Starter-generator sets of modern vehicles

V. N. Kagdin , R. A. Maleyev , A. N. Zimin , S. M. Zuyev , D. R. Yakhutl'

Izvestiya MGTU MAMI ›› 2021, Vol. 15 ›› Issue (4) : 27 -32.

PDF
Izvestiya MGTU MAMI ›› 2021, Vol. 15 ›› Issue (4) : 27 -32. DOI: 10.31992/2074-0530-2021-50-4-27-32
Original Study Articles
research-article

Starter-generator sets of modern vehicles

Author information +
History +
PDF

Abstract

This article describes the purpose and applications of the starter generator set. The modes of operation of a starter-generator set are considered both as a sequential excitation direct current electric motor, which rotates the shaft of an internal combustion engine, and as a generator, when an electric machine operates as a direct current source of independent excitation, supplying power to electric control circuits, electric motors of auxiliary electrical equipment, lighting and battery charging. Additional functions of a starter-generator set in the form of a start-stop system, regenerative braking, booster acceleration of a vehicle, damping of torsional moments of the shaft of an internal combustion engine and control of energy flows in the on-board network were studied.

The choice and substantiation of the optimal scheme, as well as the design of the starter-generator device, were carried out. The main technical and economic parameters of the starter-generator set were determined. The design of a starter-generator set was presented. This design is a reversible electric machine. A block diagram of a starter-generator set was developed.

Electrical machines used for starter-generator sets are considered. The design of an asynchronous machine with a squirrel-cage rotor, a synchronous machine with electromagnetic excitation, a valve machine with permanent magnets, a contactless machine, a synchronous machine with permanent magnets, and a valve machine with self-excitation are described. A review and analysis of electrical machines used in starter-generator sets of leading foreign companies is carried out.

The design of a reversible induction-dynamic machine is considered. The rotor rotates outside, and not inside the motor and is a short-circuited winding with a cast aluminum cage. The calculation of the main parameters of a reversible induction-dynamic machine was carried out both in the starting and in the generator modes. The calculation using a method similar to that of an induction motor was carried out.

Keywords

starter-generator set / recuperation / electric machine / internal combustion engine / induction-dynamic machine

Cite this article

Download citation ▾
V. N. Kagdin, R. A. Maleyev, A. N. Zimin, S. M. Zuyev, D. R. Yakhutl'. Starter-generator sets of modern vehicles. Izvestiya MGTU MAMI, 2021, 15(4): 27-32 DOI:10.31992/2074-0530-2021-50-4-27-32

登录浏览全文

4963

注册一个新账户 忘记密码

References

[1]

Teoriya, konstruktsiya, raschet avtotraktornogo elektrooborudovaniya [Theory, design, calculation of automotive electrical equipment]. Pod redaktsiyey Fesenko M.N. Moscow: Mashinostroyeniye Publ., 2006. 93 p.

[2]

Теория, конструкция, расчет автотракторного электрооборудования / Под редакцией Фесенко М.Н. М.: Машиностроение, 2006. 93 с.

[3]

Yutt V.E. Elektrooborudovaniye avtomobiley [Electrical equipment of vehicles]. Moscow: Transport Publ., 2019. 480 p.

[4]

Ютт В.Е. Электрооборудование автомобилей. М.: Транспорт, 2019. 480 с.

[5]

Akimov S.V., Zdanovskiy A.A., Korets A.M. i dr. Spravochnik po elektrooborudovaniyu avtomobiley [Au-tomobile electrical handbook]. Moscow: Mashinostroyeniye Publ., 2004. 120 p.

[6]

Акимов С.В., Здановский А.А., Корец А.М. и др. Справочник по электрооборудованию автомобилей. М.: Машиностроение, 2004. 120 с.

[7]

Akimov S.V., Chizhkov YU.P. Elektrooborudovaniye avtomobiley [Electrical equipment of vehicles]. Uchebnik dlya VUZov. Moscow: ZAO KZHI «Za rulеM» Publ., 2001. 234 p.

[8]

Акимов С.В., Чижков Ю.П. Электрооборудование автомобилей. Учебник для ВУЗов. М.: ЗАО КЖИ «За рулем», 2001. 234 с.

[9]

Gandzha S.A., Yerlysheva A.V. Starter-generator for autonomous power supply sources: Vestnik YUURGU, 2005. No 9, pp. 84−86 (in Russ.).

[10]

Ганджа С.А., Ерлышева А.В. Стартер-генератор для автономных источников электроснабжения-Ч.: Вестник ЮУрГУ, 2005. № 9. С. 84−86.

[11]

Konstruktsiya avtomobilya. Elektrooborudovaniye. Sistemy diagnostiki [Design of the automobile. Electri-cal equipment. Diagnostic systems]. Uchebnik dlya vuzov, pod redaktsiyey A.L. Karunina. Moscow, Izd. «Goryachaya liniya - TelekoM» Publ., 2005, 480 p.

[12]

Конструкция автомобиля. Электрооборудование. Системы диагностики. Учебник для вузов, под ре-дакцией А.Л. Карунина. М., Изд. «Горячая линия - Телеком», 2005, 480 с.

[13]

Nikolayev V.V. Starter-generator avtonomnykh ob"yektov .na osnove ventil'no-induktornoy mashiny. Dissertatsiya na soiskaniye uchenoy stepeni kandidata tekhnicheskikh nauk [Starter-generator of auton-omous objects based on a valve-inductor machine: Dissertation for Degree of PhD in Engineering]. Mos-cow: M·EI Publ., 2005. 142 p.

[14]

Николаев В.В. Стартер-генератор автономных объектов .на основе вентильно-индукторной маши-ны. Диссертация на соискание ученой степени кандидата технических наук. М.: МЭИ, 2005. 142 с.

[15]

Anisimov V.M. Avtomobil'nyy starter-generator s mikroprotsessornoy sistemoy upravleniya. Dissertatsiya na soiskaniye uchenoy stepeni kandidata tekhnicheskikh nauk [Automotive starter-generator with micro-processor control system: Dissertation for Degree of PhD in Engineering]. Yekaterinburg: UGTU Publ., 1997. 128 p.

[16]

Анисимов В.М. Автомобильный стартер-генератор с микропроцессорной системой управления. Диссертация на соискание ученой степени кандидата технических наук. Екатеринбург: УГТУ, 1997. 128 с.

[17]

Anisimov V.M. Elektromekhanicheskiye starter-generatorn·yye sistemy avtomobil'nykh transportnykh sredstv: Teoriya, proyektirovaniye, issledovaniye. Dissertatsiya na soiskaniye uchenoy doktora tekhnich-eskikh nauk [Electromechanical starter-generator systems of automotive vehicles: theory, design, re-search: Dissertation for Degree of DrSc in Engineering]. Samara: SaMGTU Publ., 2004. 378 p.

[18]

Анисимов В.М. Электромеханические стартер-генераторные системы автомобильных транспорт-ных средств: Теория, проектирование, исследование. Диссертация на соискание ученой доктора технических наук. Самара: СамГТУ, 2004. 378 с.

RIGHTS & PERMISSIONS

Kagdin V.N., Maleyev R.A., Zimin A.N., Zuyev S.M., Yakhutl' D.R.

AI Summary AI Mindmap
PDF

137

Accesses

0

Citation

Detail

Sections
Recommended

AI思维导图

/