemosphere 149: 263-271. https://doi.org/10.1016/j.chemosphere.2016.01.060

[9] Rathnayake N, Patel S, Halder P, et al. (2022) Co-pyrolysis of biosolids with alum sludge: Effect of temperature and mixing ratio on product properties. J Anal Appl Pyrolysis 163: 105488. ttps://doi.org/10.1016/j.jaap.2022.105488

[10] Zielińska A, Oleszczuk P (2016) Attenuation of phenanthrene and pyrene adsorption by sewage sludge-derived biochar in biochar-amended soils. Environ Sci Pollut Res 23: 21822-21832. tps://doi.org/10.1007/s11356-016-7382-x

[11] Zielińska A, Oleszczuk P (2016) Bioavailability and bioaccessibility of polycyclic aromatic hydrocarbons (PAHs) in historically contaminated soils after lab incubation with sewage sludge-derived biochars. Chemosphere. https://doi.org/10.1016/j.chemosphere.2016.08.072

[12] Mayer BK, Baker LA, Boyer TH, et al. (2016) Total Value of Phosphorus Recovery. Environ Sci Technol 50: 6606-6620. https://doi.org/10.1021/acs.est.6b01239

[13] Hossain MK, Strezov Vladimir V, Chan KY, et al. (2011) Influence of pyrolysis temperature on production and nutrient properties of wastewater sludge biochar. J Environ Manage 92: 223-228. https://doi.org/10.1016/j.jenvman.2010.09.008

[14] Khan S, Chao C, Waqas M, et al. (2013) Sewage sludge biochar influence upon rice (Oryza sativa L) yield, metal bioaccumulation and greenhouse gas emissions from acidic paddy soil. Environ Sci Technol 47: 8624-8632. https://doi.org/10.1021/es400554x

[15] Moško J, Pohořelý M, Skoblia S, et al. (2021) Structural and chemical changes of sludge derived pyrolysis char prepared under different process temperatures. J Anal Appl Pyrolysis 156: 105085. https://doi.org/10.1016/j.jaap.2021.105085

[16] Liu Q-S, Tian T (2021) Co-pyrolysis of iron-rich sewage sludge and potassium phosphate to prepare biochars: P fractionation and alleviated occlusion. J Anal Appl Pyrolysis 159: 105285. https://doi.org/10.1016/j.jaap.2021.105285

[17] Tang S, Liang J, Xu X, et al. (2023) Targeting phosphorus transformation to hydroxyapatite through sewage sludge pyrolysis boosted by quicklime toward phosphorus fertilizer alternative with toxic metals compromised. Renew Sustain Energy Rev. https://doi.org/10.2139/ssrn.4416963

[18] Wisawapipat W, Charoensri K, Runglerttrakoolchai J (2017) Solid-phase speciation and solubility of phosphorus in an acid sulfate paddy soil during soil reduction and reoxidation as affected by oil palm ash and biochar. J Agric Food Chem 65: 704-710. https://doi.org/10.1021/acs.jafc.6b03925

[19] Huang R, Tang Y (2015) Speciation Dynamics of Phosphorus during (Hydro)Thermal Treatments of Sewage Sludge. ACS Publ 49: 14466-14474. https://doi.org/10.1021/acs.est.5b04140

[20] Chakraborty D, Nair VD, Harris WG (2012) Compositional differences between alaquods and paleudults affecting phosphorus sorption-desorption behavior. Soil Sci 177: 188-197. https://doi.org/10.1097/SS.0b013e31824329ca

[21] Pant H, Reddy K . (2003) Potential internal loading of phosphorus in a wetland constructed in agricultural land. Water Res 37: 965-972. https://doi.org/10.1016/S0043-1354(02)00474-8

[22] Qin B, Zhou J, Elser JJ, et al. (2020) Water Depth Underpins the Relative Roles and Fates of Nitrogen and Phosphorus in Lakes. Environ Sci Technol 54: 3191-3198. https://doi.org/10.1021/acs.est.9b05858

[23] Qian TT, Jiang H (2014) Migration of phosphorus in sewage sludge during different thermal treatment processes. ACS Sustain Chem Eng 2: 1411-1419. https://doi.org/10.1021/sc400476j

[24] Hamdan R, El-Rifai HM, Cheesman AW, et al. (2012) Linking Phosphorus Sequestration to Carbon Humification in Wetland Soils by 31 P and 13 C NMR Spectroscopy. Environ Sci Technol 46: 4775-4782. https://doi.org/10.1021/es204072k

[25] McDowell RW, Condron LM, Mahieu N, et al. (2002) Analysis of Potentially Mobile Phosphorus in Arable Soils Using Solid State Nuclear Magnetic Resonance. J Environ Qual 31: 450-456. https://doi.org/10.2134/jeq2002.4500

[26] Sharpley AN, McDowell RW, Kleinman PJA (2004) Amounts, Forms, and Solubility of Phosphorus in Soils Receiving Manure. Soil Sci Soc Am J 68: 2048-2057. https://doi.org/10.2136/sssaj2004.2048

[27] Chang SC, Jackson ML (1957) Fractionation of soil phosphorus. Soil Sci. https://doi.org/10.1097/00010694-195708000-00005

[28] Kleemann R, Chenoweth J, Clift R, et al. (2017) Comparison of phosphorus recovery from incinerated sewage sludge ash (ISSA) and pyrolysed sewage sludge char (PSSC). Waste Manag. ttps://doi.org/10.1016/j.wasman.2016.10.055

[29] Fang Z, Liu F, Li Y, et al. (2021) Influence of microwave-assisted pyrolysis parameters and additives on phosphorus speciation and transformation in phosphorus-enriched biochar derived from municipal sewage sludge. J Clean Prod 287. https://doi.org/10.1016/j.jclepro.2020.125550

[30] Shao J, Yuan X, Leng L, et al. (2015) The comparison of the migration and transformation behavior of heavy metals during pyrolysis and liquefaction of municipal sewage sludge, paper mill sludge, and slaughterhouse sludge. Bioresour Technol 198: 16-22. https://doi.org/10.1016/j.biortech.2015.08.140

[31] Zeng X, Xiao Z, Zhang G, et al. (2018) Speciation and bioavailability of heavy metals in pyrolytic biochar of swine and goat manures, Elsevier B.V. https://doi.org/10.1016/j.jaap.2018.03.012

[32] Backnäs S, Laine-Kaulio H, Kløve B (2012) Phosphorus forms and related soil chemistry in preferential flowpaths and the soil matrix of a forested podzolic till soil profile. Geoderma 189-190: 50-64. https://doi.org/10.1016/j.geoderma.2012.04.016

[33] Anal C (1962) Amodified single solution method for the determination of phosphate in natural waters. Anal Chim Acta 8: 31-36. https://doi.org/10.1016/S0003-2670(00)88444-5

[34] Fife C V . (1959) An evaluation of ammonium fluoride as a selective extractant for aluminum-bound soil phosphate: II. Preliminary studies on soils. Soil Sci. https://doi.org/10.1097/00010694-195902000-00004

[35] Xiao Z, Yuan X, Li H, et al. (2015) Chemical speciation, mobility and phyto-accessibility of heavy metals in fly ash and slag from combustion of pelletized municipal sewage sludge. Sci Total Environ 536: 774-783. https://doi.org/10.1016/j.scitotenv.2015.07.126

[36] Romero-Freire A, Martin Peinado FJ, van Gestel CAM (2015) Effect of soil properties on the toxicity of Pb: Assessment of the appropriateness of guideline values. J Hazard Mater 289: 46-53. https://doi.org/10.1016/j.jhazmat.2015.02.034

[37] Fang Z, Liu F, Li Y, et al. (2021) Influence of microwave-assisted pyrolysis parameters and additives on phosphorus speciation and transformation in phosphorus-enriched biochar derived from municipal sewage sludge. J Clean Prod 287: 125550. https://doi.org/10.1016/j.jclepro.2020.125550

[38] Xu G, Zhang Y, Shao H, et al. (2016) Pyrolysis temperature affects phosphorus transformation in biochar: Chemical fractionation and 31P NMR analysis. Sci Total Environ 569-570: 65-72. https://doi.org/10.1016/j.scitotenv.2016.06.081

[39] Cantrell KB, Hunt PG, Uchimiya M, et al. (2012) Impact of pyrolysis temperature and manure source on physicochemical characteristics of biochar. Bioresour Technol 107: 419-428. https://doi.org/10.1016/j.biortech.2011.11.084

[40] Wang T, Camps-Arbestain M, Hedley M, et al. (2012) Predicting phosphorus bioavailability from high-ash biochars. Plant Soil 357: 173-187. https://doi.org/10.1007/s11104-012-1131-9

[41] Huang R, Fang C, Lu X, et al. (2017) Transformation of Phosphorus during (Hydro)thermal Treatments of Solid Biowastes: Reaction Mechanisms and Implications for P Reclamation and Recycling. Environ Sci Technol 51: 10284-10298. https://doi.org/10.1021/acs.est.7b02011

[42] Kuroda A, Takiguchi N, Gotanda T, et al. (2002) A simple method to release polyphosphate from activated sludgefor phosphorus reuse and recycling. Biotechnol Bioeng. https://doi.org/10.1002/bit.10205

[43] Liu Q, Fang Z, Liu Y, et al. (2019) Phosphorus speciation and bioavailability of sewage sludge derived biochar amended with CaO. Waste Manag 87: 71-77. https://doi.org/10.1016/j.wasman.2019.01.045

[44] Steckenmesser D, Vogel C, Adam C, et al. (2017) Effect of various types of thermochemical processing of sewage sludges on phosphorus speciation, solubility, and fertilization performance. Waste Manag 62: 194-203. https://doi.org/10.1016/j.wasman.2017.02.019

[45] Li R, Wang JJ, Zhou B, et al. (2016) Enhancing phosphate adsorption by Mg/Al layered double hydroxide functionalized biochar with different Mg/Al ratios. Sci Total Environ 559: 121-129. https://doi.org/10.1016/j.scitotenv.2016.03.151

[46] Zhang Q, Liu H, Li W, et al. (2012) Behavior of phosphorus during co-gasification of sewage sludge and coal, Energy and Fuels. https://doi.org/10.1021/ef300006d

[47] Nanzer S, Oberson A, Huthwelker T, et al. (2014) The Molecular Environment of Phosphorus in Sewage Sludge Ash: Implications for Bioavailability. J Environ Qual. https://doi.org/10.2134/jeq2013.05.0202

[48] Adhikari S, Gascó G, Méndez A, et al. (2019) Science of the Total Environment In fl uence of pyrolysis parameters on phosphorus fractions of biosolids derived biochar. Sci Total Environ 695: 133846. https://doi.org/10.1016/j.scitotenv.2019.133846

[49] Li J, Li Y, Liu F, et al. (2023) Pyrolysis of sewage sludge to biochar: Transformation mechanism of phosphorus. J Anal Appl Pyrolysis 173: 106065. https://doi.org/10.1016/j.jaap.2023.106065

[50] Frossard E, Bauer JP, Lothe F (1997) Evidence of vivianite in FeSO4 - Flocculated sludges. Water Res. https://doi.org/10.1016/S0043-1354(97)00101-2

[51] Huang X-L, Shenker M (2004) Water-Soluble and Solid-State Speciation of Phosphorus in Stabilized Sewage Sludge. J Environ Qual. https://doi.org/10.2134/jeq2004.1895

[52] Li S, Zeng W, Jia Z, et al. (2020) Phosphorus species transformation and recovery without apatite in FeCl3-assisted sewage sludge hydrothermal treatment. Chem Eng J 399: 125735. https://doi.org/10.1016/j.cej.2020.125735

[53] Huang R, Tang Y (2016) Evolution of phosphorus complexation and mineralogy during (hydro)thermal treatments of activated and anaerobically digested sludge: Insights from sequential extraction and P K-edge XANES. Water Res 100: 439-447. https://doi.org/10.1016/j.watres.2016.05.029

[54] Wang Y, Lin Y, Chiu PC, et al. (2015) Phosphorus release behaviors of poultry litter biochar as a soil amendment. Sci Total Environ 512-513: 454-463. https://doi.org/10.1016/j.scitotenv.2015.01.093

[55] Christel W, Bruun S, Magid J, et al. (2014) Phosphorus availability from the solid fraction of pig slurry is altered by composting or thermal treatment. Bioresour Technol 169: 543-551. https://doi.org/10.1016/j.biortech.2014.07.030

[56] Thygesen AM, Wernberg O, Skou E, et al. (2011) Effect of incineration temperature on phosphorus availability in bio-ash from manure. Environ Technol 32: 633-638. https://doi.org/10.1080/09593330.2010.509355

[57] Cantrell KB, Hunt PG, Uchimiya M, et al. (2012) Impact of pyrolysis temperature and manure source on physicochemical characteristics of biochar. Bioresour Technol 107: 419-428. https://doi.org/10.1016/j.biortech.2011.11.084