Strength evolution and deterioration law of cemented gangue backfill body in acid mine water

Abstract

Cemented gangue backfill technology is an important backfill mining method. However, the acid mine water environment could seriously affect the strength of the cemented gangue backfill body (CGBB). In this study, CGBB specimens were placed in different environments (air, water, H₂SO₄ solution, and H₂SO₄ solution coupled with load) to test the strength, resistivity, and ultrasonic pulse velocity (UPV) of CGBB at different ages. The acoustic emission (AE) energy of the specimens during loading was monitored, and the microstructure was analyzed by scanning electron microscopy (SEM) and X-ray diffraction (XRD). Test results showed that: 1) The strength of CGBB cured in air and water gradually slowed down with age. The strength of CGBB in the H₂SO₄ solution was greater than that of CGBB cured in air or water in the first 90 d. The strength of CGBB under the coupling of the H₂SO₄ solution and load decreased more slowly with age than that of the single H₂SO₄ solution; 2) The resistivity and UPV had a good corresponding relationship with the strength of the CGBB. The failure modes of the CGBB after erosion were various, and the CGBB showed different AE energy characteristics at different stages of loading. The surge of AE energy could be used as a precursor to the failure of CGBB; 3) Erosion products compacted CGBB in the early stages and improved its strength. In the later stage, the CGBB cracked under the action of expansion stress and the strength decreased. Applying a 40% stress-to-strength ratio would resist the erosion of the H₂SO₄ solution. The research could provide a reference for the design of the corrosion resistance of CGBB.

Keywords

acid mine water / cemented gangue backfill body / deterioration law / resistivity / ultrasonic pulse velocity / acoustic emission energy / microstructure

References

[1] WangY-m, WuJ-y, PuH, et al. . Effect of interface geometric parameters on the mechanical properties and damage evolution of layered cemented gangue backfill: Experiments and models. Construction and Building Materials, 2022, 349: 128678 J]

[2] LiB-y, ZhangJ-x, YanH, et al. . Experimental investigation into the thermal conductivity of gangue-cemented paste backfill in mine application. Journal of Materials Research and Technology, 2022, 161792-1802 J]

[3] FengG-r, RanH-y, GuoJ, et al. . Experimental investigation on the deformation and strength properties of cemented gangue backfill column under long-term axial compression. Structures, 2022, 43: 1558-1572 J]

[4] JinJ-x, QinZ-f, LuX-l, et al. . Rheology control of self-consolidating cement-tailings grout for the feasible use in coal gangue-filled backfill. Construction and Building Materials, 2022, 316: 125836 J]

[5] WangY-m, WuJ-y, MaD, et al. . Effect of aggregate size distribution and confining pressure on mechanical property and microstructure of cemented gangue backfill materials. Advanced Powder Technology, 2022, 33(8): 103686 J]

[6] FengG-r, WangZ-h, QiT-y, et al. . Effect of velocity on flow properties and electrical resistivity of cemented coal gangue-fly ash backfill (CGFB) slurry in the pipeline. Powder Technology, 2022, 396191-209 J]

[7] WaldemarK, KatarzynaP M, KrzysztofS. The idea of the recovery of municipal solid waste incineration (MSWI) residues in Klodawa Salt Mine S. A. by filling the excavations with self-solidifying mixtures. Archives of Mining Sciences, 2018, 63(3): 553-565[J]

[8] RanH-y, GuoY-x, FengG-r, et al. . Creep properties and resistivity-ultrasonic-AE responses of cemented gangue backfill column under high-stress area. International Journal of Mining Science and Technology, 2021, 31(3): 401-412 J]

[9] QiuJ-s, ChengK, ZhangR-y, et al. . Study on the influence mechanism of activated coal gangue powder on the properties of filling body. Construction and Building Materials, 2022, 345128071 J]

[10] IshakS A, HashimH. Effect of mitigation technologies on the total cost and carbon dioxide emissions of a cement plant under multi-objective mixed linear programming optimization. Chemical Engineering Research and Design, 2022, 186326-349 J]

[11] FengG-r, DuX-j, GuoY-x, et al. . Basic theory of constructional backfill mining and the underground space utilization concept. Journal of China Coal Society, 2019, 44(1): 74-84[J]

[12] DuX-j, FengG-r, QiT-y, et al. . Roof stability analyses of “water-preserved and water-stored” coal mining with constructional backfill mining. Journal of China Coal Society, 2019, 44(3): 820-829[J]

[13] WangL, WangY-s, ZhaoY-r, et al. . Experimental study on compressive strength and pore structure of nano-TiO₂. Journal of Inner Mongolia University of Technology (Natural Science Edition), 2022, 41(6): 549-555[J]

[14] XuW-b, LiuB, WuW-lu. Strength and deformation behaviors of cemented tailings backfill under triaxial compression. Journal of Central South University, 2021, 27(12): 3531-3543 J]

[15] FanW-z, WuW, MaQ-qiang. Interfacial modification and strength characteristics analysis of carbon fiber composites. Journal of Inner Mongolia University of Technology (Natural Science Edition), 2022, 41(4): 379-384[J]

[16] HuY-f, LiK-q, HanB, et al. . Strength development and optimization analysis of mixed aggregate backfill based on RSM-DF. Journal of Central South University (Science and Technology), 2022, 53(2): 620-630[J]

[17] GuoY-x, RanH-y, FengG-r, et al. . Effects of curing under step-by-step load on mechanical and deformation properties of cemented gangue backfill column. Journal of Central South University, 2020, 27(11): 3417-3435 J]

[18] DixitA, GengG-q, DuH-j, et al. . The role of age on carbon sequestration and strength development in blended cement mixes. Cement and Concrete Composites, 2022, 133: 104644 J]

[19] AbdulrahmanP I, BzeniD K. Bond strength evaluation of polymer modified cement mortar incorporated with polypropylene fibers. Case Studies in Construction Materials, 2022, 17e01387 J]

[20] LiX-r, BizzozeroJ, HesseC. Impact of C-S-H seeding on hydration and strength of slag blended cement. Cement and Concrete Research, 2022, 161106935 J]

[21] LiJ-c, ChangJ, WangT, et al. . Effects of phosphogypsum on hydration properties and strength of calcium aluminate cement. Construction and Building Materials, 2022, 347128398 J]

[22] ZhengZ-s, ZengC, TianC, et al. . Mesoscale numerical investigation on the size effect of concrete uniaxial compressive strength under different contact friction. Construction and Building Materials, 2022, 346128416 J]

[23] BenaventeD, MartinezJ, GalianaM J J, et al. . Estimation of uniaxial compressive strength and intrinsic permeability from ultrasounds in sedimentary stones used as heritage building materials. Journal of Cultural Heritage, 2022, 55346-355 J]

[24] FuQ, BuM-x, SuL, et al. . Dynamic triaxial compressive response and failure mechanism of basalt fiber-reinforced coral concrete. International Journal of Impact Engineering, 2021, 156: 103930 J]

[25] ZhangT-y, ZhangJ-m, ZhangQ, et al. . Compressive strength of cemented soil in pre-bored grouted planted piles under negative temperature environment. Transportation Geotechnics, 2022, 35100793 J]

[26] SunY-l, LiuQ-x, XuH-s, et al. . Influences of different modifiers on the disintegration of improved granite residual soil under wet and dry cycles. International Journal of Mining Science and Technology, 2022, 32(4): 831-845 J]

[27] LiF-h, WenT, LiJ-y, et al. . Ultrasonic-detected damage and bending behavior of reinforced PP-ECC beams after coupled action of freeze-thaw cycles and constant flexural load. Case Studies in Construction Materials, 2022, 17e01284 J]

[28] HuangY-g, WangG-y, RaoY-z, et al. . Influence of acid attack on physical characteristics of cemented tailings backfill. Geotechnical and Geological Engineering, 2021, 39(8): 5619-5631 J]

[29] XuG-z, FanK-g, WangK, et al. . Paste backfill corrosion mechanisms in chloride and sulfate environments. Minerals, 2022, 12(5): 12050551 J]

[30] YanB-q, KouameJ A, TannantD, et al. . Effect of fly ash on the mechanical properties of cemented backfill made with brine. Geotechnical and Geological Engineering, 2019, 237691-705 J]

[31] RenH, ZhuS-f, WangX-j, et al. . Study on issues and countermeasures in coal measures mine water resources exploitation and utilization. Coal Geology of China, 2020, 32(9): 9-20[J]

[32] ZhaoY-h, GuoY-x, FengG-r, et al. . Study on strength and deformation characteristics of cemented gangue backfill body under the coupling action of load and salt erosion. Construction and Building Materials, 2022, 342128003 J]

[33] KrzysztofS, WaldemarK, KatarzynaP M. Binding capability of ashes and dusts from municipal solid waste incineration with salt brine and geotechnical parameters of the cemented samples. Archives of Mining Sciences, 2018, 63(4): 903-918[J]

[34] HsiehM K, ChienS H, LiH, et al. . Corrosion control when using passively treated abandoned mine drainage as alternative makeup water for cooling systems. Water Environment Research, 2011, 83(9): 807-814 J]

[35] GuoY-x, WangP, FengG-r, et al. . Experimental study on diffusion process of sulfate ion in cemented gangue backfill material. Advances in Civil Engineering, 2020, 41-14[J]

[36] WangH-x, HouJ, WangJ-h, et al. . Experimental investigation of subsurface damage depth of lapped optics by fluorescent method. Journal of Central South University, 2018, 25(7): 1678-1689 J]

[37] ZhouG-p, LiA-q, LiJ-h, et al. . Test and numerical investigations on static and dynamic characteristics of extra-wide concrete self-anchored suspension bridge under vehicle loads. Journal of Central South University, 2017, 24(10): 2382-2395 J]

[38] ZhaoZ-ke. Review of non-destructive testing methods for defect detection of ceramics. Ceramics International, 2021, 147(4): 4389-4397 J]

[39] YouG-l, WangB-z, LiJ-l, et al. . The prediction of MOE of bamboo-wood composites by ANN models based on the non-destructive vibration testing. Journal of Building Engineering, 2022, 59: 105078 J]

[40] GuoP, WuS-c, JiangR-h, et al. . Damage characteristics of thermally treated granite under uniaxial compression: Insights from active and passive ultrasonic techniques. Journal of Central South University, 2022, 29(12): 4078-4093 J]

[41] MoY-x, XingJ-c, YueS-l, et al. . Dynamic properties of 3D printed cement mortar based on split hopkinson pressure bar testing. Cement and Concrete Composites, 2022, 130104520 J]

[42] WuJ-y, FengM-m, NiX-y, et al. . Aggregate gradation effects on dilatancy behavior and acoustic characteristic of cemented rockfill. Ultrasonics, 2019, 9279-92 J]

[43] XiangY, XieY-j, LongG-c, et al. . Hydration phase and pore structure evolution of hardened cement paste at elevated temperature. Journal of Central South University, 2021, 28(6): 1665-1678 J]

[44] WangH, ZhangA-l, ZhangL-c, et al. . Hydration process of rice husk ash cement paste and its corrosion resistance of embedded steel. Journal of Central South University, 2020, 11(27): 3464-3476 J]

[45] TafesseM, AlemuA S, LeeH K, et al. . Effect of chloride penetration on electrical resistivity of CNT-CF/cement composites and its application as chloride sensor for reinforced mortar. Cement and Concrete Composites, 2022, 133104662 J]

[46] GuoY-x, ZhaoY-h, WangS-w, et al. . Stress-strain-acoustic responses in failure process of coal rock with different height to diameter ratios under uniaxial compression. Journal of Central South University, 2021, 28(6): 1724-1736 J]

[47] GawelK, WennerS, EdvardsenL. Effect of carbonation on bulk resistivity of cement/carbon nanofiber composites. Construction and Building Materials, 2021, 305124794 J]

[48] WangC-l, CaoC, LiC-f, et al. . Experimental investigation on synergetic prediction of granite rockburst using rock failure time and acoustic emission energy. Journal of Central South University, 2022, 29(4): 1262-1273 J]

[49] ZhaoY-h, RanH-y, FengG-r, et al. . Damage evolution and failure characteristics of cemented gangue backfill body with different height-width ratios under uniaxial compression. Journal of Mining and Safety Engineering, 2022, 39(4): 647-682[J]

[50] DongH-z, FengG-r, GuoY-x, et al. . Pipe transportation characteristics of filling slurry in Xinyang mine. Journal of Mining and Safety Engineering, 2013, 30(6): 880-885[J]

[51] WangJ, FuJ-x, SongW-d, et al. . Mechanical behavior, acoustic emission properties and damage evolution of cemented paste backfill considering structural feature. Construction and Building Materials, 2020, 261119958 J]