Development of a methodology for rationing the route fuel consumption of the LIAZ-5256.57 bus in operation

Abstract

The article analyzes suburban bus transportation on specific routes in the Republic of Sakha (Yakutia). Route No. 101 Yakutsk – Tabaga with a total length of 31 km was chosen for the experimental study. The timetable for the movement of buses of the municipal unitary enterprise Yakutsk Passenger Transport Enterprise (YAPAK) on the suburban route is given. The main technical data of the LiAZ-5256.57 bus were studied. In accordance with international rules for buses, the determination of the amount of fuel consumption and specific emissions of normalized toxic components is carried out using a driving cycle on working drums. A technique to calculate fuel consumption is used for modeling engine performance indicators that provide a change in the traction and speed characteristics of the vehicle in accordance with the established driving cycle. The calculated fuel consumption results for the NEDC driving cycle are compared with experimental data. As a comparison of calculated and theoretical data on fuel consumption with practical data, a Cummins type CG 250 engine is considered. The internal combustion engine is installed on the LiAZ-5256.57 bus. Experimental data on the fuel consumption of this bus per 100 kilometers (km) showed 49 nm³, and theoretical calculations of the fuel consumption of the bus per 100 km using the proposed method showed 48 nm³.

Thus, to assess the traction and speed characteristics of the bus, the proposed combined method can be used, which makes it possible to obtain a calculation of fuel consumption that is closer to the experimental data on the driving cycle. Based on the initial data of the vehicle, the effective performance of the engine is evaluated. A computational method for modeling tests and an experimental driving cycle for motor vehicles with a total mass of more than five tons are proposed.

Keywords

acceleration / deceleration / driving cycle / experiment / fuel consumption / commuter buses

References

[1] Turenko A.N., Abramchuk F.I., Poyda A.N. [i dr.] Automated test bench for research and development of a gas small-capacity high-speed internal combustion engine. Avtomobil’nyy transport. 2009. No 23, pp. 89−94 (in Russ.).

[2] Туренко А.Н., Абрамчук Ф.И., Пойда А.Н. [и др.] Автоматизированный стенд для исследования и доводки газового малолитражного быстроходного двигателя внутреннего сгорания // Автомобильный транспорт. 2009. № 23. С. 89−94.

[3] Lukanin V.N., Buslayev A.P., Trofimenko Yu.V., Yashina M.V. Avtotransportn·yye potoki i okruzhayushchaya sreda [Traffic flows and the environment]: [ucheb. posobiye dlya VUZov]. Moscow: INFRA-M Publ., 1998. 408 p.

[4] Луканин В.Н., Буслаев А.П., Трофименко Ю.В., Яшина М.В. Автотранспортные потоки и окружающая среда: [учеб. пособие для ВУЗов]. М.: ИНФРА-М, 1998. 408 с.

[5] Kanіlo P.M., Bey І.S., Rovens’kiy O.І. Avtomobіl’ ta navkolishnє seredovishche [Vehicle and environment]. KH.: Prapor Publ., 2000. 304 p.

[6] Каніло П.М., Бей І.С., Ровенський О.І. Автомобіль та навколишнє середовище. Х.: Прапор, 2000. 304 с.

[7] Gasparyants G.A. Konstruktsiya, osnovy teorii i rascheta avtomobilya [Design, basic theory and calculation of the vehicle]. Moscow: Mashinostroyeniye Publ., 1978.

[8] Гаспарянц Г.А. Конструкция, основы теории и расчета автомобиля. М.: Машиностроение, 1978.

[9] Abramchuk F.I., Kabanov A.N., Kuz’menko A.P., Lipinskiy M.S. Multi-criteria optimization of the parameters of the combustion process of a small-capacity automobile gas engine. Dvigateli vnutrennego sgoraniya. Khar’kov: NTU «KHPI», 2011. No 2, pp. 8−13 (in Russ.).

[10] Абрамчук Ф.И., Кабанов А.Н., Кузьменко А.П., Липинский М.С. Многокритериальная оптимизация параметров процесса сгорания малолитражного автомобильного газового двигателя // Двигатели внутреннего сгорания. Харьков: НТУ «ХПИ», 2011. № 2. С. 8−13.

[11] Glagolev N.M. Rabochiye protsessa dvigateley vnutrennego sgoraniya [Working processes of internal combustion engines]. Kiyev: gosudarstvennoye nauchno-tekhnicheskoye izdatel’stvo mashinostroitel’noy literatury Publ., 1950. 480 p.

[12] Глаголев Н.М. Рабочие процессы двигателей внутреннего сгорания. Киев: Государственное научно-техническое издательство машиностроительной литературы, 1950. 480 с.

[13] Andryukhіna O.S. Rozrobka sproshchenogo viprobuval’nogo tsiklu dlya perevіrki tekhnіchnogo stanu benzinovikh dvigunіv legkovikh avtomobіlіv v umovakh yekspluatatsії: dis. kand. tekhn. nauk [Development of a simplified test cycle to check the technical condition of gasoline engines of passenger vehicles in service conditions: Dissertation for Degree of PhD in Engineering]: 05.22.20. Kiїv, 2006. 171 p.

[14] Андрюхіна О.С. Розробка спрощеного випробувального циклу для перевірки технічного стану бензинових двигунів легкових автомобілів в умовах експлуатації: дис. ... канд. техн. наук: 05.22.20. Київ, 2006. 171 с.

[15] Lukanin V.N., Trofimenko Yu.V. Reducing environmental impacts during the operation of road transport. Itogi nauki i tekhniki. Moscow: VINITI Publ., 1996 (in Russ.).

[16] Луканин В.Н., Трофименко Ю.В. Снижение экологических нагрузок на окружающую среду при работе автомобильного транспорта // Итоги науки и техники. М.: ВИНИТИ, 1996.

[17] Filipkovskiy A.I. Sovershenstvovaniye rabochego protsessa dizeley tipa CHN 32/32 na osnove fizicheskogo i matematicheskogo modelirovaniya: dis. kand. tekhn. nauk [Improving the working process of diesel engines of ChN 32/32 type based on physical and mathematical modeling: Dissertation for Degree of PhD in Engineering]: 05.04.02. KH., 1988. 193 p.

[18] Филипковский А.И. Совершенствование рабочего процесса дизелей типа ЧН 32/32 на основе физического и математического моделирования: дис. ... канд. техн. наук: 05.04.02. Х., 1988. 193 с.

[19] Lukanin V.N., Trofimenko Yu.V. Reducing environmental impacts on the environment during the operation of road transport. Itogi nauki i tekhniki. Moscow: VINITI Publ., T. 19: Avtomobil’nyy i gorodskoy transport. 1996, pp. 90−110 (in Russ.).

[20] Луканин В.Н., Трофименко Ю.В. Снижение экологических нагрузок на окружающую среду при работе автомобильного транспорта // Итоги науки и техники. М.: ВИНИТИ, Т. 19: Автомобильный и городской транспорт. 1996. С. 90−110.

[21] Kul’chitskiy A.I. Toksichnost’ avtomobil’nykh i traktornykh dvigateley [Toxicity of automobile and tractor engines]. Ucheb. Posobiye. Vladim. gos. un-t. Vladimir Publ., 2000. 256 p.

[22] Кульчицкий А.И. Токсичность автомобильных и тракторных двигателей: учеб. пособие / Владим. гос. ун-т. Владимир, 2000. 256 с.

[23] http://www.autoopt.ru/auto/encyclopedia/bus/liaz/mark/liaz-5256/

RIGHTS & PERMISSIONS

Boloyev P.A., Petrov N.V., Skrybykin P.A.